Winnebago Journey Manual
  1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. Journey
  6. Manual

Winnebago Journey Manual

Hide thumbs Also See for Journey:
Table of Contents

Advertisement

Quick Links

See also: Basic Operation Manual , Manual
About this Manual ............................................................................................................................ 1-1
Safety Messages Used in this Manual .............................................................................................. 1-1
Owner InfoCase ................................................................................................................................ 1-2
Chassis Owner's Manual .................................................................................................................. 1-2
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ............................................................................................................... 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Vehicle Certification Label ............................................................................................................... 1-3
Body and Chassis Specifications ...................................................................................................... 1-4
Tank Capacities ................................................................................................................................. 1-5
Owner Information ........................................................................................................................... 1-6
Emergency Information .................................................................................................................... 1-6
2006 New Vehicle Limited Warranty ............................................................................................... 1-7
General Warnings ............................................................................................................................. 2-1
Driving .............................................................................................................................................. 2-1
Formaldehyde Information ............................................................................................................... 2-1
LP Gas Leak Detector ....................................................................................................................... 2-1
Carbon Monoxide Warning .............................................................................................................. 2-2
Carbon Monoxide Alarm .................................................................................................................. 2-2
Smoke Alarm .................................................................................................................................... 2-3
Fire Extinguisher ............................................................................................................................... 2-3
Emergency Exits ............................................................................................................................... 2-4
Roadside Emergency ........................................................................................................................ 2-4
Jump Starting .................................................................................................................................... 2-5
Engine Overheat ............................................................................................................................... 2-6
Effects of Prolonged Occupancy ...................................................................................................... 2-6
Seats .................................................................................................................................................. 3-1
Seat Belts .......................................................................................................................................... 3-2
Child Restraints ................................................................................................................................. 3-3
Power Door Locks ............................................................................................................................ 3-4
Power Electric Mirrors ...................................................................................................................... 3-4
Rearview Monitor System ................................................................................................................ 3-6
Electronic Compass and Outside Thermometer ............................................................................... 3-6
Power Sunvisors ............................................................................................................................... 3-7
Trip Tek Coach Computer ................................................................................................................ 3-7
Rev. 0611060911

Table of Contents

September 2006
Copyright 2006 Winnebago Industries, Inc. All rights reserved.
Part No. 132000-09-006

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Journey and is the answer not in the manual?

Questions and answers

Sam
May 12, 2025

There appear to be two coolant reservoirs in the engine compartment. What do these two systems feed and what coolant do I need to put in them.

0
1 comments:
Mr. Anderson
May 20, 2025

The two coolant reservoirs in the Winnebago Journey engine compartment feed the main engine cooling system and the rear auxiliary automotive heater and motoraid water heater. The required coolant is a nitrate-free OAT (Organic Acid Technology) mixture specific to the Cummins system. Only this type of extended-life coolant should be used to maintain the system’s long-life properties.

This answer is automatically generated

0

Related Manuals for Winnebago Journey

Summary of Contents for Winnebago Journey

  • Page 1: Table Of Contents

    Power Electric Mirrors ........................3-4 Rearview Monitor System ........................ 3-6 Electronic Compass and Outside Thermometer ................3-6 Power Sunvisors ..........................3-7 Trip Tek Coach Computer ........................ 3-7 Rev. 0611060911 September 2006 Part No. 132000-09-006 Copyright 2006 Winnebago Industries, Inc. All rights reserved.
  • Page 2 Table of Contents Vehicle Information Center ......................3-7 GPS Navigation System ........................3-8 Parking Brakes ..........................3-8 Exhaust Restriction Braking System ....................3-8 Map Light Switch ..........................3-9 Hazard Warning Lights ........................3-9 Signal Lever/Headlight Hi/Lo Beam ....................3-9 Steering Column Tilt/Telescope ..................... 3-10 SmartWheel Steering Wheel Control System .................
  • Page 3 Table of Contents Range and Oven ..........................4-2 Microwave Oven ..........................4-3 Range Hood ............................4-3 OnePlace Systems Monitor Panel ..................... 4-3 Solar Charger Panel .......................... 4-5 Powerline Energy Management System ................... 4-5 Gas/Electric Water Heater ........................ 4-6 Pressure-Temperature Relief Valve ....................4-7 Motor Aid Water Heater ........................
  • Page 4 Table of Contents PLUMBING 7 Fresh Water System .......................... 7-1 Water Pump ............................7-2 Water Purifier System ........................7-3 Disinfecting Fresh Water Systems on RV’s ..................7-4 Shower Hose Vacuum Breaker ......................7-5 Exterior Shower ..........................7-5 Toilet ..............................7-5 Waste Water System (Holding Tanks) .....................
  • Page 5 Table of Contents Underbody Cleaning ........................11-1 Exterior Finish ..........................11-2 Care of Decals ..........................11-2 Front End Masks and Paint Damage ....................11-2 Headlights and Exterior Lights ....................... 11-3 Plastic Parts - Cleaning ........................11-3 Interior Softgoods ........................... 11-4 Cabinetry ............................

