Cleaning; Cleaning The Engine And The Exhaust System Area; Cleaning The Debris From The Machine; Cleaning The Engine Debris Guard - Toro Spray Master Operator's Manual

Cleaning

Cleaning the Engine and
the Exhaust System Area
Service Interval: After each use (clean more often
when operating the machine in dry
or dirty conditions.)
CAUTION
Excessive debris around engine-air intake
and exhaust system area can cause engine,
exhaust area, and hydraulic system to
overheat which can create a fire hazard.
Clean all debris from engine and exhaust
system area.
1. Prepare the machine for maintenance; refer to
Preparing the Machine (page
2. Clean all debris from the engine, around engine
shrouding, fuel tank, and exhaust system area.
3. Wipe up any excessive grease or oil around the
engine and exhaust system area.
4. Clean muffler-heat shields of all debris, dirt, and
oil.
Cleaning the Debris from
the Machine
Service Interval: After each use
1. Prepare the machine for maintenance; refer to
Preparing the Machine (page
2. Clean off any debris or chemical build-up on the
machine, especially the nozzles, sprayer-tank
opening, impeller, and the spray wand and its
holder.
Cleaning the Engine Debris
Guard
Service Interval: Every 80 hours
1. Prepare the machine for maintenance; refer to
Preparing the Machine (page
2. Rotate open the left spray tank; refer to
the Tanks (page
3. Use a brush or dry cloth to remove debris from
the engine debris guard
Note:
Also, clean dust, dirt, and oil from
external surfaces of engine which can cause
improper cooling.
49).
49).
49).
50).
(Figure 104).
4. Close and secure the left spray tank; refer to
Closing the Tanks (page

Waste Disposal

Chemical Disposal
Improper chemical disposal can pollute the
environment and cause health issues.
Follow the disposal directions on the
chemical-manufacturer's label. Dispose of
chemicals and containers in accordance to
local/state/federal laws.
Disposing of the Engine Oil
Engine oil and hydraulic fluid are both pollutants to
the environment. Dispose of used pollutants at a
certified-recycling center or according to your state
and local regulations.
Disposing of the Battery
DANGER
Battery electrolyte contains sulfuric acid,
which is poisonous and can cause severe
burns. Swallowing electrolyte can be fatal or
if it touches skin can cause severe burns.
Opening
• Wear eye protection to shield eyes, and
rubber gloves to protect skin and clothing
when handling electrolyte.
• Do not swallow electrolyte.
• In the event of an accident, flush with water
and call a doctor immediately.
72
Figure 104
51).
g313101