Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Heartway Medical Products S19F
Summary of Contents for Heartway Medical Products S19F
- Page 1 S19F User Manual Version: 2021-01...
-
Page 2: Table Of Contents
Contents …………….……..………...…………………... P01 Information Safety Instruction .……………………..…………………... P03 Product Specification ……..……………………………….. P06 Adjustment ..…………………………………..….……… P07 Operation of Control ...………..…………………………… P09 Battery & Charging Instruction …………..………………. P11 Indicator Signal …………..…………………….…..……. P13 Electromagnetic Interference .………...……………….. P21 Brake & Battery Connection ….…………………………. P21 Maintenance &... -
Page 3: Information
Member State in which the user and/or patient is established** S19F should be turned off prior to entering or existing the seat. Make sure the scooter is fully un‐folded before driving. - Page 4 WARNING Environmental conditions may affect the safety and performance of your power scooter. Water and extreme temperatures are the main elements that can cause damage and affect performance. A) Rain, Sleet and Snow: If exposed to water, your power scooter is susceptible to damage to electronic or mechanical components.
- Page 5 SAFETY SYMBOL The following symbols are used in the scooter to identify warnings, mandatory actions and prohibited actions. It is very important that you read and understand them completely. Read and follow the information in the instruction manual. Caution. Observing notes and accompanying documents It is classified in category A according to EN 12184.
- Page 6 Emergo Europe Prinsessegracht 20 2514 AP The Hague The Netherlands The scooter S19F is designed for indoor use for adults with mobility restrictions. It is classified in category A according to EN 12184. It is compact, maneuverable and not necessarily able to overcome obstacles outdoors;...
-
Page 7: Safety Instruction
SAFETY INSTRUCTION General Always use a seat belt Never operate the scooter Never use electronic radio and keep your feet on while you are under the transmitters such as the scooter all the time. influence of alcohol. walkie-talkies, or cellular phones. -
Page 8: Product Specification
PRODUCT SPECIFICATION MODEL S19F - Auto Folding Scooter WEIGHT CAPACITY 115kgs(254 Ibs) SEAT: TYPE/SIZE 16" DRIVE WHEEL PU 200mmx50mm(8"x2") FRONT CASTER (WHEEL) PU 180mmx40mm(7"x1.6") REAR CASTER (ANTI-TIPPER) MAX SPEED 6 KM/H BATTERY SPECIFICATIONS 11.5 AH Li-Polymer BATTERY RANGE 15KM 2.5Amp, 110/240 Volt,... -
Page 9: Adjustment
ADJUSTMENT Folding Out the Scooter Position the scooter with rear wheels and anti-tipper wheels on the ground Insert the key into the ignition of the scooter and switch the scooter on. The green button (arrowed below) on the scooter should now be illuminated. - Page 10 ADJUSTMENT The red button (arrowed below) on the scooter should now be illuminated. Press this for 3 seconds then release the button and the scooter will automatically fold up. Alternatively, press the red button on the remote. (If case of emergency, press the green button on the rear of the scooter the stop the folding procedure.
-
Page 11: Operation Of Control
OPERATION OF CONTROL The power scooter is simple to operate. However, we recommend that you read carefully the following instructions to become familiarized with your new vehicle. Please do not operate this power scooter if it is behaving abnormally or erratically. The following operation can be carried out either by assistant or occupant . - Page 12 DRIVING Controller ON/OFF Switch Insert the key to power on the scooter (Remove the key to power off). Swing the finger lever control forward or backward to control the driving direction of the scooter (The finger lever control is located at both sides of the controller and the returning of the finger lever control to its neutral position,(center), will reduce the speed and stop the vehicle by automatically applying the electro‐magnetic brakes Finger Lever Control/Maximum...
-
Page 13: Battery & Charging Instruction
BATTERY & CHARGING INSTRUCTION We recommend that you use deep-cycle batteries that are sealed and maintenance free for your power scooter. General product Information: The equipment is a Rechargeable Li-ion Battery Pack for use in the scope of information technology equipment. Model: EBP28A076C1 Cell’s arrangement:... - Page 14 CHARGING INSTRUCTIONS BATTERY CHARGER The battery charger takes the standard wall outlet voltage (alternating current) and converts it into DC voltage (direct current).The batteries use direct current to run your power scooter. When the batteries are fully charged, the amperage from the charger is almost at zero.
