Winnebago Journey Service Manual
Hide thumbs Also See for Journey:
Table of Contents

Advertisement

Rev. 1424150527
Part No. 161500-14-024
Copyright 2013 Winnebago Industries, Inc. All rights reserved.

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Journey and is the answer not in the manual?

Questions and answers

Gino
June 19, 2025

How do you turn the radio on on a 2015 journey

Mickey McKoy
June 3, 2025

Where is the Fuel / Air sensor located on the 2015 Winnebago Journey

Summary of Contents for Winnebago Journey

  • Page 1 Rev. 1424150527 Part No. 161500-14-024 Copyright 2013 Winnebago Industries, Inc. All rights reserved.
  • Page 3: Table Of Contents

    TABLE OF CONTENTS 1 – INTRODUCTION About this Manual ..........................1-1 Safety Messages Used in this Manual ....................1-1 Pre-Delivery Inspection ........................1-2 Front Axle Tire Alignment ....................... 1-2 Service and Assistance ........................1-2 Reporting Safety Defects ........................1-2 Occupant and Cargo Carrying Capacity Label ................. 1-3 Vehicle Certification Label .......................
  • Page 4 Table Of Contents Mirrors – Power Electric ........................3-6 Front Drop-Down Solar/Night Shade (12-Volt) ................3-8 Infotainment Center/GPS ........................3-9 CB Radio Power Wiring ......................... 3-12 Parking Brake ..........................3-12 Exhaust Restriction Braking System ....................3-13 Tag Axle Suspension System ......................3-13 Hazard Warning Flashers ........................
  • Page 5 Table Of Contents Solar Charge Panel ..........................4-9 Water Heater - Gas/ Electric ......................4-9 MotorAid Water Heater ........................4-10 Pressure-Temperature Relief Valve ....................4-11 Electronic Thermostat ........................4-12 Air Conditioner Filters ........................4-14 Washer/Dryer - Stackable ....................... 4-15 Washer/Dryer - Prep Package ......................4-16 5 –...
  • Page 6 Table Of Contents Drainage System (P-Traps) ......................7-10 Waste Water System ........................7-10 WaterLine and Tank Drain Valves ....................7-13 Water Heater Bypass Valve ......................7-14 Winterizing Procedures ........................7-14 Winterizing Optional Appliances ....................7-19 Water System Drain Valve Locations ..................... 7-22 8 –...
  • Page 7 Table Of Contents Slideout Room Troubleshooting (Power Gear®) ................10-6 Slideout Room Troubleshooting (Lippert) ..................10-8 Slideout Emergency Retraction (Power Gear®) ................10-9 Slideout Emergency Retraction (Lippert) ..................10-10 General Slideout Care ........................10-11 Leveling System ........................... 10-12 Checking Hydraulic Oil Level (Lippert) ..................10-14 11 –...
  • Page 8 Table Of Contents Roof Ladder ..........................12-10 Storage Compartment Doors ......................12-10 Compartment Lights Switch ......................12-10 Power Awning ..........................12-11 Stepwell Cover ..........................12-12 Windows ............................12-13 Power Roof Ventilator ........................12-14 Air Hose Connector ........................12-15 Effects of Prolonged Occupancy ....................12-15...
  • Page 9: Introduction

    The instructions included in this manual are intended as a guide, and in no way DANGER indicates a hazardous situation extend the responsibilities of Winnebago which, if not avoided, will result in death or Industries beyond the standard written serious personal injury.
  • Page 10: Pre-Delivery Inspection

    National Highway Traffic Safety Administration delivery inspection of the chassis and all (NHTSA) in addition to notifying Winnebago motorhome components. Industries, Inc. As a part of the pre-delivery inspection...
  • Page 11: Occupant And Cargo Carrying Capacity Label

    SECTION 1 – INTRODUCTION or go to their website at http://www.safercar.gov or write to: Administrator, NHTSA 1200 New Jersey Avenue S.E. Washington, D.C. 20590 You can also obtain other information about motor vehicle safety from the NHTSA website at http://www.safercar.gov OCCUPANT AND CARGO CARRYING CAPACITY LABEL This label is affixed in the driver’s area next to...
  • Page 12: Vehicle Certification Label

    These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.
  • Page 13: Specifications And Capacities

    100 gal. Notes: All information is based upon the most recent data available. Visit the Winnebago Industries, Inc. web page – www.winnebagoind.com – for the most current product information. The height of each model is measured to the top of the tallest standard feature and is based on the curb weight of a typically equipped unit.
  • Page 14: Owner And Vehicle Information

    Motorhome Serial Number ___________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...
  • Page 15: Safety And Precautions

    SECTION 2 – SAFETY AND PRECAUTIONS GENERAL WARNINGS DRIVING SAFETY • Only seats equipped with seat belts are to be occupied while the vehicle is moving. WARNING • Make sure all passengers have seat belts fastened. Lap belts should fit low on the hips and upper thighs.
  • Page 16: Fuel And Propane Gas

    SECTION 2 – SAFETY AND PRECAUTIONS • Do not operate the cruise control on icy or extremely wet roads, winding roads, in heavy WARNING traffic, or in any other traffic situation where a constant speed cannot be maintained. • Use care when accelerating or decelerating on Propane gas containers, gasoline, or a slippery surface.
  • Page 17: Propane Gas Leaks

    SECTION 2 – SAFETY AND PRECAUTIONS • Open doors and other ventilating openings. • Leave the area until odor clears. DA NG E R • Have the propane system checked and leakage source corrected before using again. Do not use gas cooking appliances for Failure to comply could result in death or comfort heating.
  • Page 18: Carbon Monoxide Warning

    ® fuel. It will detect CO gas from any combustion Winnebago Industries dealer. source such as the furnace, gas range/oven, water Further Information heater, refrigerator, chassis engine, and electric See the manufacturer’s user guide provided in...
  • Page 19: Smoke Alarm

    RV application. We that is also listed for RV application. We recommend obtaining a replacement from your recommend obtaining a replacement from your ® ® Winnebago Industries dealer. Winnebago Industries dealer. Further Information Further Information Please read the information provided by the See the manufacturer’s information in your...
  • Page 20: Electrical

    We recommend obtaining a replacement only from your Winnebago MAINTENANCE ® Industries dealer or a reliable RV parts supplier.
  • Page 21: Power Sofas And Beds

    SECTION 2 – SAFETY AND PRECAUTIONS POWER SOFAS AND BEDS WARNING Keep people away from operating mechanism and pinch hazard areas during use. Failure to do so could cause injury. Escape Window (Lift both red safety latch handles UP SLIDEOUT ROOMS and push window OUT) -Typical View WARNING...
  • Page 22: Formaldehyde Information

    Winnebago Industries ® throughout the outdoor and indoor air. Because If Winnebago Industries determines that mold of the nature of the use of a motorhome, it is ® ® is present in the Winnebago...
  • Page 23: Roof And Ladders

    Winnebago Industries within the limited the rungs are wet, or if your shoes are wet or warranty period, Winnebago will clean the carry mud or debris that could result in a loss affected area(s) and/or replace affected items as it of footing.
  • Page 24: Jump Starting

    If you see or hear steam escaping from the proper towing equipment to use. engine compartment or have any other reason to ® Winnebago Industries does not assume suspect an extreme engine overheating condition, responsibility for damage incurred while towing pull the vehicle over to the roadside as soon as it this vehicle.
  • Page 25 SECTION 2 – SAFETY AND PRECAUTIONS NOTICE Operating a vehicle under a severe overheating condition can result in damage to the vehicle. For information on what to do in case of overheating, consult your chassis manual. 2-11...
  • Page 27: Driving Your Motorhome

