Skoda Octavia III 2013 Service Manual page 92

Octavia III 2013 ➤ , Octavia III 2014 ➤
Maintenance - Edition 12.2014
WARNING
♦ The engine must not be started if the repair was carried
out and no oil was poured in, or only a small amount of oil
is available in the gearbox, or after a major gearbox oil
loss.
♦ Only gear oil for the double clutch gearbox must be used,
which is indicated as spare part for automatic gearbox 0D9
- DSG. Other oils can lead to functional problems or to
failure of the gearbox, part number ⇒ Electronic catalogue
of original parts .
♦ Observe instructions for automatic gearbox 0D9 - DSG ⇒
Gearbox 0D9 - DSG; Rep. gr. 00 .
♦ General repair instructions ⇒ Gearbox 0D9 - DSG; Rep.
gr. 00 .
♦ Regulations concerning cleanliness when working on the
gearboxes ⇒ Gearbox 0D9 - DSG; Rep. gr. 00 .
♦ The gearbox oil temperature is determined with the vehi‐
cle diagnosis, measurement and information system -
VAS- .
♦ The gear oil level changes with the gearbox oil tempera‐
ture.
♦ Checking gear oil level when oil temperature is too low
may result in over-filling.
♦ Checking gear oil level when oil temperature is too high
may result in under-filling.
♦ An over-filling or an under-filling impairs the proper work‐
ing of the gearbox.
♦ Always replace the gasket ring of the outlet and check
screw.
Requirements
• Engine switched off
• Vehicle in horizontal position, all supports of the lift platform
must be at the same level, so that it is secured in the horizontal
position.
• Selector lever in ,,P"
• -VAS- is connected.
• The gearbox oil temperature must not exceed 35°C at the start
of the test.
Change the gearbox oil, replace the oil filter
Note
The following instructions must be observed until termination of
the gear oil change.
removing and installing oil filter
– Remove engine cover ⇒ Relevant Engine; Rep. gr. 10 .
88
4. Gearbox