  • Page 7: Introduction

    Winnebago personal injury. Industries beyond the standard written warranty as presented in this manual.

  • Page 8: Owner Infocase

    If you need warranty repairs while traveling section 1 of the Operator Manual Supple- you may take your motor home to any authorized ment for more details. Winnebago or Itasca dealership and request their assistance. CHASSIS OWNER’S MANUAL See the dealership directory in your Owner Throughout this manual, frequent reference is InfoCase.

  • Page 9: Vehicle Certification Label

    1. Chassis manufacturer. and fuel economy. 2. Chassis manufacture date. 9. Rear Axle Wheel Configuration: Single or 3. Month and year of manufacture at Winnebago Dual as it relates to the inflation. Industries. 10. Serial Number: This is the serial number 4.

  • Page 10: Body And Chassis Specifications

    SECTION 1 INTRODUCTION BODY AND CHASSIS SPECIFICATIONS Model Length (Bumper to Bumper) 32’ 9” 34’ 11” 36’ 6” 39’ 6” Interior Width 8’ 0.5” 8’ 0.5” 8’ 0.5” 8’ 0.5” Exterior Width 8’ 5.5” 8’ 5.5” 8’ 5.5” 8’ 5.5” Interior Height 6’...

  • Page 11: Tank Capacities

    SECTION 1 INTRODUCTION TANK CAPACITIES Chassis Fuel Tank Freightliner - Diesel fuel - dual fills (all models) ........90 gal. LP Gas Tank All Models .

  • Page 12: Owner Information

    Motor Home Serial Number _____________________________________________________________ Vehicle Chassis Identification Number (VIN) _______________________________________________ Vehicle Mileage at Time of Delivery ______________________________________________________ Selling Dealer Name and Address ________________________________________________________ ___________________________________________________________________________________ EMERGENCY INFORMATION YOUR WINNEBAGO INDUSTRIES DEALER Name _______________________________________________________________________________ Address _____________________________________________________________________________ ___________________________________________________________________________________ Contact Person _______________________________________________________________________ Phone ______________________________________________________________________________...

  • Page 13: 2006 New Vehicle Limited Warranty

    WARRANTY COVERAGE TO OWNER Winnebago Industries, Inc. of Forest City, Iowa warrants each new properly maintain sealants is not covered by this warranty. Winnebago Industries motor home to the owner for use in the U.S.A. and Canada as follows: WINNEBAGO INDUSTRIES’ RESPONSIBILITY...
  • Page 14 CHANGES IN DESIGN Winnebago Industries, Inc. reserves the right to make changes in design and changes or improvements upon its products without imposing any obligation upon itself to install the same upon its products theretofore manufactured.

  • Page 15: Safety & Precautions

    SECTION 2 SAFETY & PRECAUTIONS not been affected. Never operate any vehicle if GENERAL WARNINGS a difference in braking efficiency is noticeable. • Only seats equipped with seat belts are to be • Adverse weather conditions and extremes in occupied while the vehicle is moving. terrain may affect handling and/or •...

  • Page 16: Carbon Monoxide Warning

    SECTION 2 SAFETY & PRECAUTIONS CARBON MONOXIDE WARNING WARNING Avoid inhaling exhaust gases, as they contain carbon monoxide, which is a colorless, odorless and poisonous gas. LP Gas Leak Detector The best protection against carbon monoxide entry into the vehicle body is a properly maintained engine exhaust and ventilation WARNING system.

  • Page 17: Smoke Alarm

    SECTION 2 SAFETY & PRECAUTIONS Press button to test Press button to test Smoke Alarm Carbon Monoxide Alarm Further Information Further Information See the manufacturer’s information in your Owner InfoCase for further instructions on Please read the information provided by the battery replacement and testing of the smoke manufacturer, which is included in your Owner alarm.