    The information in this section refers only to Lumbar Lift to Swivel features installed or adapted to the dash and Tension driver compartment area by Winnebago ® Industries . It also includes passenger seating in the living area of the coach.
  • Page 28: Seat Belts

    SECTION 3 – DRIVING YOUR MOTORHOME and a convenient built-in workstation. This flip- up hard surface tablet feature stores on the Armrest outboard side of the seat when not in use. Height To Use Tablet Adjuster • Extend tablet all the way out (toward front of coach).
  • Page 29: Child Restraints

    SECTION 3 – DRIVING YOUR MOTORHOME Adjustment To lengthen belt, swivel the tab end at a right WARNING angle to belt and pull strap to desired length. To shorten, pull loose end of belt. Never wear the shoulder belt in any To Fasten position other than as stated above.
  • Page 30: Keyone Lock System

    The key number for your coach is registered in our factory database, so if you ever lose your NOTE: The dinette table must be in the lowered ® keys, any Winnebago Industries dealership can position when a child seat is in use. order a new key for you.
  • Page 31: Accent Led Light Strips (Front)

    SECTION 3 – DRIVING YOUR MOTORHOME NOTE:Keys should always be removed when leaving the vehicle. Since doors can be locked without keys, make sure they have been removed from the ignition before locking the coach. Reprogramming Remote When replacing batteries, the remote unit may need to be reprogrammed with a push button on the keyless entry system control box.
  • Page 32: Mirrors - Power Electric

    SECTION 3 – DRIVING YOUR MOTORHOME Accent LED Light Strips -Typical View The Front AUX switch (located on the dash) Turn Signal Indicator Lights operates the LED Light Strips. -If Equipped Press Front AUX switch UP to turn ON. Press Your coach may be equipped with turn signal Front AUX switch DOWN to turn OFF.
  • Page 33 SECTION 3 – DRIVING YOUR MOTORHOME Mirror Heaters Mirror Arm/Head Adjustment The mirrors may also contain heating If you cannot adjust a mirror properly using elements to defog or de-ice the mirror glass the control switch, the mirror may need a coarse during cold weather operation.
  • Page 34: Front Drop-Down Solar/Night Shade (12-Volt)

    SECTION 3 – DRIVING YOUR MOTORHOME Mirror Arm Mounting Base Mirror Arm Pivot Bolt on underside of mounting base - Shown with access plug removed (Torque nut to 75-100 in./lbs.) Unscrew protective caps and loosen Allen head set screws to pivot mirror arm. (Torque screws to 75-100 in./lbs.) FRONT DROP-DOWN SOLAR/ If mirror arm will not pivot with set screws...
  • Page 35: Infotainment Center/Gps

    Refer to the manufacturer’s owner manual internal motor failure. and/or quick start guide provided in your Should the Automatic Safety Retraction InfoCase for a complete explanation of features feature deploy, go to your nearest Winnebago and operating/set-up instructions. ® Industries dealer for service before operating the shade again.
  • Page 36 SECTION 3 – DRIVING YOUR MOTORHOME Sideview Cameras The sideview cameras (built into the driver and passenger side mirrors) activate with the corresponding turn signals and replace the rear camera view on the monitor until the turn is completed or the signal lever is canceled manually.
  • Page 37: Radio Remote Controls

    SECTION 3 – DRIVING YOUR MOTORHOME Insert CD/DVD Insert GPS Card Eject iPod Connection (Located on dash) CD/DVD and GPS Card Reader -Typical View (Located on lower dash) • Open cover to access iPod Connection -Typical View USB Port Bluetooth Your coach may be equipped with a USB Port Your coach is equipped with a Bluetooth (located on the dash) to connect items such as...
  • Page 38: Cb Radio Power Wiring

    SECTION 3 – DRIVING YOUR MOTORHOME CB RADIO POWER WIRING Your coach is pre-wired for CB radio power connection. The wires are located beneath the dash to the left of the steering wheel. Look for a pair of wires - yellow (+) and white (-) with connectors and flag labels suspended from the wiring harness.
  • Page 39: Exhaust Restriction Braking System

    SECTION 3 – DRIVING YOUR MOTORHOME To use the Exhaust Brake NOTE: It is normal to hear an occasional burst of air pressure from the rear of the vehicle. This is an automatic moisture purging feature of the air brake system. See the Brakes section of your chassis manual for instructions on periodic draining of brake air tank.
  • Page 40: Hazard Warning Flashers

    SECTION 3 – DRIVING YOUR MOTORHOME the rear suspension/axle will be loaded to a HAZARD WARNING FLASHERS weight greater than 20,000 lbs. When certain conditions arise, air can be exhausted from the air The hazard warning flashers provide springs to improve maneuverability or traction additional safety when the vehicle must be on the rear axle by operating the Tag Axle switch stopped on the side of the roadway and presents a...
  • Page 41: Signal Lever/Headlight High-Low Beam

    SECTION 3 – DRIVING YOUR MOTORHOME SIGNAL LEVER/HEADLIGHT HIGH-LOW BEAM The signal lever controls the turn signals and headlight high/low beams. Driver Map Light Switch (Located on left side of dash) -Typical View Passenger Map Light Switch Press the Passenger Map Light switch UP to turn ON.
  • Page 42: Steering Column Adjustment

    SECTION 3 – DRIVING YOUR MOTORHOME NOTE: The House/Coach Battery Disconnect STEERING COLUMN switch near the entrance door must be ADJUSTMENT ON and house batteries must be sufficiently charged for this feature to The tilt/telescope adjustment pedal is located work. on the floor to the left of the steering column as shown.
  • Page 43: Defrost Fans

    SECTION 3 – DRIVING YOUR MOTORHOME A small amount of air will blow out of all The air horn sound units are located behind of the defrost and dash vents regardless the front grille assembly. of the mode setting. Further Information See the manufacturer’s user guide provided in your InfoCase for complete operating instructions.
  • Page 44: Filling The Fuel Tank - Diesel Engine

    SECTION 3 – DRIVING YOUR MOTORHOME Further Information FILLING THE FUEL TANK – Refer to the chassis manual provided in your DIESEL ENGINE InfoCase for the manufacturer’s recommendations on starting and stopping the Diesel fuel can foam up while being pumped engine.
  • Page 45: Front Service Access

    SECTION 3 – DRIVING YOUR MOTORHOME FRONT SERVICE ACCESS (HOOD) The front hood panel can be opened for access to the air hose connector and service items such as filling windshield washer fluid reservoir and checking the generator oil. Extending Front Hood Panel 1.
  • Page 46: Engine Access Covers - Rear

    SECTION 3 – DRIVING YOUR MOTORHOME Take precautions to protect carpet and interior furnishings when removing engine covers. The undersides of the engine covers could contain deposits of oil and fuel or other engine fluids and substances that could damage fabrics and interior furnishings.
  • Page 47 SECTION 3 – DRIVING YOUR MOTORHOME Suction Cup Lift 3. Remove fasteners from metal engine access cover and set cover aside. 3. Remove screws around perimeter of plywood 4. Reverse steps to reinstall engine access cover. panel. Remove panel and set aside. Rearward Engine Access Cover (Beneath wardrobe floor) In some cases, you may need further access of...
  • Page 48 SECTION 3 – DRIVING YOUR MOTORHOME • Forward Engine Access Cover • Route Air Bed Hoses through hole at the head of the bed. 3. Lower the bed board and remove mattress from bed and set aside in another area of the 6.
  • Page 49 SECTION 3 – DRIVING YOUR MOTORHOME • Rearward Engine Access Cover Step Cover Screw Locations -Typical installation shown 8. Reverse steps to reinstall engine access cover Raising the Bed Board (if required) and bed board. If additional clearance is required to remove the step cover screws, the bed board may be Model 40U raised to gain further access.
  • Page 50 SECTION 3 – DRIVING YOUR MOTORHOME Model 42E Forward Engine Access Cover (Beneath rear bath floor) 1. Remove rear bath rug (if equipped) and set aside. 2. Using the Engine Cover Latch Key (located on your key ring), unlock the Engine Cover Latch by turning counter-clockwise.
  • Page 51: Fuel/Water Separator - Diesel

