Groen HY-3E Operator's Manual
Hypersteam atmospheric convection steamer
Hide thumbs
Also See for HY-3E:
- Operator's and service manual (38 pages) ,
- Operator's manual (36 pages) ,
- Manual (2 pages)
Table of Contents
Advertisement
Quick Links
P IMPORTANT INFORMATION P KEEP FOR OPERATOR P IMPORTANT INFORMATION P
OPERATOR MANUAL
Part Number 121004 - Rev. B
MODELS:
HY-3E,(2)HY-3E, (3)HY-3E
HyPerSteam™
Atmospheric Convection
Steamer
Self-Contained
Electric Heated
Capacity:
3 Steamer Pans [per cavity]
(12" x 20" x 2½")
THIS MANUAL MUST BE RETAINED FOR FUTURE REFERENCE. READ,
UNDERSTAND AND FOLLOW THE INSTRUCTIONS AND WARNINGS
CONTAINED IN THIS MANUAL.
DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND
LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE
New Model
FOR YOUR SAFETY
OM-HY-3E
DOMESTIC
Old Model
.
Advertisement
Table of Contents
Related Manuals for Groen HY-3E
Summary of Contents for Groen HY-3E
- Page 1 P IMPORTANT INFORMATION P KEEP FOR OPERATOR P IMPORTANT INFORMATION P OPERATOR MANUAL OM-HY-3E Part Number 121004 - Rev. B DOMESTIC MODELS: HY-3E,(2)HY-3E, (3)HY-3E HyPerSteam™ Atmospheric Convection Steamer Self-Contained Electric Heated Capacity: 3 Steamer Pans [per cavity] (12" x 20" x 2½”)
-
Page 2: Operator Warnings
DO NOT USE ANY DE-GREASER THAT CONTAINS POTASSIUM HYDROXIDE OR SODIUM HYDROXIDE OR THAT IS ALKALINE. WARNING: USE OF ANY REPLACEMENT PARTS OTHER THAN THOSE SUPPLIED BY GROEN OR THEIR AUTHORIZED DISTRIBUTOR VOIDS ALL WARRANTIES AND CAN RESULT IN BODILY INJURY TO THE OPERATOR AND DAMAGE THE EQUIPMENT. SERVICE BY OTHER THAN FACTORY-AUTHORIZED PERSONNEL WILL VOID ALL WARRANTIES. -
Page 3: Table Of Contents
OM-HY-3E Table of Contents OPERATOR WARNINGS ..............2 REFERENCES . -
Page 4: Equipment Description
Door hinges are reversible (the door may be set to open from the left or right). Operating Controls are on the front panel. The HY-3E steamer holds three standard 12"x 20"x 2-½" deep pans [old model shown] Newer model HY-3E steamers (manufactured since... - Page 5 This typically requires it to have a minimum of 40 parts per million (ppm) total dissolved solids (TDS) as measured with a Groen Test Kit (P/N 110889). At high TDS concentrations, however, serious scaling problems may occur. Consult your local...
-
Page 6: Installation And Start-Up Instructions
OM-HY-3E Installation and Start-Up WARNING THE UNIT MUST BE INSTALLED BY PERSONNEL WHO ARE QUALIFIED TO WORK WITH ELECTRICITY AND PLUMBING. IMPROPER INSTALLATION CAN CAUSE INJURY TO PERSONNEL AND/OR DAMAGE TO THE EQUIPMENT. THE UNIT MUST BE INSTALLED IN ACCORDANCE WITH APPLICABLE CODES. -
Page 7: Drain Connection
E. Branch Circuit Protection line. A trap can cause pressure build-up in the cavity, which may cause the door gasket to leak. Each HY-3E Steamer should have its own DRAIN LINE INSTALLATION branch circuit protection. Current and power (OLDER MODELS WITH DRAIN BOX) demands for the different units are as follows: OPTION ONE: Use 1½”... - Page 8 Treated water (softened) is connected to the right valve fitting Rear view of (2) HY-3E — Note: The drain (facing the rear of the unit) and untreated water hoses, required for installation, are packed to the left valve fitting.
- Page 9 OM-HY-3E Figure 2 - Drain and Water Connections for (2) HY-3E with optional twin hose connections. (Drain Kit P/N 125777) Figure 3 - Drain and Water Connections for (3) HY-3E with optional twin hose connections. (Drain Kit P/N 125777).
-
Page 10: Operating Instructions
OM-HY-3E Operation WARNING ANY POTENTIAL USER OF THE EQUIPMENT SHOULD BE TRAINED IN SAFE AND CORRECT OPERATING PROCEDURES. seconds. When both probes fail, the light A. Controls will flash continuously and the beeper will Operator controls are on the front right of the unit. - Page 11 OM-HY-3E steam generator is at standby temperature 3. Open the door and slide the pans onto the and the cavity is hot enough to begin supports. If you will only be steaming one pan, steaming. put it in the middle position.
-
Page 12: Cleaning
OM-HY-3E Cleaning To keep your HY-3E Steamer in proper working condition, use the following procedure to clean the unit. This regular cleaning will reduce the effort required to clean the steam generator and cavity. A. Suggested Tools WARNING DISCONNECT THE POWER SUPPLY 1. - Page 13 If the CLEAN light comes on again, call the authorized Groen Service agent in your area. (See listing enclosed The process for de-liming your HY-3E Steamer is with this manual). “simple, tool-less and quick. Adding de-limer/de-...
-
Page 14: Maintenance And Troubleshooting
Troubleshooting This Groen Steamer is designed to operate smoothly and efficiently if properly maintained. However, the following is a list of checks to make in the event of a problem. Wiring diagrams are furnished inside the service panel. If an... -
Page 15: Parts List
OM-HY-3E Parts List To order parts, contact your authorized Groen Service Agency. Supply the model designation, part description, part number, quantity, and when applicable, voltage and phase. REAR VIEW Description Description Right Side Panel 123134 096796 Cover, Fuse Box 119846... - Page 16 OM-HY-3E Parts List To order parts, contact your authorized Groen Service Agency. Supply the model designation, part description, part number, quantity, and when applicable, voltage and phase. Description Description Heater Element, 200 V 123104 094118 Transformer 208/240/480V 106234 100912 Heater Element, 208 V...
- Page 17 OM-HY-3E Parts List To order parts, contact your authorized Groen Service Agency. Supply the model designation, part description, part number, quantity, and when applicable, voltage and phase. Older Models New Model Description Description Red Timer Lamp 096898 Water Inlet Hose*...
-
Page 18: Schematics [New Models]
Electrical Schematics (New Models) All Voltages... -
Page 19: Schematics [Old Models]
Electrical Schematics (Older Models) 208 and 240 Volt Models... - Page 20 Electrical Schematics (Older Models) 480 Volt Model...
- Page 21 Electrical Schematics (Older Models) 380/415 Volt Three Phase and 220/240 Volt One Phase Models...
-
Page 22: Service Log
OM-HY-3E Service Log Model No. Purchased From Serial No. Location Date Purchased Date Installed Purchase Order No. For Service Call Date Maintenance Performed Performed by... -
Page 23: Warranty Protection
Groen Foodservice Equipment (“Groen Equipment”) has been skillfully manufactured, carefully inspected, and packaged to meet rigid standards of excellence. Groen warrants its Equipment to be free from defects in material and workmanship for (12) twelve months with the following conditions an subject to the following limitations. - Page 24 1055 Mendell Davis Drive OM-HY-3E (Revised 01/00) Jackson, MS 39212 Telephone 601 372-3903 Part Number 121004 - Rev. B Fax 601 373-9587...