MQ Power DCA300SSJU4F3 Operation Manual page 50

GENERAL INSPECTION
Prior to each use, the generator should be cleaned and
inspected for deficiencies. Check for loose, missing or
damaged nuts, bolts or other fasteners. Also check for
fuel, oil, and coolant leaks. Use Table 14 as a general
maintenance guideline Engine Side (Refer to the Engine
Instruction Manual)
Air Filter Dust Indicator
NOTICE
The air filter should not be changed until the indicator
reads "RED". Dispose of old air filter. It may not be
cleaned or reused.
The air filter indicator (Figure 64) is attached to the air filter.
When the air filter element is clogged, air intake restriction
becomes greater and the air filter indicator signal shows
RED. When indicator is red, replace filter immediately.
After changing the air filter, press the air filter indicator
button to reset.
PUSH BUTTON TO RESET
Figure 64. Air Filter Dust Indicator
AIR CLEANER
NOTICE
If the engine is operating in very dusty or dry grass
conditions, a clogged air cleaner will result. This can
lead to a loss of power, excessive carbon buildup in
the combustion chamber and high fuel consumption.
Change air cleaner more frequently if these conditions
exist.
Every 250 hours: Remove air cleaner element (Figure 65)
and clean the heavy duty paper element with light spray of
compressed air. Replace the air cleaner as needed.
This John Deere diesel engine is equipped with a
replaceable, high-density paper air cleaner element.
This air cleaner is also equipped with an inner element
(secondary) that is used as a backup filter should the
primary element becomes damaged.
PAGE 50 — DCA300SSJU4F2/F3 60 HZ GENERATOR • OPERATION MANUAL — REV. #2 (04/18/22)
25 INCHES H O
2
6.23 kPa
CAUTION
Wear protective equipment such as
approved safety glasses or face shields
and dust masks or respirators when
cleaning air filters with compressed air.
Primary and Secondary Air Cleaner Elements
1. Release the latches (Figure 65) that secures the cover
to the air cleaner body.
2. Remove the air cleaner cover and set aside.
3. Remove both the primary and secondary air cleaner
elements.
4. Check the air cleaner daily or before starting the engine.
5. Check for and correct heavy buildup of dirt and debris
along with loose or damaged components.
NOTICE
Operating the engine with loose or damaged air cleaner
components could allow unfiltered air into the engine
causing premature wear and failure.
6. To clean the primary element (paper air filter) as
referenced in (Figure 65), tap the filter element
several times on a hard surface to remove dirt, or blow
compressed air not to exceed 30 psi (207 kPa, 2.1
kgf/cm ) through the filter element from the inside out.
2
BODY
PRIMARY
AIR FILTER
ELEMENT
SECONDARY
BLOW COMPRESSED
AIR FROM THE
INSIDE OUT
Figure 65. Air Cleaner
7. Clean the secondary element (paper air filter) as
referenced in step 6.
8. Replace both elements if they are damaged or
excessively dirty.
MAINTENANCE
AIR FILTER
ELEMENT
AIR FILTER
LATCH
INDICATOR
EVACUATOR
VALVE
ARROW
MARK
(DUST PAN)