    SECTION 3 – DRIVING YOUR MOTORHOME FUEL/WATER SEPARATOR – Suction Cup DIESEL Lift ® Freightliner Chassis Diesel fuel often contains small quantities of water, which can damage the engine if not filtered out. The Fuel/Water Separator traps this water and prevents it from reaching the engine. The harmful water deposits must be drained from the separator canister during normal periodic service and maintenance to keep the fuel...
  • Page 52: Diesel Exhaust Fluid Fill

    SECTION 3 – DRIVING YOUR MOTORHOME Further Information Refer to the chassis manual provided in your InfoCase for complete information and precautions. ENGINE COOLING SYSTEM Do not remove the radiator cap while engine and radiator are still hot. Always check coolant level visually at the see-through coolant Fuel/Water Separator Drain Valve reservoir.
  • Page 53: Circuit Breakers And Fuses - Chassis/Dash Automotive 12-Volt

    SECTION 3 – DRIVING YOUR MOTORHOME Automotive Circuit Breakers (push to reset) Chassis Battery Disconnect Switch • Breakers are labeled for components equipped (Located near entrance door) -Typical View Turn the switch to the OFF or ON positions to disconnect or reconnect the chassis batteries. NOTE: The Chassis Battery Disconnect switch must be on to start the engine.
  • Page 54: Windshield Washers And Wipers

    SECTION 3 – DRIVING YOUR MOTORHOME WINDSHIELD WASHERS AND WIPERS The Windshield Washer Fluid Reservoir is located behind the front hood panel (see “Front Service Access” elsewhere in this section for instructions on opening the hood panel). We recommend using commercially available premixed solutions for best results.
  • Page 55: Suspension Alignment And Tire Balance

    SECTION 3 – DRIVING YOUR MOTORHOME Further Information SUSPENSION ALIGNMENT Refer to the chassis manual in your InfoCase AND TIRE BALANCE for further information. The front suspension and steering system of this vehicle was factory aligned using highly accurate equipment prior to delivery to the dealership.
  • Page 57: Appliances And Systems

    SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motorhome are not intended to operate with inverter power are manufactured by reputable RV appliance for long periods of time as they too will quickly makers and have been tested by independent drain your house batteries.
  • Page 58: Refrigerator

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information NOTE: Allow 24 hours for your refrigerator to cool completely before storing food. See the manufacturer’s user guide provided in your InfoCase for further key features as well as Ice Maker operating, safety, maintenance, and •...
  • Page 59: Ice Maker

    SECTION 4 – APPLIANCES AND SYSTEMS AC (Electric Mode) - Refrigerator will operate on 120-VAC household current if the shoreline is connected or the auxiliary generator is running. AU (Automatic Mode) - Refrigerator will automatically start operating on 120-VAC household current if the shoreline is connected or the auxiliary generator is running.
  • Page 60: Refrigerator Service Access Compartment - Residential Refrigerator

    SECTION 4 – APPLIANCES AND SYSTEMS To Open NOTE: A water shut-off valve for the ice maker is located near the water faucet filter 1. Use a screwdriver or coin to turn the latch inside the galley cabinet beneath the knobs to the vertical position as shown.
  • Page 61: Tailgate Package

    SECTION 4 – APPLIANCES AND SYSTEMS • To extend the refrigerator/freezer unit for easier access, release the slide tray lock • To extend the slide tray, release the slide tray mechanism by lifting UP. lock mechanism by lifting UP. • Grasp the underside of the slide tray and •...
  • Page 62: Microwave Oven/Range Hood

    SECTION 4 – APPLIANCES AND SYSTEMS MICROWAVE OVEN/RANGE HOOD -If Equipped The range hood vent is built into the microwave oven. The range hood fan carries cooking odors and gas fumes to the outside of the coach. A light on the underside of the hood provides illumination for food preparation.
  • Page 63: Oneplace® Systems Monitor Panel

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information See the appliance manufacturer’s user guide DA NG E R provided your InfoCase for complete operating instructions and safety precautions. Do not use gas cooking appliances for ONEPLACE SYSTEMS comfort heating. May lead to carbon ®...
  • Page 64: Water Pump Switch

    SECTION 4 – APPLIANCES AND SYSTEMS • An interior light should be turned on to provide a small load which draws off the battery surface charge. Water Heater Switches Sensors See Water Heater information elsewhere in this section for operating instructions. Water Tank -Typical View Tank Capacities...
  • Page 65: Power Control System (Pcs)

    SECTION 4 – APPLIANCES AND SYSTEMS POWER CONTROL SYSTEM (PCS) The Power Control System (PCS) monitors the electrical usage of the appliances and equipment in the coach and allows you to use certain high energy appliances, such as the microwave or washer/dryer, without overloading the shoreline circuit breaker to prevent nuisance tripping.
  • Page 66: Motoraid Water Heater

    SECTION 4 – APPLIANCES AND SYSTEMS See the Water Heater manufacturer’s operation manual provided in your InfoCase for complete operating instructions, safety warnings, and maintenance information before operating the Water Heater. Be sure the Water Heater is filled with water before starting either electric or propane gas operation.
  • Page 67: Pressure-Temperature Relief Valve

    SECTION 4 – APPLIANCES AND SYSTEMS CAUTION NOTICE Any leak in the heat exchanger or its Hot water can escape from tank causing supply or return lines could cause loss of injury. Operate this valve only when the coolant and subsequent engine failure. tank water is cold.
  • Page 68: Electronic Thermostat

    SECTION 4 – APPLIANCES AND SYSTEMS NOTE: The Thermostat does not automatically ELECTRONIC THERMOSTAT switch between heating and cooling. You must manually select desired system. (Heating and Cooling) The Electronic Thermostat (located near the Heating monitor panel) controls the propane furnace, as 1.
  • Page 69: Heat Pump

    SECTION 4 – APPLIANCES AND SYSTEMS NOTE: Repeat steps for each zone. If the word “Set” is not shown, then the temperature shown is the actual room Heat Pump temperature in the displayed zone. Your coach is equipped with an air source Changing Temperature Setpoints Heat Pump built into the air conditioning system.
  • Page 70: Air Conditioner Filters

    NOTE: It is normal for some water to run off the roof when using your air conditioner in “heat pump” mode. ® See your Winnebago Industries dealer for service and proper cleaning of the drain lines. NOTICE Water running off the roof is a sign the condensate drain lines are plugged and require service.
  • Page 71: Washer/Dryer - Stackable

    SECTION 4 – APPLIANCES AND SYSTEMS NOTE: There are multiple Supply and Return within the rear wardrobe (Models 34B and 40U), Vents throughout the coach. Therefore, or beneath the rear bath lavatory cabinet (Model you must remember to remove each 42E).
  • Page 72: Washer/Dryer - Prep Package

