Table of Contents
Advertisement
IMPORTANT INFORMATION
IMPORTANT INFORMATION
IMPORTANT INFORMATION
IMPORTANT INFORMATION
OPERATOR MANUAL
Part Number 138486 Rev B
MODELS:
Self-Contained
Gas Heated
Capacity:
THIS MANUAL MUST BE RETAINED FOR FUTURE REFERENCE. READ,
UNDERSTAND AND FOLLOW THE INSTRUCTIONS
CONTAINED IN THIS MANUAL.
DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND
LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE
INSTRUCTIONS TO BE FOLLOWED IN THE EVENT USER SMELLS GAS. THIS
INFORMATION SHALL BE OBTAINED BY CONSULTING YOUR LOCAL GAS
SUPPLIER.
AS A MINIMUM, TURN OFF GAS AND CALL YOUR GAS
COMPANY AND YOUR AUTHORIZED SERVICE AGENT. EVACUATE ALL
PERSONNEL FROM THE AREA.
IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR
MAINTENANCE CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH.
READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS
THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIPMENT.
KEEP FOR OPERATOR
KEEP FOR OPERATOR
KEEP FOR OPERATOR
KEEP FOR OPERATOR
HY-5G, (2)HY-5G
HyPerSteam™
Atmospheric Convection
Steamer
5 Steamer Pans [per cavity] (HY-5G)
(12" x 20" x 2½")
FOR YOUR SAFETY
POST IN A PROMINENT LOCATION
WARNING
IMPORTANT INFORMATION
IMPORTANT INFORMATION
IMPORTANT INFORMATION
IMPORTANT INFORMATION
OM-HY-5G
HY-5G
AND WARNINGS
.
DOMESTIC
(2)HY-5GF
Advertisement
Table of Contents
Related Manuals for Groen HyPerSteam (2)HY-5G
Summary of Contents for Groen HyPerSteam (2)HY-5G
- Page 1 IMPORTANT INFORMATION IMPORTANT INFORMATION IMPORTANT INFORMATION IMPORTANT INFORMATION KEEP FOR OPERATOR KEEP FOR OPERATOR KEEP FOR OPERATOR KEEP FOR OPERATOR IMPORTANT INFORMATION IMPORTANT INFORMATION IMPORTANT INFORMATION IMPORTANT INFORMATION OPERATOR MANUAL OM-HY-5G Part Number 138486 Rev B DOMESTIC MODELS: HY-5G, (2)HY-5G HyPerSteam™...
-
Page 2: Operator Warnings
OM-HY-5G IMPORTANT — READ FIRST — IMPORTANT WARNING: THE UNIT MUST BE INSTALLED BY PERSONNEL QUALIFIED TO WORK WITH ELECTRICITY AND PLUMBING. IMPROPER INSTALLATION CAN CAUSE INJURY TO PERSONNEL AND/OR DAMAGE TO THE EQUIPMENT. THE UNIT MUST BE INSTALLED IN ACCORDANCE WITH APPLICABLE CODES. -
Page 3: Table Of Contents
OM-HY-5G Table of Contents OPERATOR WARNINGS ..............2 REFERENCES . -
Page 4: Equipment Description
OM-HY-5G Equipment Description Your Groen HY-5G or (2)HY-5G HyPerSteam Convection Steamer is designed to give years of service. It has a stainless steel cavity (cooking chamber) which is served by an independent atmospheric steam generator which is gas-heated. A powerful blower circulates the steam in the cavity to increase heating efficiency. -
Page 5: Water Quality And Treatment
OM-HY-5G Water Quality and Treatment It is essential to supply the steam generator with water that will not form scale. Even though the steam generator/boiler is engineered to minimize scale formation, scale development depends on the hardness of your water and the number of hours you operate the equipment each day. -
Page 6: Installation And Start-Up
OM-HY-5G Installation and Start-Up WARNING THE UNIT MUST BE INSTALLED BY PERSONNEL WHO ARE QUALIFIED TO WORK WITH GAS, ELECTRICITY AND PLUMBING. IMPROPER INSTALLATION CAN CAUSE INJURY TO PERSONNEL AND/OR DAMAGE TO THE EQUIPMENT. THE UNIT MUST BE INSTALLED IN ACCORDANCE WITH APPLICABLE CODES CAUTION DO NOT INSTALL THE UNIT WITH THE RIGHT OR LEFT SIDE VENTS BLOCKED OR WITHIN 12 INCHES OF... - Page 7 OM-HY-5G After the unit has been connected to the gas There must be a free air gap between the end of the supply, all gas joints must be checked for leaks. hose and the building drain. The free air gap should No flame should be used when checking for be as close as possible to the unit drain.
- Page 8 OM-HY-5G D. Drain Connection Ensure that there is a free air gap between the end of the unit drain and the building drain. This gap Steamers must be leveled front to back, or should be as close as possible to the unit drain. Do pitched to the rear (maximum ¼...