-
Page 15: Indicator Signal
INDICATOR SIGNAL The Indicator Signal Chart Indicator LED 1 LED 2 Condition Power On (Power on by plugging in AC source and without battery) Flashing in three times then ON Constant Current Mode Constant Current Mode Battery Fully Charged (Terminate Current ≤ 300 ± 100mA) Pre-Charged Mode Slow Flash Red and Green LEDs... - Page 16 During charging, user can remove the battery from charger any time as he/she wants. Users also could start to charge the battery at any time. The charger is able to determine the best cut‐in point where the charging process is starting to. In case of problems, please check battery pack and repeat above steps.
- Page 17 WARNING Don’t operate scooter on public streets and roadways. Be aware that it may be difficult for traffic to see you when you are seated on the scooter. Obey all local pedestrian traffic rules. Wait until your path is clear of traffic, and then proceed with extreme cautions.
- Page 18 19. Operating in rain, snow, salt, mist conditions and on icy or slippery surfaces may have an adverse affect on the electrical system. 20. Never sit on your scooter when it is being used in connection with any type of lift or elevation product.
- Page 19 Weight limitation. Please refer to the specifications table for weight capacity information. Power scooter is rated for a maximum weight capacity. Stay within the specified weight capacity for your scooter. Exceeding the weight capacity voids your warranty. Heartway will not be held responsible for injuries or property damage resulting from failure to observe weight limitations.
-
Page 20: Electromagnetic Interference
The United States Food and drug Administration (FDA) suggests that the following statement be incorporated to the user’s manual for all power scooter like the S19F. Power scooters may as susceptible to electromagnetic interference (EMI), which is interfering electromagnetic energy emitted from sources such as radio stations, TV stations, amateur radio (HAN) transmitter, two‐way radios, cellular phones and alarm systems... - Page 21 • The driving performance of the scooter can be influenced by electro magnetic fields. S19F seat is tested according to EN 1021 regarding resistance to ignition, but it is recommended to avoid the use of flame near the power scooter and of smoking during sitting on the power scooter.
- Page 22 PINCH POINT-BE AWARE OF FINGERS WHEN FOLDING AND UN-FOLDING POWER SCOOTER • One persons are needed to lift this power scooter.– S19F If user or care giver cannot lift the unit by himself/herself, assistance from a second person is required.
- Page 23 Free-Wheeling: The motors are designed to engage the electromagnetic brakes when the vehicle is not in use or when the power is OFF. They also have a manual feature that allows them to “free‐wheel” so the scooter can be moved without turning it on.
- Page 24 WARNING DO NOT operate this scooter with depleted batteries since the occupant could be stranded. Please remove the battery package from the scooter unit before long term storage. Forbidden! Although the travel scooter has passed the required IPX4 water spray test requirements, keep electrical connections away from sources of moisture, including direct exposure to water or body fluids, and incontinence.
- Page 25 BATTERY MAINTENANCE INSTRUCTION Read through the charger operating instruction before using it. Make sure you charge the battery every time after you use the power scooter or scooter. If the charger indicates red light, please kindly check if the charger is defected or if the cable wiring connection is poor.
-
Page 26: Maintenance & Repair
MAINTENANCE & REPAIR Your power scooter is designed for minimal maintenance. However, like any motorized vehicle it requires routine maintenance. To keep your S19F for years of trouble-free operation, we recommend you follow the following maintenance checks as scheduled. DAILY CHECKS •... - Page 27 TROUBLE SHOTTING & ERROR CODE Dynamic 50 AMP CONTROLLER: Your power wheelchair is fitted with DYNAMIC controller, which continuously monitors the operating conditions of your power wheelchair. If it detects a problem it will indicate with error message by flashing light on the power ON/ OFF light.
- Page 28 Circuit Diagram...
-
Page 29: Bom List
BOM LIST... -
Page 30: Warranty Declaration
WARRANTY DECLARATION Quality/ Warranty Declaration Products are fit for purpose and of excellent quality and performance. For valid warranty claims Heartway will, at their discretion, replace/ repair/ refund items mutually agreed to be defective. Heartway’s Warranty as Following: Frame: Two‐year limited warranty Controllers: One‐and‐a‐half‐year limited warranty Electronic Components and Charger: One‐year limited warranty Warranty Exclusion. The following items are not covered by warranty. Motor brushes Wheel Tires Arm Pads Seat Cushion... - Page 31 Heartway Medical Products Co.,LTD No.18, Jingke Central 1st Rd., Nantun Dist., Taichung City 408, Taiwan (R.O.C.) TEL:+886-4-2358-0537 FAX:+886-4-23590786 E-mail: sales@heartway.com.tw http://www.Heartway.com.tw...