    Water Supply Faucets -Typical installation shown We recommend obtaining parts and service for the Washer/Dryer installation from your ® ® Winnebago or Itasca dealer. Water Supply Faucets (Located beneath rear bath lavatory cabinet) * Remove top lavatory cabinet drawer to access See “Winterizing Optional Appliances”...
  • Page 73: Propane Gas

    SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY Tank Gauge & Tank Fill Overflow Sender The propane gas system supplies fuel for the Valve Valve gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides modern living conveniences wherever you travel.
  • Page 74: Propane Accessory Connection

    SECTION 5 – PROPANE GAS propane gas outlets in the United States do not offer any other type of liquefied petroleum gas WARNING than propane to the general public.) Check local phone directory yellow pages for locations of local propane gas refilling stations or bulk Do not fill propane container(s) to more dealerships.
  • Page 75: Safe Use Of The Propane Gas System

    SECTION 5 – PROPANE GAS “clockwise” to turn gas supply OFF. Rotate the shut-off valve “counter-clockwise” to turn gas CAUTION supply ON. See Section 2 - Safety and Precautions in this manual for other safety and precautions you need Turn valve off when not in use. to be aware of related to propane.
  • Page 76: Propane Gas Warnings And Precautions

    SECTION 5 – PROPANE GAS • Have the entire propane gas system inspected for possible leaks and missing or damaged DA NG E R parts at each tank filling. Also inspect before and after each trip, and any time trouble is suspected.
  • Page 77: Propane Gas Pressure Regulator

    SECTION 5 – PROPANE GAS • Never use an open flame to test for propane NOTE: If your model is equipped with a propane gas leaks. Replace all protective covers and powered electrical generator, there will caps on propane system after filling. Make be two regulators stacked one upon sure valve is closed and door latched securely.
  • Page 78: Propane Vaporization In Cold Weather

    SECTION 5 – PROPANE GAS tank and bottle manufacturers, and propane gas dealers take every precaution to reduce moisture, but sometimes only a fraction of an ounce entering the tank can cause problems. To help avoid the possibility of freeze-up, always keep tank control valve closed when not in use, even when tank is empty, to prevent moisture from collecting on the inside.
  • Page 79: Electrical

    SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motorhome that is • 12-volt DC system (battery current);...
  • Page 80: Connecting The Power Cord

    SECTION 6 – ELECTRICAL be used is designed to mate with the prongs of the power cord plug, the electrical connection can be WARNING expected to carry rated load. Connecting The Power Cord This connection is for 208Y/120-Volt or To connect to an external source, remove the 120/240 Volt AC, 3-pole, 4 wire, 60 Hz cord from the utility compartment and plug it into 50 Ampere supply.
  • Page 81: Charging Section

    SECTION 6 – ELECTRICAL shoreline or generator power. The inverter can also be used while driving the motorhome because the engine alternator will charge the batteries while driving. The inverter/charger unit is accessible through a mid-passenger side compartment door. WARNING Service inlet access must be closed when utility connections are not in use.
  • Page 82: Inverter/Charger Unit - 2000W

    SECTION 6 – ELECTRICAL If the house batteries have been significantly NOTE: Your coach may be equipped with a discharged, they will accept charge at a relatively residential-style refrigerator, which will high amperage rate. If they are only slightly only operate on 120-volt AC. The discharged, they will charge at a lower amperage residential refrigerator requires either rate.
  • Page 83 SECTION 6 – ELECTRICAL If the batteries do not charge as described above, it is possible the batteries are defective. If the batteries are extremely discharged, the charger may not be able to recharge the batteries. NOTE: Do not leave the shoreline plugged in during storage.
  • Page 84: Circuit Breakers - House 120-Volt Ac

    SECTION 6 – ELECTRICAL Further Information ELECTRICAL OUTLETS – See the inverter/charger manufacturer’s user HOUSE 120-VOLT AC guide provided in your InfoCase for complete instructions and charging setup directions. A number of standard household electrical outlets are provided throughout the coach for CIRCUIT BREAKERS –...
  • Page 85: Electrical Generator

    SECTION 6 – ELECTRICAL WARNING The GFCI will not completely eliminate the risk of electrical shock. Infants and small children may still be affected. ELECTRICAL GENERATOR WARNING Automatic Power Transfer Box (Located inside or behind utility compartment) Careless handling of the generator and -Typical installation shown electrical components can be fatal.
  • Page 86: Generator Operation

    SECTION 6 – ELECTRICAL Generator Operation Operation Warnings and Cautions To Start the Generator Press and Hold the “Start/Preheat” button on WARNING the AGS Control Pad until you hear the Generator running smoothly, then release. The exhaust of all internal combustion To Stop the Generator engines contains carbon monoxide (CO).
  • Page 87: Electrical System - House 12-Volt Dc

    SECTION 6 – ELECTRICAL ELECTRICAL SYSTEM – BATTERY INFORMATION HOUSE 12-VOLT DC Chassis Batteries The DC voltage system consists of the chassis The chassis batteries operate the engine starter battery, the 12-volt house batteries, and the 12- and all automotive accessories and controls volt power converter.
  • Page 88: House/Coach Battery Disconnect Switch

    SECTION 6 – ELECTRICAL NOTE: House batteries are AGM (Absorbed The house/coach batteries are located within Glass Mat). Because of their the basement of the coach, which is accessible construction, AGM batteries do not beneath an access cover inside driver and require an addition of water to the cells.
  • Page 89: Battery Care

    SECTION 6 – ELECTRICAL The two best defenses against sulfating and insufficient charge are to: 1. Turn off the House/Coach Battery Disconnect switch to avoid parasitic discharge (the trickle discharge caused by directly connected components like propane gas detectors or digital clock displays, etc.) 2.
  • Page 90: Circuit Breakers - House 12-Volt

    If your coach is going to be unoccupied for battery, make sure all 12-volt equipment ® two weeks or more, Winnebago Industries in the motorhome is off and the power recommends disconnecting the chassis batteries cord has been disconnected. Be sure to in your coach to avoid battery discharge.
  • Page 91 SECTION 6 – ELECTRICAL House Circuit Breakers -Typical View Typical view of breaker panel. Actual breaker panel location may vary according to model floorplan. Breakers are labeled on panel according to appliance and equipment options. 6-13...
  • Page 93: Plumbing

    SECTION 7 – PLUMBING FRESH WATER SYSTEM The Fresh Water System provides water to the galley sink, shower, bathroom lavatory, and toilet. Water may be supplied by either of two sources: • A fresh water tank and water pump located within the motorhome, or •...
  • Page 94 SECTION 7 – PLUMBING NOTE: Always keep the Fresh Water valve in Normal position unless you are filling the NOTICE tank. If this valve is left in the Tank Fill position while using the city water, water will keep flowing into the tank and out Do not leave fresh water connection the tank vent tube onto the ground and unattended when filling tank.
  • Page 95: Utility Light

    SECTION 7 – PLUMBING demand pump is designed to run only when you are using water. When you open a faucet, the waterline pressure drops and the pump begins to run, and it will continue to run as long as the faucet is open.
  • Page 96: Cold Water Filter

    SECTION 7 – PLUMBING Further Information • Remove the bowl and pull the strainer screen out of the bowl to tap out any particles and Refer to the Water Pump manufacturer’s rinse clean. operation, care, and maintenance information • Insert the strainer screen back into the bowl, provided in your InfoCase.
  • Page 97: Ice Maker Water Filter

    SECTION 7 – PLUMBING Replacing the Cold Water Filter Cartridge You should replace the filter cartridge every season and when water flow from the faucet is too slow for convenience. The cartridge must be replaced at least every 12 months. •...
  • Page 98: Full-Coach Water Filtration System

