Checking The Crankcase Breather Hose; Synchronizing The Throttle Bodies - Yamaha STAR XVS95CE 2DX1 2014 Service Manual

13.Install:
• Rear cylinder tappet covers
• Fuel filter bracket
• Front cylinder tappet covers
Rear cylinder tappet cover bolt
10 Nm (1.0 m·kgf, 7.2 ft·lbf)
Front cylinder tappet cover bolt
10 Nm (1.0 m·kgf, 7.2 ft·lbf)
14.Install:
• Crankshaft end accessing screw
(along with the O-ring
• Timing mark accessing screw
(along with the O-ring
• Generator cover damper
• Damper cover
Refer to "GENERATOR AND STARTER
CLUTCH" on page 5-42.
Damper cover bolt
7 Nm (0.7 m·kgf, 5.1 ft·lbf)
15.Install:
• All removed parts
TIP
For installation, reverse the removal procedure.
EAS21070
CHECKING THE CRANKCASE BREATHER
HOSE
1. Remove:
• Air filter case
Refer to "GENERAL CHASSIS" on page 4-1.
• Air duct
Refer to "BELT DRIVE" on page 4-70.
• Fuel tank
Refer to "FUEL TANK" on page 6-1.
2. Check:
• Crankcase breather hose "1"
Cracks/damage → Replace.
Loose connection → Connect properly.
ECA13450
NOTICE
Make sure the crankcase breather hose is
routed correctly.
New )
New )
3-7
PERIODIC MAINTENANCE
3. Install:
• Fuel tank
Refer to "FUEL TANK" on page 6-1.
• Air duct
Refer to "BELT DRIVE" on page 4-70.
• Air filter case
Refer to "GENERAL CHASSIS" on page 4-1.
EAS20570

SYNCHRONIZING THE THROTTLE BODIES

TIP
Before synchronizing the throttle bodies, check
the following items:
• Valve clearance
• Spark plugs
• Air filter element
• Throttle body joints
• Fuel hoses
• Exhaust system
• Canister purge hoses (for California)
• Breather hoses
1. Stand the vehicle on a level surface.
TIP
Place the vehicle on a suitable stand.
2. Check:
• Engine idling speed
▼ ▼▼▼ ▼ ▼▼▼ ▼ ▼ ▼▼▼ ▼ ▼ ▼▼▼ ▼
a. Start the engine, warm it up for several min-
utes, and then let it run at the specified en-
gine idling speed.
Engine idling speed
950–1050 r/min
Out of specification → Clean or replace.
▲ ▲▲▲ ▲ ▲▲▲ ▲ ▲ ▲▲▲ ▲ ▲ ▲▲▲ ▲
3. Remove:
• Air filter case
Refer to "GENERAL CHASSIS" on page 4-1.
4. Disconnect:
• Intake air pressure sensor hose "1"
• Cap "2"
1
▼ ▼▼▼ ▼ ▼ ▼▼▼ ▼ ▼▼▼
▲ ▲▲▲ ▲ ▲ ▲▲▲ ▲ ▲▲▲