  • Page 18: Emergency Exits

    SECTION 2 SAFETY & PRECAUTIONS WARNING WARNING This window should be kept closed while Do not test the fire extinguisher by driving to avoid drawing dangerous discharging it. Partial discharge can exhaust gases into the vehicle. cause leakage of pressure or contents which would render the unit inoperative when needed.

  • Page 19: Jump Starting

    SECTION 2 SAFETY & PRECAUTIONS Never get beneath a vehicle that is held up by Winnebago Industries does not assume a jack only. responsibility for damage incurred while towing this vehicle. If You Get A Flat Tire NOTE:Consult the chassis owner’s manual for •...

  • Page 20: Engine Overheat

    SECTION 2 SAFETY & PRECAUTIONS Ventilate with Outside Air ENGINE OVERHEAT Partially open one or more windows and a roof vent to circulate outside air through the If you see or hear steam escaping from the coach. In cold weather, this ventilation may engine compartment or have any other reason to increase use of the furnace, but it will greatly suspect an extreme engine overheating condition,...

  • Page 21: Driving Your Motor Home

    The information in this section refers only to features installed or adapted to the dash and Manual Seat Adjustments driver compartment area by Winnebago Industries. It also includes passenger seating in the living area of the coach. See your chassis owner’s manual for all original chassis related controls, instrumentation, switches and other features.

  • Page 22: Seat Belts

    SECTION 3 DRIVING YOUR MOTOR HOME To Face Driver’s Seat Rearward: Manual Seat • Tilt the steering wheel all the way up and extend the telescoping column all the way out. • Put the left armrest down. • Swivel the seat to the right until it just contacts the steering wheel, then slide the seat forward all the way.

  • Page 23: Child Restraints

    SECTION 3 DRIVING YOUR MOTOR HOME Seat Belt Care and Cleaning tongue into buckle. Adjust to a snug fit by pulling the loose end away from the tongue. • Be careful not to damage the belt webbing and To Release: Press button in center of buckle and hardware.

  • Page 24: Power Door Locks

    SECTION 3 DRIVING YOUR MOTOR HOME 4. Review the instructions for installation and use of the restraint. Be sure that you understand them fully and can install the restraint properly and safely in your vehicle. Tether Anchor Loop If your coach has a dinette, a child seat tether anchor loop is located in the floor of the coach directly behind the forward facing dinette seat.
  • Page 25 SECTION 3 DRIVING YOUR MOTOR HOME Press to move mirror in indicated direction Allen Head Set Screw* Move L or R to select mirror, *Set screws may be located on the opposite side or center for “neutral”. of the mirror arm. Passenger side mirror is simi- When mirrors are adjusted to preference, place the selector switch back in the middle position to cancel power to the buttons.

  • Page 26: Rearview Monitor System

    SECTION 3 DRIVING YOUR MOTOR HOME REARVIEW MONITOR SYSTEM The rearview camera monitor system lets you see what’s directly behind your coach for maneuvering assistance and safety. A microphone is built into the camera to let you hear warning sounds or verbal directions from an assistant.

  • Page 27: Power Sunvisors

    SECTION 3 DRIVING YOUR MOTOR HOME POWER SUNVISORS -Optional The powered sunvisors are controlled by switches on the driver and passenger armrest panels. The driver side contains switches for both sides to allow driver control. The passenger side has a switch only for the passenger side visor. Press and hold DOWN side of the switch to extend, then release at the desired position.

  • Page 28: Gps Navigation System

    SECTION 3 DRIVING YOUR MOTOR HOME PARKING BRAKES The parking brakes are applied by pulling outward on the large yellow knob on the dash to the left of the steering column. Push the knob in to release the brakes. T/Toggle: Cycles through the screens of a menu. H/Home: Takes you back to the previous menu page.

  • Page 29: Map Light Switch

    SECTION 3 DRIVING YOUR MOTOR HOME deactivate the exhaust brake system and return to chassis brakes alone. MAP LIGHT SWITCH Turn the map light on using the Panel Light brightness thumbwheel control. Roll it up towards “Cargo/Dome” until you feel it click into the map light ‘on’ position. How It Works See your chassis manual for further The exhaust brake generates “braking”...