    SECTION 7 – PLUMBING • Insert a new filter cartridge up into the filter socket as far as possible and twist it clockwise (to the right) one-quarter turn until it stops. • Discard the first two batches of ice cubes to avoid consuming carbon dust or particles that may have been present in the new filter cartridge.
  • Page 99: Disinfecting Your Fresh Water System

    SECTION 7 – PLUMBING • Remove the filter canister from the filter head. • Insert a new filter cartridge into the canister, Use the filter wrench supplied to loosen the then hand tighten the canister securely onto filter canister. the filter head. DO NOT OVER-TIGHTEN. •...
  • Page 100 SECTION 7 – PLUMBING City Water Tank and Hose NOTE: This solution will result in a residual chlorine concentration of approximately Disinfection 50 ppm in the water system. (If a 100 This procedure can be used periodically to ppm concentration is desired, use 3 cups sanitize the city water hose, and can be used as an of household bleach).
  • Page 101: Shower Hose Vacuum Breaker

    SECTION 7 – PLUMBING • Chlorine will be removed from drinking water TOILET by the Full-Coach Water Filtration System and by the separate Filtered Water Faucet. -If Equipped • Superchlorination does not affect city water The toilet in your motorhome is very similar usage, only the fresh water tank.
  • Page 102: Drainage System (P-Traps)

    SECTION 7 – PLUMBING See winterizing instructions at the end of this Water Saver Flush Normal Flush section to prepare the toilet for storage in freezing conditions. Further Information See the toilet manufacturer’s operation information provided in your InfoCase for complete operating, care, and maintenance information.
  • Page 103 SECTION 7 – PLUMBING The sewage drain hose is located in the water open. If you open the dump valve before service center. the hose valve, the hose will fill with sewage water and become difficult to 1. Remove the dust cap from the sewage drain move or could become clogged.
  • Page 104 SECTION 7 – PLUMBING Tank Drain valve and drain the tank again. 3. Attach a garden hose from a city water Close Black Waste Tank Drain valve when hydrant to the Black Waste Tank Flush Inlet done). fitting in the water service center. (This inlet is clearly marked separate from the City Water 6.
  • Page 105: Holding Tank Level Indicators

    SECTION 7 – PLUMBING Water Tank Drain Valve site. This keeps the solids in suspension, allowing them to be carried out with the liquids when the dump valve is opened. If the valve is left open, the liquids will drain off, leaving solids in the tank.
  • Page 106: Water Heater Bypass Valve

    SECTION 7 – PLUMBING 2. Drain Fresh Water Tank and Waterlines. WATER HEATER BYPASS Open all waterline drain valves and drain VALVE fresh water tank. (See “Water System Drain Valve Locations” chart at end of this section Your coach may be equipped with a water for locations on your model).
  • Page 107 SECTION 7 – PLUMBING After emptying the canister, remount it onto the filter assembly and continue the Blow-Out Procedure. 6. Open Faucets. Turn on the Water Pump switch and open all sink faucets and shower head knobs. Leave open after water stops flowing.
  • Page 108 A blow-out plug can be purchased at any each drain for the galley sink, lavatory sink, and shower/tub. This fills the drain trap pipes ® ® Winnebago or Itasca dealer. to prevent holding tank odors from entering the coach during storage.
  • Page 109 SECTION 7 – PLUMBING 21. Close waste tank drain valves and refit the dust cap onto the sewage drain outlet. This will inhibit rust formation on valve shafts and prevent entry and contamination by airborne debris, insects, and rodents. Your drainage and fresh water systems are now winterized.
  • Page 110 SECTION 7 – PLUMBING Set Up Winterization Valves 3. Turn Winterization Valve 1 to “Water Heater Bypass” position to avoid filling water heater with antifreeze. RV Antifreeze Siphon Tube (Located near water pump - second compartment on driver side of coach) •...
  • Page 111: Winterizing Optional Appliances

    SECTION 7 – PLUMBING Drain Water Heater section.) If not equipped with optional appliances, 12. Turn off the Water Heater power switch proceed to the next numbered step. before draining the water heater tank to avoid damage to the heating element. Fill Drainage System P-Traps •...
  • Page 112 SECTION 7 – PLUMBING Ice Maker Water Supply Connection Ice Maker Drain Line (Located in refrigerator service access (Located in exterior Residential compartment on outside of coach) Refrigerator service compartment) -Typical View 3. Turn Ice Maker Winterization Drain valve to the OPEN position.
  • Page 113 SECTION 7 – PLUMBING 4. Turn the water supply ON. 3. With Washer/Dryer power OFF, pour 1/2 TBSP. of powder detergent (or liquid 5. Ensure the ice bin is in place and the wire shut- equivalent) into “Compartment 2” inside off arm is lowered to the ON position.
  • Page 114: Water System Drain Valve Locations

    SECTION 7 – PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS System Drain Valve Locations Waterline Drain Valves • Models 34B, 36M, 40U, and 42E: Two (2) waterline drain caps located inside the water pump compartment (second compartment on driver side). Open exterior shower faucet and lay shower head on ground.
  • Page 115: Entertainment

    Secondary Source Selector Control (Located in front passenger overhead cabinet) (Located in your InfoCase Box) To Watch Satellite TV NOTE: There may be a slight delay when changing sources. Winnebago • Connect Satellite Receiver to the Accessory ® Industries recommends setting each Connection Cable (Satellite Receiver 1 or 2.)
  • Page 116 SECTION 8 – ENTERTAINMENT • Power “ON” TV, HDMI Video Selection All TV’s in the coach will now be connected System, and Satellite Receiver. to the roof antenna (via coax cable) and set TV to be viewed through antenna input. •...
  • Page 117: Front Tv Ignition Switch Interlock

    SECTION 8 – ENTERTAINMENT To Listen to FM Radio Through Home Theater • Power “ON” TV, HDMI Video Selection System, and Blu-ray/DVD Home Theater. • Determine which TV you want to view radio source from (e.g. EXTERIOR for Exterior Entertainment Center TV) and select “Blu- ray”...
  • Page 118 SECTION 8 – ENTERTAINMENT Home Theater System remote (or “Play” button on Home Theater System) to begin playing the feature. 8. Volume is adjusted with the 3. Set TV Input to HDMI1 by using the TV Home Theater System remote remote or the Controls on the TV.
  • Page 119: Blu-Ray /Dvd Player And Sound Bar System

    SECTION 8 – ENTERTAINMENT Further Information select the desired entry or press the “Enter” button on the Blu-ray/DVD player remote to See the manufacturer’s user guide provided in begin playing the feature. your InfoCase for complete feature descriptions 8. Volume is adjusted with the Blu-ray/DVD and operating instructions.
  • Page 120: Tv (Dining Buffet) - Power Lift

    SECTION 8 – ENTERTAINMENT 2. Continue to raise TV to the height that best TV (DINING BUFFET) - POWER suits your viewing needs. LIFT -If Equipped (Typical View - your coach may vary in appearance) Your coach may be equipped with a TV power lift/lower mechanism built into the dining buffet which allows you to raise and lower the TV with a touch of a switch.
  • Page 121: Tv Antenna - Digital

    SECTION 8 – ENTERTAINMENT Digital Antenna Power Switch (Located in an overhead cabinet or mounted on a wall near the TV) 2. Pull the TV out and pivot to desired position. 2. Turn ON the Signal Meter Power switch 3. Rotate TV back to center position and press (located on the side of the Signal Meter).
  • Page 122: Tv Signal Amplifier

