Page 1
IMPORTANT INFORMATION ? ? KEEP FOR OPERATOR KEEP FOR OPERATOR ? ? IMPORTANT INFORMATION ? ? IMPORTANT INFORMATION OPERATOR MANUAL OM-HY-3E Part Number 121004 DOMESTIC MODEL: HY-3E HyPerSteam™ Atmospheric Convection Steamer Self-Contained Electric Heated Capacity: 3 Steamer Pans (12" x 20" x 2½”) THIS MANUAL MUST BE RETAINED FOR FUTURE REFERENCE.
DO NOT USE ANY DE-GREASER THAT CONTAINS POTASSIUM HYDROXIDE OR SODIUM HYDROXIDE OR THAT IS ALKALINE. WARNING: USE OF ANY REPLACEMENT PARTS OTHER THAN THOSE SUPPLIED BY GROEN OR THEIR AUTHORIZED DISTRIBUTOR VOIDS ALL WARRANTIES AND CAN RESULT IN BODILY INJURY TO THE OPERATOR AND DAMAGE THE EQUIPMENT. SERVICE BY OTHER THAN FACTORY-AUTHORIZED PERSONNEL WILL VOID ALL WARRANTIES.
Controls are on the front panel. The drain system includes a spray condenser, which helps keep steam from escaping from the chamber. The HY-3E steamer holds three standard 12"x 20"x 2-½" pans Inspection and Unpacking The HY3-E will be delivered completely assembled Write down the model number, serial number and in a heavy shipping carton attached to a skid.
80%, resulting in significant savings. On the HY-3E, the twin water connections are side by side on the rear of the unit. When facing the back of the unit, the treated (softened) water intake is on the right.
Page 6
VOLTAGE PHASE AMPS MAX. KW The HY-3E Steamer must be leveled front to back, or even pitched slightly to the rear by adjustment of the bulllet feet on the cabinet base. A 1½ inch (38mm) ID hose may be attached to the drain pipe (supplied).
Page 7
OM-HY-3E IMPORTANT: Do not allow any water traps in WARNING the line. A trap can cause pressure to build up BLOCKING THE DRAIN IS HAZARDOUS. inside the cavity during steaming, which will make the door gasket leak. Install the drain line with a constant downward pitch.
The timer will automatically run the steamer for the set time and then turn it off. A red light will come on and a beeper will sound. Steam stops. Controls for the HY-3E are simple, and easy to operate.
OM-HY-3E Cleaning To keep your HY-3E Steamer in proper working condition, use the following procedure to clean the unit. This regular cleaning will reduce the effort required to clean the steam generator and cavity. A. Suggested Tools PRECAUTIONS 1. Mild detergent WARNING 2.
Page 10
Do not use any de-limer that directions in the owner’s manual..For contains chlorine. Groen, you have to take out the racks and g. Replace fan baffle partition. get inside, but the process again is simple, tool-less and quick, about 25 h.
Troubleshooting This Groen Steamer is designed to operate smoothly and efficiently if properly maintained. However, the following is a list of checks to make in the event of a problem. Wiring diagrams are furnished inside the service panel. If an item on the check list is marked with (Y), it means that the work should be done by a factory- authorized service representative.
OM-HY-3E Parts List To order parts, contact your authorized Groen Service Agency. Supply the model designation, part description, part number, quantity, and when applicable, voltage and phase. REAR VIEW Description Part No. Description Part No. Right Side Panel 096796 Top Side Cover...
Page 13
OM-HY-3E Parts List To order parts, contact your authorized Groen Service Agency. Supply the model designation, part description, part number, quantity, and when applicable, voltage and phase. Description Part No. Description Part No. Heater Element, 200 Volt 094118 Transformer 208/240/480 Volt Pri./ 100912 24 Volt Sec.
Page 14
OM-HY-3E Parts List To order parts, contact your authorized Groen Service Agency. Supply the model designation, part description, part number, quantity, and when applicable, voltage and phase. Description Part No. Description Part No. Red Timer Lamp 096898 Drain Hose,* Steam Generator...
Electrical Schematics 480V 240V 18AWG EXCEPT 480V 208V 600V 105E E C CONNECT POWER TO THESE 10 AWG 600V TERMINALS JUMPERS 24 VAC 24 VAC DRAIN TRANSFORMER HIGH VALVE TR1 WIRING SCHEME 14AWG 600V 200E E C DRAIN CLEAN 6 TYP. WATER LEVEL POWER CLEAN...
Page 17
Electrical Schematics CAVITY POWER SWITCH CAVITY POWER SWITCH CAVITY POWER SWITCH W/ON-OFF LEGEND SHOWN IN OFF POSITION SHOWN IN OFF POSITION SHOWN IN OFF POSITION ORANGE DOT INDICATOR CONNECT POWER TO THESE TERMINALS 18AWG 600V 105E E C 10 AWG 600V JUMPERS Back Back...
OM-HY-3E Service Log Model No. Purchased From Serial No. Location Date Purchased Date Installed Purchase Order No. For Service Call Date Maintenance Performed Performed by...
Groen Foodservice Equipment (“Groen Equipment”) has been skillfully manufactured, carefully inspected, and packaged to meet rigid standards of excellence. Groen warrants its Equipment to be free from defects in material and workmanship for (12) twelve months with the following conditions an subject to the following limitations.
Page 20
1055 Mendell Davis Drive Jackson, MS 39272 Telephone 601 372-3903 Fax 601 373-9587 OM-HY-3E (Revised 2/98) Part Number 121004...