Battery Instruction & Maintenance - Heartway Medical Products S16 User Manual

BATTERY INSTRUCTION & MAINTENANCE
 Read through the charger operating instruction before using it.
 If you use your scooter every day, please charge its batteries as soon as you finish using it for the
day. Your scooter will be ready each morning.
 Avoid deeply discharging your scooter's batteries.
 Charge the battery at least 24 hours a week if the power chair or scooter has not been used.
(This is to make sure that the electrolyte is always at the top level)
 If the battery cannot be charged (Orange light cannot turn to Green) or if the Orange light turns to
Green immediately, please check it with the technicians. The battery may be defective.
 The voltage difference between the two batteries on a power unit cannot be more than 0.5 V; the
battery case should be inspected for cleanliness and evidence of damage.
 If the charger indicates red light, please kindly check if the charger is defected or if the cable
wiring connection is poor.
 Please keep the battery Θand ⊕connectors clean otherwise the charging condition will be poor.
 Please do not operate the scooter with depleted batteries since the occupant could be standard.
To Change the batteries in your scooters:
 Remove the battery cover and captain seat.
 Unfasten the battery tie-down strap.
 Disconnect the battery harnesses properly.
 Disconnect the battery by opening two gray main connectors and also three smaller connectors
(two white and one red).
 Remove the old batteries from the battery wells.
 Place a new battery in each battery well.
 Reconnect the gray connectors.
 Check the terminal boots for correct position..
 Reconnect the battery tie-down strap.
 Reinstall the battery cover and seat back to the scooter.
 Removing the battery and seat from the scooter is allowed before transporting.
 Please remove connectors (A, B, C, D, E) first before removing the battery.
28
28