    A second connection may be included inside a cabinet in the bedroom for the rear TV (if equipped). ® See your authorized Winnebago Industries dealer for proper installation and sealing of roof mounted components. To Access Interior Satellite Dish TV Signal Amplifier Power Switch...
  • Page 123: Tv Digital Satellite System (Automatic/In-Motion)

    SECTION 8 – ENTERTAINMENT HDMI Connection Cable (Located in cabinet near bedroom TV) Access Panel Cover Latches • Turn “counter-clockwise” to remove cover TV DIGITAL SATELLITE SYSTEM (AUTOMATIC/IN- • Remove access panel and set aside. You have MOTION) now accessed the Interior Satellite Dish Connections.
  • Page 124: Tv Digital Satellite System - Automatic

    SECTION 8 – ENTERTAINMENT TV DIGITAL SATELLITE SYSTEM – AUTOMATIC –If Equipped The Automatic Multi-Satellite Television System allows you to receive TV programs directly from satellite to your coach. We recommend that you read the satellite dish manual thoroughly to understand the system completely before attempting any setups or adjustments.
  • Page 125: Exterior Entertainment Center (Adjustable)

    SECTION 8 – ENTERTAINMENT To Swivel TV 3. To turn off the power after it has locked onto satellites, press the “POWER” and “SELECT” buttons at the same time. Note: The Automatic Multi-Satellite antenna is not meant for use while traveling. Do not move the vehicle until the antenna is stowed.
  • Page 127: Furniture And Softgoods

    SECTION 9 – FURNITURE AND SOFTGOODS LOUNGE CHAIR - SWIVEL –If Equipped (Typical View – Your coach may differ in appearance) This chair is not equipped with a seat belt and is not intended for seating while the vehicle is in motion.
  • Page 128 SECTION 9 – FURNITURE AND SOFTGOODS WARNING Properly secure all free-standing chairs, furniture, and loose items prior to driving. Moving items can cause driver distraction, possibly resulting in an accident that can result in death or serious injury. Storing Buffet Chairs 1.
  • Page 129: Sliding Buffet Table And Chairs

    SECTION 9 – FURNITURE AND SOFTGOODS NOTE: The Buffet Table Extension is located SLIDING BUFFET TABLE AND inside a lounge or galley storage cabinet, CHAIRS depending on model. –If Equipped (Typical View – Your coach may differ in appearance) Buffet Chairs The Buffet Chairs are free-standing to allow greater freedom of movement.
  • Page 130 SECTION 9 – FURNITURE AND SOFTGOODS 2. Push chairs against opposite sides of the Buffet Table Extension buffet table. 1. Grasp the edge of the buffet table and pull all the way out. 3. Bind chairs together with the provided strap, ensuring the strap goes through the ring located on the bottom side of the buffet table.
  • Page 131: Sleeping Facilities

    SECTION 9 – FURNITURE AND SOFTGOODS SLEEPING FACILITIES 4. Push edge of buffet table in until it locks into place. WARNING Sleeping facilities are not intended for use while vehicle is in motion. For safety, passengers must use safety belted seating positions while vehicle is in motion.
  • Page 132 SECTION 9 – FURNITURE AND SOFTGOODS 2. Flip seat back support upright. NOTICE Engage bracket to prevent damage. 3. Grasp the pull strap (located on the back side of the sectional extension seat cushion) and pull UP and OUT. 5. Install seat back cushion, ensuring the back slip cover slides over top of the seat back to secure.
  • Page 133 SECTION 9 – FURNITURE AND SOFTGOODS 6. Repeat Steps 1 through 5 on opposite dinette 11. Reverse steps to convert into single dinette seat. seating. 7. Loosen knobs beneath dinette table (one Dinette to Bed located on each side of table). •...
  • Page 134: Extendable Sectional Sofa/Sleeper

    SECTION 9 – FURNITURE AND SOFTGOODS • Arrange dinette cushions to cover bed area. • Lower dinette table to the floor. • Reverse steps to convert back into dinette • Grasp the dinette table extension and pull seating. OUT to fully extended position. NOTICE Stow furniture extension before retracting slide rooms.
  • Page 135 SECTION 9 – FURNITURE AND SOFTGOODS Sectional Extension • Engage and Hold the black lever (located on the inboard sectional sofa arm) and fully extend sectional extension. • Push front of seat cushion rearward to secure into seated position. • Flip seat back support upright.
  • Page 136 SECTION 9 – FURNITURE AND SOFTGOODS 3. Rotate the lever lock (located on the bottom • Reverse steps to store sectional extension. right-hand side of the sofa/sleeper) Sofa/Sleeper Conversion “clockwise” to release the bottom section of the sofa/sleeper. 1. Remove sofa seat back cushions and set aside. 4.
  • Page 137 SECTION 9 – FURNITURE AND SOFTGOODS Silent Night Comfort Adjust If your air bed pressure drops below the NOTE: The air mattress is plugged into an AC predetermined pressure level, the Silent Night power outlet behind the sofa. Comfort Adjust Pump will automatically turn on It may be necessary to press the “Reset”...
  • Page 138 SECTION 9 – FURNITURE AND SOFTGOODS NOTE: Pump will automatically turn off and the Inflate/Deflate switch will automatically return to the OFF position upon complete deflation. 5. Rotate the lever lock “counter-clockwise”, securing the bottom section of the sofa/sleeper into locked position. 3.
  • Page 139: Sofa/Bed Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS Further Information Refer to the air mattress manufacturer’s user guide provided in your InfoCase for complete operating instructions, safety precautions, and Security Latch Handle repair information. (Shown with sofa seat lifted) - Press DOWN to release SOFA/BED CONVERSION •...
  • Page 140: Rest Easy Multi-Position Lounge

    SECTION 9 – FURNITURE AND SOFTGOODS • Press the Rest Easy Power switch toward the REST EASY MULTI-POSITION ® outboard side of the lounge to return upright. LOUNGE NOTE: Ensure house batteries contain adequate –If Equipped charge. If the batteries are partially (Typical View –...
  • Page 141: Extendable Sectional Sofa

    SECTION 9 – FURNITURE AND SOFTGOODS Bed Conversion • Extend footrest and push together with the lounge seat cushion. • Press Rest Easy Power switch in the recline position until entire lounge lies flat. • Reverse steps to return to lounge seating. NOTE: The gap between the footrest and seat should provide ample room to enter and exit the lounge.
  • Page 142 SECTION 9 – FURNITURE AND SOFTGOODS 4. Push front of seat cushion down, and then push rearward to secure the seat cushion into place. 5. Flip seat back support upright. 2. Fully extend the sectional extension. 6. Install seat back cushion. 3.
  • Page 143: Digital Sleep Air Bed

    SECTION 9 – FURNITURE AND SOFTGOODS DIGITAL SLEEP AIR BED BED - POWER LIFT ® by Innomax –If Equipped (Typical View – Your coach may differ in –If Equipped appearance) • Memory feature allows Your coach may be equipped with a power •...
  • Page 144: Roller Shades (Manual) - Solar/Blackout

    –If Equipped NOTICE People are drawn to the natural beauty of ® wood. At Winnebago Industries , our craftsmen work with the art found in each piece of wood to Bed must be in the fully upright (vertical) create cabinets of superior quality, backed by the position to fully retract slideroom.
  • Page 145 SECTION 9 – FURNITURE AND SOFTGOODS Stains are likely to exaggerate the difference between open and closed grains and other markings in wood. Grain variation and color change should be expected. As hardwood ages, it will darken when exposed to different types of light.
  • Page 147: Slideout Rooms And Leveling

