Page 1
IMPORTANT INFORMATION IMPORTANT INFORMATION IMPORTANT INFORMATION IMPORTANT INFORMATION KEEP FOR OPERATOR KEEP FOR OPERATOR KEEP FOR OPERATOR KEEP FOR OPERATOR IMPORTANT INFORMATION IMPORTANT INFORMATION IMPORTANT INFORMATION IMPORTANT INFORMATION 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 OPERATOR MANUAL OPERATOR MANUAL...
Use no de-greaser that contains potassium hydroxide or sodium hydroxide or is alkaline. WARNING: USE OF ANY REPLACEMENT PARTS OTHER THAN THOSE SUPPLIED BY GROEN OR THEIR AUTHORIZED SERVICE AGENTS VOIDS ALL WARRANTIES AND CAN CAUSE BODILY INJURY TO THE OPERATOR AND DAMAGE THE EQUIPMENT. SERVICE PERFORMED BY OTHER THAN FACTORY-AUTHORIZED PERSONNEL WILL VOID ALL WARRANTIES.
OM-HY-6CAV Equipment Description The Groen HY-6 HyPlus Steamer is designed to Operator Controls are located on the front panel. bring you years of service. It has two stainless steel cavities (cooking chambers) and a control Model HY-6 HyPlus steamer cavities are mounted...
Alternating Current, 60 Hz, single phase, 15 MAKING ELECTRICAL MECHANICAL AMP service. Local codes and/or the National CHANGES TO THE UNIT WITHOUT APPROVAL Electrical Code should be observed in FROM GROEN FOOD SERVICE accordance with ANSI/NFPA-70-1987 (or latest ENGINEERING DEPARTMENT VOID edition). AN ELECTRICAL GROUND IS WARRANTIES.
Page 6
OM-HY-6CAV Water supply lines should be sized to provide IMPORTANT: Improper drain connection will for maximum water use (the total of the boiler void warranty. and condenser spray) as shown in the following table: Maximum Water Consumption-gal/hr (L/hr) CNGB/3 boiler only 12.9 (48.8) CNEB/1 (24KW) boiler only 8.2 (31.0)
Page 7
OM-HY-6CAV Utility Connections (keyed to illustration) IMPORTANT: Refer to the appropriate boiler manual for complete installation details (OM-CNGB/3 for HY-6SG, and OM-CNEB/1 for HY-6SE) HY-6SG (GAS) MODEL 1. Hot water (for faucet on 36" and wider units with kettles). 2. Steam outlet (for power take-off) 3.
Turn on the electrical power to the unit. If the unit functions as described above, it is ready On models HY-6SG and HY-6SE, start the for use. If it does not, contact your Groen Authorized boiler and allow steam pressure to develop. Service Agent.
OM-HY-6CAV Operation WARNING ANY POTENTIAL USER OF THE EQUIPMENT SHOULD BE TRAINED IN SAFE AND CORRECT OPERATING PROCEDURES. 7. Turn the timer to one of the following settings: Controls: Timers are located on the front right side of the unit. There are two timers — one each for a.
1. Mild detergent OUT OF CONTROLS AND ELECTRICAL 2. Stainless steel exterior cleaner such as COMPONENTS. NEVER HOSE OR STEAM Groen Spray Degreaser (Part No. CLEAN ANY PART OF THE UNIT. 114801), Zepper® 3. De-greaser, such as EncompasS®, Malone DON’T MIX DE-LIMING AGENTS (ACID) 34®, Puritan Puribrute®, or Con-Lie®...
Certain parts may need replacement following steps: after prolonged use. If there is a need for service, only Groen personnel or Authorized Groen Service 1. Check the condition of the door gasket. Replace Representatives should do the work. it if it is cracked or split.
OM-HY-6CAV Troubleshooting Groen Steamers are designed to operate smoothly and efficiently when properly maintained. However, the following is a list of things to check if there is a problem. Wiring diagrams are furnished inside the service panel. SYMPTOM WHAT TO CHECK Timer control will not operate a.
OM-HY-6CAV OM-HY-6CAV Parts List Parts List HY-6SG, HY-6SE, and HY-6SM Steamer Cavity Only HY-6SG, HY-6SE, and HY-6SM Steamer Cavity Only OM-HY-6CAV Parts List HY-6SG, HY-6SE, and HY-6SM Steamer Cavity Only...
