Fuel Lines And Connections; Electrical System Maintenance; Servicing The Battery - Toro 04520 Operator's Manual

1
Figure 46
1. Fuel filter /water separator
canister
5. Unscrew the filter canister and dispose of it
according to local regulations.
6. Screw the filter on by hand until the gasket contacts
the filter adapter, then tighten 1/2 to 3/4 turn
further.
7. Make sure the filter drain plug is closed. Open the
fuel shut off valve.

Fuel Lines and Connections

Service Interval: Every 2 years
Inspect the fuel lines for deterioration, damage, or loose
connections.
2
2. Filter drain plug
Electrical System
Maintenance

Servicing the Battery

Battery posts, terminals, and related
g014720
accessories contain lead and lead compounds,
chemicals known to the State of California
to cause cancer and reproductive harm.
Voltage: 12 v, 530 Cold Cranking Amps
The battery electrolyte level must be properly maintained
and the top of the battery kept clean. lf the machine is
stored in a location where temperatures are extremely
high, the battery will run down more rapidly than if the
machine is stored in a location where temperatures are
cool.
Maintain the cell level with distilled or demineralized
water. Do not fill the cells above the bottom of the split
ring inside each cell.
DANGER
Battery electrolyte contains sulfuric acid which is a
deadly poison and causes severe burns.
• Do not drink electrolyte and avoid contact with
skin, eyes or clothing. Wear safety glasses to
shield your eyes and rubber gloves to protect
your hands.
• Fill the battery where clean water is always
available for flushing the skin.
Keep the top of the battery clean by washing it
periodically with a brush dipped in ammonia or
bicarbonate of soda solution. Flush the top surface with
water after cleaning it. Do not remove the fill caps while
cleaning the battery.
The battery cables must be tight on the terminals to
provide good electrical contact.
39
WARNING
CALIFORNIA
Proposition 65 Warning
Wash hands after handling.