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING To Release SLIDEOUT ROOM TRAVEL • Press and hold the UNLOCK side of the LOCKS - ELECTRIC Slideout Room Travel Lock switch for –If Equipped approximately 7 seconds. (You may be able to hear the lock motor sound stop).
  • Page 148: Slideout Room Travel Locks

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING NOTICE Release and remove Slideout Prop-Lock Rods before attempting to extend slideout room. Damage to the vehicle will result if this is not done. Position and secure Prop-Locks before driving vehicle. See following instructions. Place T-shaped Slideout Lock Drain Line Place flat plate end...
  • Page 149: Slideout Room Retraction (With Power Lift Bed)

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING 4. Repeat steps 1-3 for the rearward end of the retracted passenger side slideout room. • During vehicle stops, check and retighten as necessary. SLIDEOUT ROOM RETRACTION (WITH POWER LIFT BED) -If Equipped Your coach may be equipped with a power Slideout Room Keylock lift/lower mechanism that raises and lowers the...
  • Page 150 SECTION 10 – SLIDEOUT ROOMS AND LEVELING To Extend Slideout Room Before Extending! • Level the coach and set the Parking Brake. • Release the travel lock or latch (if equipped) inside the coach. See information at beginning of this section (if equipped). •...
  • Page 151: Slideout Room - Extreme Weather Precaution

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING To Retract Slideout Room the slideout roof. Retract the slideout slowly, starting and stopping to allow water to drain off Before Retracting! room cover. • Be sure the coach is level and the Parking Brake is set.
  • Page 152: Slideout Room Troubleshooting (Power Gear®)

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING • The circuit breaker may be tripped. The circuit breaker, labeled “Slideout Power” is located on a panel on an interior wall of the passenger side storage compartment just behind or ahead of the entrance door. Problems Retracting the Room •...
  • Page 153 SECTION 10 – SLIDEOUT ROOMS AND LEVELING • Take your vehicle to an authorized service In the event of a total system failure where center for repair. Manual Mode cannot be used, two crank handles may be used to retract or extend the room. See Before operating the room after an error has Slideout Emergency Retraction - Electric been detected, check for obvious faults such as...
  • Page 154: Slideout Room Troubleshooting (Lippert)

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING • Take your vehicle to an authorized service • Motor center for repair. • Mode • Status Direction Button LED’s Further Information See the slideout room operating guide included in your InfoCase for further instructions and troubleshooting information.
  • Page 155: Slideout Emergency Retraction (Power Gear )

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING Crank-In Procedure • (9) - HALL POWER SHORT TO GROUND. Power to encoder has been • Disengage the motor brakes, which appear as shorted to ground. This is usually a wiring a flat “square” protrusion on the protective problem.
  • Page 156: Slideout Emergency Retraction (Lippert)

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING • Fasten slideout room travel latching device (if equipped) inside the coach before driving the vehicle. • See your dealer for service of the slideout mechanism before using again. Further Information See the Slideout Room operating guide included in your InfoCase for further instructions and troubleshooting information.
  • Page 157: General Slideout Care

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING 7. When the slideout room is fully retracted, secure the room with a support item (e.g. 2x4 wood board) above the interior slideout room to secure room during travel. NOTE: For larger slideout rooms, place a travel support item on each end of the interior slideout room.
  • Page 158: Leveling System

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING Slideout Room Seal Care and while in PARK, raising either one or both of the rear wheels off the ground could Maintenance allow the vehicle to roll off the jacks. While most household cleaners work well for cleaning slideout room seals, certain chemical agents may cause the seals to degrade.
  • Page 159 SECTION 10 – SLIDEOUT ROOMS AND LEVELING This switch allows you to extend or retract your jacks and observe them at the same time. It NOTICE also allows you to stop them suddenly, if needed, without having to climb in and out of the coach. The Auto Level Remove switch is located in •...
  • Page 160: Checking Hydraulic Oil Level (Lippert)

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING CHECKING HYDRAULIC OIL Breather/Fill Cap LEVEL (LIPPERT) See the Leveling System Operation Guide provided in your InfoCase for complete maintenance instructions and information. All maintenance should be done as part of the normal servicing of the coach. The hydraulic oil level should be checked when the vehicle is first purchased and after any extended storage.
  • Page 161: Maintenance And Storage

    • Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.
  • Page 162: Exterior Automotive Paint Finish

    SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the • Do not scrape ice or snow from the painted amount of cargo you can carry and remain within surface. Brush off gently with a soft-bristled GVWR and GAWR limits.
  • Page 163 SECTION 11 – MAINTENANCE AND STORAGE Washing NOTE:Avoid aiming water flow from a hose or spray from high-pressure washing • Commercial vehicle wash facilities should be equipment into any appliance intake, as strictly avoided! They will scratch your RV! damage or difficulty in operating Truck-style wash centers have high- appliances may occur.
  • Page 164: Exterior Graphic Care

    SECTION 11 – MAINTENANCE AND STORAGE Further Information • Avoid paste waxes. They sometimes have fillers and additives that give a very short term See the manufacturer’s information provided result. Stay away from silicones in polishes in your InfoCase for complete care and and soaps.
  • Page 165: Plastic Parts - Cleaning

    LIGHTS cleaning products to use on plastic parts. Exterior Light Lenses ® Most Winnebago Industries vehicles have NOTICE polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical Do not use citrus-based cleaners on solvents and cleaners.
  • Page 166: Interior Soft Goods

    SECTION 11 – MAINTENANCE AND STORAGE automobiles. This type of lamp assembly is not sealed from the atmosphere and is designed with WARNING a moisture venting system. Because they are not sealed, under “dew point” conditions the headlights may exhibit When cleaning upholstery and fabric, do signs of humidity condensation on the reflector not use lacquer thinner, nail polish...
  • Page 167: Cabinetry - Cleaning

    SECTION 11 – MAINTENANCE AND STORAGE Vinyl simulated wood panels may be cleaned with a mild, water-based cleaner and a soft cloth. UltraLeather Cleaning Chart Do not use solvents on vinyl wood panels. Detergent/ Cleaner/ Type of Stain Water Degreaser NOTE: Many cabinetry and furniture items ...
  • Page 168: Care And Maintenance

    SECTION 11 – MAINTENANCE AND STORAGE To remove cuts and scratches, use a more Stainless steel does not deteriorate due to ® aggressive cleaning powder such as Comet frequent cleaning, so proper cleaning can be moistened steel wool soap pad, or green scouring performed whenever necessary.
  • Page 169: Galley Sink

    SECTION 11 – MAINTENANCE AND STORAGE Important “Don’ts” RANGE AND REFRIGERATOR • Do not use hydrochloric acid or any other For care and appearance maintenance of the detergents containing chlorides on stainless range and refrigerator, refer to the appliance steel. manufacturer’s operation and maintenance •...
  • Page 170: Bathroom

    SECTION 11 – MAINTENANCE AND STORAGE NOTE: For heavy soil, a damp mop with a Mineral-Based Stains. Cleaners designed to heavy-duty cleaner may be used. Rinse remove iron or rust should not harm the sink, nor with clean water. will solvents such as denatured alcohol, mineral Dried adhesive or stubborn stains may spirits, or acetone.
  • Page 171: Vehicle Storage - Removal

    SECTION 11 – MAINTENANCE AND STORAGE month during long-term storage periods to VEHICLE STORAGE – maintain battery charge and to avoid REMOVAL sulfating. If connecting a charger directly to batteries, turn the House/Coach Battery 1. Completely air out the motorhome. Disconnect switch off to avoid electrical 2.
  • Page 172: Chassis Service And Maintenance