Page 14
OM-HY-6CAV Parts List HY-6SG, HY-6SE, and HY-6SM Steamer Cavity Only Description Part No. Description Part No. 1 Upper Cavity Drain Hose 088847 15 Jumper, Voltage Select - SE 100960 28 Lock Washer 2 Motor Assembly 096740 16 Harness, Spray Valve - SM 137834 29 Relay, DPDT 3 Timer,...
Page 15
OM-HY-6CAV Parts List Motor/Fan Assembly Description Part No. Motor 096739 Slinger Washer 096831 Motor Mounting Plate 094134 Shaft Seal 096868 Plate Seal Holder 096752...
Page 16
OM-HY-6CAV Parts List Sheet Metal and Doors Description Part No. Description Part No. 1 Cover, Right Side HY-6SM & HY-6SE 139941 5 Retainer, Top 123156 1 Cover, Right Side, HY-6SG 143778 6 Screw, 8-32 x 3/8 slotted hex head 004173 2 Cover, Left Side 123184 7 Door Handle...
Page 17
OM-HY-6CAV Parts List Door & Cavity Hardware Description Part No. Description Part No. Door Gasket 094147 Lock Nut 003823 Door Handle 070123 Inner Panel 094141 Door Cam 074252 Door Spacer 071206 Magnet Assembly 069762 Door Screws 05764 U-Channel Assy (Incl. Door Spring P/N 078911) 094144 Door Hinge 094143 Latch Spring...
Page 18
OM-HY-6CAV Parts List Drain Box with Spray Condenser Description Part No. Description Part No. Solenoid Valve (Spray Condenser) 099221 Spacer 099212 Hose d” ID x 8" Long 099282b Hose, outlet 1¼” ID x 3½” Long 099280b Rubber Flap 099213 Anchor Coupling, d” NPT N89267...
Page 19
OM-HY-6CAV Parts List 6SM Electrical Controls Description Part No. Description Part No. Weld Assembly, Electronic Cabinet 137257 Weld Assy, Electronic Cabinet Bottom 137256 003887 069773 Terminal Block, 2-Pole Screw, Hex HD, 10-32 x 3/8" Long 119829 137749 Lug, Ground Plate, Hole Cover Bracket , Electronic Cabinet Breaker 137254 Hole Plug, 7/8"...
OM-HY-6CAV OM-HY-6CAV Electrical Schematic HY-6SG HyPlus Steamer Cavities Service Log Model No. Purchased From Serial No. Location Date Purchased Date Installed Purchase Order No. For Service Call Date Maintenance Performed Performed by...
Page 25
OM-HY-6CAV OM-HY-6CAV References NOTES: UNDERWRITERS LABORATORIES, INC. 333 Pfingsten Road Northbrook, Illinois 60062 KLENZADE SALES CENTER ECOLAB, Inc. 370 Wabasha St. Paul, Minnesota 55102 800 328-3663 or 612 293-2233 NATIONAL FIRE PROTECTION ASSOCIATION 60 Battery March Park Quincy, Massachusetts 02269 NFPA/70 The National Electrical Code NSF INTERNATIONAL 789 North Dixboro Road...
Equipment”) (other than CapKold foodservice equipment) shall be free from defects in material and workmanship for (12) twelve months from the date of installation or fifteen (15) months from date of shipment from Groen, whichever date first occurs (the “Warranty Period”), in accordance with the following terms and conditions: This warranty is limited to replacement parts and related labor for Groen Equipment located at its original place of installation in the United States and Canada.
Page 27
KLENZADE SALES CENTER ECOLAB, Inc. VIII. Groen Equipment is for commercial use only. If sold as a component of another (O.E.M.) 370 Wabasha manufacturer’s equipment, or if used as a consumer product, such Equipment is sold AS IS and St. Paul, Minnesota 55102 without any warranty.
Page 28
1055 Mendell Davis Drive Jackson, MS 39272 Telephone 601 372-3903 OM-HY-6CAV Fax 601 373-9587 www.groen.com Part Number 121001 Rev. C...