Table Of Contents; Introduction; Warning; Additional Required Equipment - Hangar 9 PiZAZZ Instruction Manual

Table of Contents

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Additional Required Equipment . . . . . . . . . . . . . . . . . . . . . . . 3
Kit Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Section 1: Installing the Wing . . . . . . . . . . . . . . . . . . . . . . . . 6
Section 2: Hinging the Ailerons . . . . . . . . . . . . . . . . . . . . . . . 8
Section 3: Installing the Aileron Servos . . . . . . . . . . . . . . . . 10
Section 4: Installing the Aileron Linkages . . . . . . . . . . . . . . 12
Section 5: Installing the Horizontal Stabilizer . . . . . . . . . . . . 14
Section 6: Installing the Vertical Stabilizer (Fin) . . . . . . . . . 16
Section 7: Installing the Rudder and Tail Wheel Assembly . . 18
Section 8: Hinging the Elevator . . . . . . . . . . . . . . . . . . . . . . 20

Introduction

Thank you for purchasing one of the finest Sport 3-D fun-fly
models available. The Pizazz ™ is an outstanding model for club
fun-fly events and also is a great 3-D sport aircraft. The Pizazz
uses a conventional two-aileron setup, with separate servos
for each aileron, allowing the you to program each aileron
seperately. This is especially useful for "flapperon" configuration
of the control surfaces.
This configuration offers excellent slow speed and stall
characteristics that allow even inexperienced pilots to feel at
home. Plus, it offers aerobatic capabilities that will have your
flying buddies drooling.
To get the most out of your Pizazz, we strongly suggest using
a computer radio system. This allows you to explore the various
mixes available with computer radio systems.
With a little practice, you could be doing 3-D tricks you never
thought possible. Plus, you'll have fun learning about your
computer radio and its capabilities.
Don't miss out on the fun.
Additional Equipment Required
Radio Equipment
• 4 channels (minimum)
• 5 servos (JR 537 or equivalent)
• Standard 600-1100mAh receiver
battery pack
Recommended JR ®
• JR Quattro • JR F421EX
• JR XP652 • JR XP631
• PCM10X • JR XP8103
• PCM10SX • PCM10SXII
Systems
Section 9: Installing the Rudder and Elevator Control Horns 21
Section 10: Assembling the Fuel Tank
Section 11: Installing the Engine . . . . . . . . . . . . . . . . . . . . 25
Section 12: Installing the Radio System . . . . . . . . . . . . . . . 27
Section 13: Installing the Rudder, Elevator,
and Throttle Pushrods . . . . . . . . . . . . . . . . . . . . 29
Section 14: Installing the Main Landing Gear . . . . . . . . . . . . 33
Section 15. Installing the Canopy . . . . . . . . . . . . . . . . . . . . 34
Section 16: Control Throw Recommendations . . . . . . . . . . . .35
Section 17: Balancing the Pizazz . . . . . . . . . . . . . . . . . . . . .35
Preflight at the Field . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36
AMA Safety Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37
If you encounter difficulty in any construction sequence, please
contact one of our technicians-we stand ready to provide any
assistance we can concerning the construction of your Pizazz.
You can contact us at:
Horizon Hobby, Inc.
4105 Fieldstone Road
Champaign, IL 61822
(217) 355-9511
www.horizonhobby.com

WARNING

An R/C aircraft is not a toy! If misused, it can cause serious
bodily harm and damage to property. Fly only in open areas,
preferably AMA (Academy of Model Aeronautics) approved
flying sites, following all instructions included with your radio
and engine.
. . . . . . . . . . . . . . . 23
JR XP8103
3