    SECTION 11 – MAINTENANCE AND STORAGE 16. Check tires for proper cold inflation pressure. CHASSIS FUSES AND RELAYS See Vehicle Certification Label in Introduction section. ® -Freightliner Chassis 17. After washing accumulated winter grime Chassis and dash component fuses and relays from the vehicle, it is important to carefully are located in the 12-volt electrical compartment inspect the seams and sealants for separation...
  • Page 173: Chassis Diagnostic Connectors

    SECTION 11 – MAINTENANCE AND STORAGE Towing Fuses The fuses for the chassis supplied towing package are located inside the driver side rear compartment. Diagnostic Plug (Located on steering column support beneath left side of dash) -Typical View Towing Package Fuses (Located in driver side rear compartment) -Typical View •...
  • Page 174: Coach Maintenance Chart

    SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System ...
  • Page 175 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: ...
  • Page 176 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants ...
  • Page 177: Miscellaneous

    SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motorhome’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available WARNING space when loading your motorhome.
  • Page 178 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motorhome is to weigh each “corner”...
  • Page 179: Car Or Trailer Towing

    SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual When towing a trailer or vehicle, do not set (left rear duals or right rear duals) should not exceed either the GVWR, the rear axle GAWR, exceed 6,000 lbs.
  • Page 180: Trailer Wiring Connector

    SECTION 12 – MISCELLANEOUS Finally, do not forget to consider the actual tongue weight. This should not exceed the stated NOTICE hitch vertical load for your vehicle. This weight is typically defined as the tongue weight of a towed vehicle hitch, boat trailer tongue weight, Exceeding any of the recommended or a receiver-mounted carrier rack.
  • Page 181: Fireplace

    350 items noted in GVWR above. For purposes of lbs. All Winnebago Industries models this definition, the “trailer” can be a trailer, a equipped with a Class IV hitch have a...
  • Page 182: Control Panel

    SECTION 12 – MISCELLANEOUS Remote Operation Control Panel • Flame • Heater • Power • Power • Flame • Timer • Heater • Backlight • Timer • Backlight NOTE: Holding the POWER button on the control panel for ten seconds will disable Fireplace Remote Control the heater function.
  • Page 183: Countertop Extension

    SECTION 12 – MISCELLANEOUS Indicator Panel • For high heat, turn Heat Level I and II switches ON. • LOW / HIGH INDICATORS • For temperature control, rotate Temperature Adjust dial to preferred setting. • FIRE INDICATOR • For dimming, rotate the Dimmer dial to preferred setting.
  • Page 184: Bi-Fold Door (Model 36M)

    SECTION 12 – MISCELLANEOUS Door Pull -Typical View • To retract galley countertop extension, pull release lever outward while pushing countertop extension back into stored position. NOTE: Ensure the countertop extension is in the stored position before retracting the slideout room to prevent possible property damage.
  • Page 185: Tool And Ladder Storage

    SECTION 12 – MISCELLANEOUS Stationary Extended Mode - Step Switch OFF (Step Remains Extended) With the Step power switch in the OFF position, the step will extend when the screen door is opened and will stay extended whether the door is opened or closed. NOTE: The step switch is “locked”...
  • Page 186: Roof Ladder

    SECTION 12 – MISCELLANEOUS • Be aware that the vehicle may sway as you ROOF LADDER climb the ladder. Do not use the ladder in high winds. –If Equipped • As you climb the ladder, grasp the side rails firmly and always use both hands. Keep your WARNING body centered between the side rails.
  • Page 187: Power Awning

    SECTION 12 – MISCELLANEOUS Compartment Lights Switch (Located near entrance door) -Typical View POWER AWNING Your coach is equipped with entry door and Awning Control Switches patio power awnings to provide protection (Located near entrance door) against outdoor elements, such as sun, light rain, -Typical View and wind.
  • Page 188: Stepwell Cover

    SECTION 12 – MISCELLANEOUS Power Switch • Power ON - The On position activates the CAUTION Patio Awning switch and the Auto-Retract system as well as provides power to the awning. The Auto-Retract feature provides • Power OFF - The Off position shuts down the protection against adverse elements, but no Auto-Retract system is a guarantee system.
  • Page 189: Windows

    SECTION 12 – MISCELLANEOUS Do not use the Emergency Retract feature unless necessary for an emergency. Step Cover Switch (Located on passenger side armrest) -Typical View Emergency Retract Strap (Located underneath stepwell cover) Typical View • To retract the stepwell cover for an emergency exit, pull the Emergency Retract Strap (located underneath the stepwell cover) DOWN.
  • Page 190: Power Roof Ventilator

    SECTION 12 – MISCELLANEOUS If the window will not open after three or more full turns of the knob, the glass may be stuck to the sealing gasket. Go to the outside of the coach and gently free the glass with your fingers. A periodic light dusting of talcum powder on the gasket should prevent this from recurring.
  • Page 191: Air Hose Connector

    SECTION 12 – MISCELLANEOUS 2. The turbine fan will start automatically as the vent dome is raised and stop as the vent dome WARNING is lowered and closed. (Fan Speed knob up on the ventilator frame must be in a position other than 0-Off).
  • Page 192 SECTION 12 – MISCELLANEOUS moisture can cause water stains or mildew, which can damage interior items such as upholstery and cabinets. When you recognize the signs of excessive moisture and condensation in your coach, you should take immediate action to minimize their effects.
  • Page 193 INDEX About this Manual ..........................1-1 Accent LED Light Strips (Front) ......................3-5 Air Conditioner Filters .......................... 4-14 Air Conditioner/Heater – Automotive (Dash) ..................3-16 Air Horns .............................. 3-17 Air Hose Connector ..........................12-15 Audio-Video System Basic Operation ....................8-3 Bathroom ............................
  • Page 194 Index Drainage System (P-Traps) ........................7-10 Driving Safety ............................2-1 Effects of Prolonged Occupancy ......................12-15 Electrical ..............................2-6 Electrical Cautions ..........................6-1 Electrical Generator ..........................6-7 Electrical Outlets – House 120-Volt AC ....................6-6 Electrical System – House 120-Volt AC ....................6-1 Electrical System –...
  • Page 195 Index HDMI Video Selection System ......................8-1 Headlights and Exterior Lights ......................11-5 House/Coach Battery Disconnect Switch ..................... 6-10 Hub cover .............................. 3-28 Ice Maker ..............................4-3 Ice Maker Water Filter ..........................7-5 Infotainment Center/GPS ........................3-9 Interior Soft Goods ..........................11-6 Inverter/Charger Unit –...
  • Page 196 Index Refrigerator - Residential ........................4-1 Refrigerator ............................. 4-2 Refrigerator Service Access Compartment - Residential Refrigerator ........... 4-4 Refrigerator Service Access Compartment ..................... 4-4 Refrigerator/Freezer - Portable ....................... 4-4 Reporting Safety Defects ........................1-2 Rest Easy® Multi-Position Lounge ...................... 9-14 Roadside Emergency ..........................
  • Page 197 Index Tailgate Package ............................. 4-5 Tires ..............................3-28 Toilet - Electric Flush ..........................7-9 Toilet ............................... 7-9 Tool and Ladder Storage ........................12-9 Towing Guidelines ..........................12-4 Trailer Wiring Connector ........................12-4 TV – Bedroom (Swing-Out) ........................8-6 TV (Dining Buffet) - Power Lift ......................8-6 TV Antenna - Digital ..........................

Table of Contents

Save PDF