  • Page 30: Steering Column Tilt/Telescope

    SECTION 3 DRIVING YOUR MOTOR HOME WARNING Do not adjust the steering column or tilt wheel while the vehicle is in motion. This could cause a loss of vehicle control. SMARTWHEEL STEERING Turn Signals/Hi-Lo Beams WHEEL CONTROL SYSTEM (Available With 6-Speed Move multi-function lever upward for right turn Transmission Chassis Only) signal and downward for left turn signal.

  • Page 31: Marker Light Courtesy Flash

    SECTION 3 DRIVING YOUR MOTOR HOME • This button will also perform “Coast” feature. Press and hold until vehicle slows to desired speed and release to establish new ‘set’ speed. Res (Resume/Accel) • Press to return to previous ‘set’ speed after braking or reducing speed.

  • Page 32: Idle Speed Control

    SECTION 3 DRIVING YOUR MOTOR HOME later, the windshield needs another wipe - press the button again and the delay time will be set to 7 seconds. • If the mist gets heavier and you press the button again 3 seconds after the last wipe, the delay time will be reset to 3 seconds.

  • Page 33: Aux Start Switch

    SECTION 3 DRIVING YOUR MOTOR HOME AUX START SWITCH CAUTION This switch can be used to provide emergency starting power from the motor home auxiliary Do not operate engine at low idle for long battery if the automotive battery is discharged. periods with engine coolant temperature below the minimum specification in your diesel engine manual.

  • Page 34: Aux Fan Switch

    SECTION 3 DRIVING YOUR MOTOR HOME Further Information Please refer to the radio manufacturer’s oper- ating guide in your Owner InfoCase for detailed See the manufacturer’s information in your instructions on programming preset station but- Owner InfoCase for specific operating tons and using this full-featured radio/audio sys- instructions and other information.

  • Page 35: Cb Radio

    SECTION 3 DRIVING YOUR MOTOR HOME CB Wires (in plastic sheath) Antenna SWR Adjustment To adjust CB antenna SWR (standing wave ratio), turn the adjusting ring of the antenna to Radio Power Switch achieve the lowest SWR reading. This procedure will help optimize transmitting and receiving CB RADIO capabilities of the radio system.

  • Page 36: Filling The Fuel Tank

    SECTION 3 DRIVING YOUR MOTOR HOME Winter Fuel Waxing and Anti-Gel Idling Diesel Engine Additives In sub-freezing temperatures, #2 diesel fuel CAUTION can form small wax crystals that become trapped in the fuel filter and block the fuel flow to the Do not operate engine at low idle for long engine, causing it to stall out.

  • Page 37: Engine Access Grille - Rear

    SECTION 3 DRIVING YOUR MOTOR HOME • Power Steering Reservoir • Radiator Cap • Engine Coolant Overflow Bottle • Transmission Dipstick/Fill Tube • Air Filter Restriction Indicator • Engine Diagnostic Connector • Chassis Battery Cutoff Switch • Air Manifold w/Air Hose Connector ENGINE TOP ACCESS COVERS Diesel Engine Heater Switch –...

  • Page 38: Fuel/Water Separator

    SECTION 3 DRIVING YOUR MOTOR HOME • Remove fasteners from metal engine covers and set covers aside. Models with ‘East-West’ Beds (Crosswise to Coach) • Remove the mattress from the bed and set aside in another area of the coach. •...

  • Page 39: Chassis Battery Cutoff Switch

    SECTION 3 DRIVING YOUR MOTOR HOME NOTE:Your chassis engine cooling system is Turn the knob to the positions indicated (OFF filled with special extended-life coolant or ON) to disconnect or reconnect the chassis that is not the same as common anti- batteries.

  • Page 40: Tires

    SECTION 3 DRIVING YOUR MOTOR HOME funnel may be required for filling. We recommend using commercially available SUSPENSION ALIGNMENT premixed solutions for best results. Do not use AND TIRE BALANCE water in freezing temperatures because the The front suspension and steering system of washer pump could become damaged.

  • Page 41: Loading The Vehicle

    SECTION 3 DRIVING YOUR MOTOR HOME Refer to your chassis operating guide for NOTE: We recommend that you dump all hold- further information. ing tanks before traveling to avoid carry- ing unnecessary weight. LOADING THE VEHICLE CAUTION NOTE: Your motor home’s load capacity is des- ignated by weight, not by volume, so you cannot necessarily use all available The weight of the loaded vehicle...
  • Page 42 SECTION 3 DRIVING YOUR MOTOR HOME Finding a Scale compare these weights to the gross weight ratings listed on your Vehicle Certification Label to use In urban areas, the most common places to as a guideline for future loading limits and weight find a public access scale are commercial truck distribution.

