Remove Mechatronics For Double Clutch Gearbox J743 ; Gearbox Installed - Skoda Fabia II 2007 Workshop Manual

1.2 Remove mechatronics for double clutch
gearbox - J743- ; gearbox installed.
Special tools and workshop equipment required
♦ Assembly lever - T10407-
♦ Catch pan - VAS 6208-
WARNING
Follow the safety measures when working on the mechatronics
for double
⇒ "2.3 Safety measures for working on the mechatronics for
double clutch gearbox J743 ", page 2
Note
Observe general repair instructions and other instructions for
♦
automatic gearbox DSG - 0AM
⇒ "3 Repair instructions", page 4
The new mechatronics for the gearbox is already precisely fil‐
♦
led with oil at the factory, do not drain the oil.
The removed mechatronics is sent back with oil (close the
♦
ventilation opening with a suitable plug).
Pay attention to the ventilation when handling the mechatron‐
♦
ics .
During assembly work, remove the air bleed valve and close
♦
the opening with a suitable screw plug. In case of oil leakage
from the mechatronics , the mechatronics must be replaced ⇒
Electronic Catalogue of Original Parts .
The clutch is self-adjusting. Vibrations can have a negative
♦
effect on the adjusting device. Even when the mechatronics is
removed, the sudden removal of the assembly lever - T10407-
below the engaging levers can have a negative effect on the
adjusting device.
Ensure adequate clearance in front of the gearbox in order to
♦
remove the mechatronics. Components, which are not directly
connected with the gearbox, must be removed on some vehi‐
cles. Any brackets on the screw plugs of the mechatronics
must be removed.
After the battery earth strap is disconnected and connected,
♦
carry out additional operations ⇒ Electrical System; Rep. gr.
27 .
Before removing the mechatronics , basic setting of the neutral
♦
position of the gearbox must be performed ⇒ Vehicle diag‐
nostic tester
– Shift selector lever into position P.
– Connect vehicle diagnosis, measurement and information
system - VAS/ODIS- .
– Select
Targeted functions
Under "7-speed double clutch gearbox", select
tuator into neutral position
– Switch off ignition.
Fabia II 2007 ➤ , Fabia II 2009 ➤ , Fabia II 2011 ➤ , Octavia II 2004 ➤ ...
clutch gearbox
.
.
.
.
Gearbox 0AM-DSG - Edition 01.2015
- J743-
bring gear ac-
1. Mechatronics for double clutch gearbox J743
79