MQ Power DCA300SSJU4F3 Operation Manual page 40

FUEL CHECK
DANGER
Fuel spillage on a hot engine can cause
a fire or explosion. If fuel spillage occurs,
wipe up the spilled fuel completely to
prevent fire hazards. NEVER smoke
around or near the generator.
Refilling the Fuel System
CAUTION
ONLY properly trained personnel who have read
and understand this section should refill the fuel tank
system.
This generator has an internal fuel tank located inside the
enclosure (Figure 39). ALWAYS fill the fuel tank with clean
fresh #2 diesel fuel. DO NOT fill the fuel tank beyond its
capacity. Some units may be equipped with a fuel cell
mounted inside the trailer frame.
Pay attention to the fuel tank capacity when replenishing
fuel. The fuel tank cap must be closed tightly after filling.
Handle fuel in a safety container. If the container does
not have a spout, use a funnel. Wipe up any spilled fuel
immediately.
300
Figure 39. Internal Fuel Tank System
PAGE 40 — DCA300SSJU4F2/F3 60 HZ GENERATOR • OPERATION MANUAL — REV. #2 (04/18/22)
FUEL CAP
INTERNAL
FUEL TANK
INSPECTION/SETUP
Refueling Procedure:
WARNING
Diesel fuel and its vapors are dangerous
to your health and the surrounding
environment. Avoid skin contact and/or
inhaling fumes.
1. Level Tanks — Make sure fuel cells are level with the
ground. Failure to do so will cause fuel to spill from the
tank before reaching full capacity (Figure 40).
CAUTION
ALWAYS place trailer on firm level ground before
refueling to prevent spilling and maximize the amount
of fuel that can be pumped into the tank.
Level Ground
Figure 40. Only Fill on Level Ground
NOTICE
ONLY use #2 diesel fuel (ultra low sulfur diesel fuel)
when refueling.
2. Open the enclosure door and remove fuel cap and fill
tank as shown in Figure 41.
DIESEL
FUEL
Figure 41. Fueling the Generator
DO NOT fill on
=
unlevel ground
!
!
Level Ground
FUEL TANK
FILLER PORT