  • Page 43: Car Or Trailer Towing

    SECTION 3 DRIVING YOUR MOTOR HOME After the rear wheel set has been weighed, vehicle. See preceding items “Loading the turn the coach around and repeat this process for Vehicle” and “Weighing Your Loaded Vehicle” the other side. for explanation of weight ratings. The load on each wheel or dual-wheel set Because of individual vehicle use and loading should not exceed one-half of the corresponding...

  • Page 44: Trailer Wiring Connector

    SECTION 3 DRIVING YOUR MOTOR HOME The diagram shows proper connection of trailer or tow vehicle wiring to the coach light system. We recommend connections be made by CAUTION a qualified auto electrical technician to avoid ‘shorts’ or other malfunctions. Exceeding any of the recommended gross vehicle weight ratings may result in vehicle damage.

  • Page 45: Mountain Driving

    SECTION 3 DRIVING YOUR MOTOR HOME durability and performance of the tow vehicle drivetrain: engine cooling systems, transmission, TOOL AND LADDER STORAGE drive line, drive axle, and others. The tow vehicle The roof ladder extension and various brakes may be rated for operation at GVWR, not supplied tools are stored in clips on the walls of GCWR.

  • Page 46: Storage Compartment Doors

    SECTION 3 DRIVING YOUR MOTOR HOME • Hold the ladder extension horizontally with the support pad pointing downward and hook STORAGE COMPARTMENT the open ends of the C-shaped rung retainers DOORS onto the bottom rung of the roof ladder as The high-density gaskets used on the exterior shown in the photo.

  • Page 47: Air Hose

    SECTION 3 DRIVING YOUR MOTOR HOME Wind Sensor Auto-Retract Feature AIR HOSE If the Wind Sensor is activated, the system will automatically retract the awning when the For convenience, your coach is supplied with wind speed becomes strong enough to be a threat a 50-foot quick-connect air hose that you can use to the awning.

  • Page 49: Appliances & Systems

    SECTION 4 APPLIANCES & SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. REFRIGERATOR The refrigerator in your coach can be operated Bubble must be 1/2 inside circle from either of two power sources available to the If over 1/2 of the bubble is inside the circle in...

  • Page 50: Range And Oven

    SECTION 4 APPLIANCES & SYSTEMS To Open: RANGE AND OVEN 1. Use a screwdriver or coin to turn the latch knobs to the vertical position as shown. Optional Refrigerator Access Door Latches 2. Remove the door from the opening. To Close: 1.

  • Page 51: Microwave Oven

    SECTION 4 APPLIANCES & SYSTEMS See the manufacturer’s information in your Owner InfoCase for instructions on replacement of light bulbs and grease filter elements. WARNING Portable fuel-burning equipment ONEPLACE SYSTEMS including wood and charcoal grills and MONITOR PANEL stoves, should not be used inside the recreational vehicle.

  • Page 52: Water Pump Switch

    SECTION 4 APPLIANCES & SYSTEMS For example, if the fluid level is 1-2” below the FULL sensor, the monitor will show the level to be only 2/3 even though the tank is nearly full. If the fluid level is below the 1/3 sensor, the monitor will register an empty tank even though there may actually be some water left in the tank.

  • Page 53: Solar Charger Panel

    SECTION 4 APPLIANCES & SYSTEMS Battery Voltage Meter Push the “House Battery” button to check the level of charge (voltage) in the 12-volt coach battery. To get an accurate reading; 1. Both the chassis engine and the auxiliary generator engine must be shut off. 2.

  • Page 54: Gas/Electric Water Heater

    SECTION 4 APPLIANCES & SYSTEMS On” indicator will remain lit. If the “Pilot Out” light comes on during LP operation, it means that the burner has gone into “lockout” mode and must be restarted. If this happens, turn the Water Heater switch off for about 5 minutes, then turn it back on.

  • Page 55: Pressure-Temperature Relief Valve

    SECTION 4 APPLIANCES & SYSTEMS To Replace the Air Gap: quickly than a single source would alone. Use this mode when you are using a larger than 1. Turn off the water heater switch and incoming normal volume of hot water. water supply (city water and/or demand pump).