- Page 9 OM-HY-5G Initial Start-Up After the HY-5G Steamer has been installed, test it water has reached its standby temperature. to ensure that the unit is operating correctly. When the READY light is displayed, you may take any one of the following steps: 1.
-
Page 10: Operation
OM-HY-5G Operation WARNING ANY POTENTIAL USER OF THE EQUIPMENT MUST BE TRAINED IN SAFE AND CORRECT OPERATING PROCEDURES. When one probe fails, the SERVICE light A. Controls flashes briefly every few seconds, but the Operator controls are on the front right of the unit. unit will continue to operate. - Page 11 OM-HY-5G The timer is used in three ways: If you want to steam continuously, turn the timer to the manual ON position. A green In the OFF position the steam generator light will come on. The unit will continue stays at a low boil or “holding” temperature. steaming until you stop it by turning the timer to OFF.
-
Page 12: Cleaning
OM-HY-5G Cleaning To keep your HY-5G Steamer in proper working condition, use the following procedure to clean the unit. This regular cleaning will reduce the effort required to clean the steam generator and cavity. A. Suggested Tools WARNING DISCONNECT THE POWER SUPPLY 1. - Page 13 OM-HY-5G Steam Generator and Cooking Chamber NOTES: On a regularly scheduled basis, or if the SERVICE 1. If the clean cycle ends abruptly, the CLEANING light is on, follow the simple de-liming instructions light will flash five times per second. This below.
-
Page 14: Maintenance
OM-HY-5G Maintenance The HY-5G Steamer is designed for minimum 3. Adjust the door latch pin to allow for changes maintenance, and no user adjustments should be that might occur as the gasket ages. necessary. Certain parts may need replacement a. Loosen the lock nut at the base of the latch after prolonged use. -
Page 15: Parts List
OM-HY-5G Parts List - HY-5G To order parts, contact your authorized Groen Service Agency. Supply the model designation, serial number, part description, part number, quantity, and when applicable, voltage and phase. Description Description Right Side Panel 138532 13 Funnel, Delime 106624 Door Assy, Complete 125922... - Page 16 OM-HY-5G Parts List - (2) HY-5G To order parts, contact your authorized Groen Service Agency. Supply the model designation, serial number, part description, part number, quantity, and when applicable, voltage and phase. Parts listed below only apply to model (2) HY-5G. Common parts are listed on page 15. Description Part No.
- Page 17 OM-HY-5G Electrical Parts List - HY-5G To order parts, contact your authorized Groen Service Agency. Supply the model designation, serial number, part description, part number, quantity, and when applicable, voltage and phase. Description Part No. Description Part No. Fuse, 3 Amp 077853 15 Gas Valve 099906...
- Page 18 OM-HY-5G Parts List - HY-5G To order parts, contact your authorized Groen Service Agency. Supply the model designation, serial number, part description, part number, quantity, and when applicable, voltage and phase. Description Part No. Description Part No. Steam Generator 138521 13 Gasket 106232 Cavity...
-
Page 19: Electrical Schematics
OM-HY-5G Electrical Schematic - HY-5G HY-5G Wiring Diagram P/N 130396 Rev A All Voltages... -
Page 20: Service Log
OM-HY-5G Service Log Model No. Purchased From Serial No. Location Date Installed Date Purchased For Service Call Purchase Order No. Date Maintenance Performed Performed by... - Page 21 OM-HY-5G NOTES:...
- Page 22 OM-HY-5G LIMITED WARRANTY TO COMMERCIAL PURCHASERS* (U.S. & Canadian Sales Only.) Groen warrants to original commercial purchaser/users that foodservice equipment manufactured by Groen (“Groen Equipment”) (other than CapKold foodservice equipment) shall be free from defects in material and workmanship for (12) twelve months from the date of installation or fifteen (15) months from date of shipment from Groen, whichever date first occurs (the “Warranty Period”), in accordance with the following terms and conditions: This warranty is limited to replacement parts and related labor for Groen Equipment located at its original place...
-
Page 23: Warranty
OM-HY-5G VII. THIS WARRANTY IS EXCLUSIVE AND IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, EACH OF WHICH IS HEREBY EXPRESSLY DISCLAIMED. THE REMEDIES DESCRIBED ABOVE ARE EXCLUSIVE AND IN NO EVENT SHALL GROEN BE LIABLE FOR SPECIAL, CONSEQUENTIAL, OR INCIDENTAL DAMAGES FOR THE BREACH OR DELAY IN PERFORMANCE OF THIS WARRANTY. - Page 24 1055 Mendell Davis Drive OM-HY-5G Jackson, MS 39272 Revised 10/01 Telephone 601 372-3903 Part Number 138486 Rev B Fax 601 373-9587 www.groen.com...