  • Page 56: Water Heater By-Pass Valve

    SECTION 4 APPLIANCES & SYSTEMS CAUTION CAUTION Any leak in the heat exchanger or its Leave by-pass valve handle in Normal supply or return lines could cause loss Operation position if draining water of coolant and subsequent engine and blowing out water lines. Place in failure.

  • Page 57: Electronic Thermostat

    SECTION 4 APPLIANCES & SYSTEMS Heating: alarm. If this happens, provide adequate ventilation of the smoke to avoid a nui- • Slide the thermostat switch to “Gas Heat” sance smoke alarm at this time. We do not position. recommend removing the smoke alarm NOTE:Follow proper furnace lighting proce- battery.

  • Page 58: Thermostat Operation

    SECTION 4 APPLIANCES & SYSTEMS • Adjust the temperature setpoint to personal • Slide Fan Mode switch to On. preference if needed. See “Changing • Place Fan Speed switch to Lo or Hi as desired Temperature Setpoints”. • The fan will run continuously at the selected speed and is not controlled by thermostat To Run Fan Only (No Heat or Air) setting.

  • Page 59: Central Air Conditioner

    SECTION 4 APPLIANCES & SYSTEMS does exactly the opposite. Even cold air contains “Condenser Coils”) The cooled air is forced some heat, so a heat pump will extract heat from through ducts in the ceiling of the coach. Inside the outside air on a cold day and carry it to the air returns to the air conditioner through a filter inside of the coach to maintain a comfortable system beneath the rear bed.

  • Page 60: Washer/ Dryer

    SECTION 4 APPLIANCES & SYSTEMS A/C Filter Size: 14” x 20” x 1” NOTE:Do not block the filter in any way, such as by setting packages or newspapers, etc. in front of the night stand grate. There must be free air flow for the air condi- To Open the Door During a Wash Cycle: tioner to operate efficiently.

  • Page 61: Electric Entrance Step

    SECTION 4 APPLIANCES & SYSTEMS Water Supply Faucets The washing machine water supply faucets WARNING are located inside the cabinet door above the machine. Always turn supply faucets off when not using washing machine to avoid possible Do not use step unless fully extended. water leaks if a hose or hose gasket should fail.

  • Page 62: Stepwell Cover

    SECTION 4 APPLIANCES & SYSTEMS Further Information For additional information on the step, see the CAUTION manufacturer’s operators manual included in your Owner InfoCase. Stay clear of entrance step area when stepwell is being extended or retracted. STEPWELL COVER Personal injury and/or property damage may result.

  • Page 63: Power Roof Vent

    SECTION 4 APPLIANCES & SYSTEMS Fan Speed Fuse Fan On/Off Selector Switch Vertical Slider Windows Vertical windows have spring-loaded catches on both sides of the window that pop out to hold Manual the window in its fully raised position. Press the Dome Crank catches outward toward the frames while lowering the window.

  • Page 65: Lp Gas

    SECTION 5 LP GAS LP GAS SUPPLY WARNING The LP gas system supplies fuel for the range, water heater, furnace and refrigerator (while in Do not alter or remove LP tank gauge at gas mode). When used and handled properly, this any time.

  • Page 66: Selecting Lp Fuel Types

    SECTION 5 LP GAS NOTE: If you travel outside the U.S. with your motor home, you may find butane or DAN GE R propane/butane mixtures available in addition to propane. Because gas- DO NOT FILL CONTAINER TO MORE burning RV appliances are designed to THAN 80 PERCENT OF CAPACITY.

  • Page 67: Lp Gas Leaks

    SECTION 5 LP GAS LP Gas Leaks immediately. Have the LP gas system checked by your dealer or other qualified LP gas The following label is located in the vehicle service center. near the range area. If you smell gas within the •...

  • Page 68: Pressure Regulator

    SECTION 5 LP GAS Regulators are equipped with a protective cover. Make sure that the regulator vent faces downward and that the cover is kept in place to minimize vent blockage which could result in excessive gas pressure causing fire or explosion. PRESSURE REGULATOR The pressure regulator is protected from the elements by a plastic cover which should be left...
  • Page 69 SECTION 5 LP GAS If moisture begins to cause problems, have your LP gas dealer inject a small amount of dry methyl alcohol in your tank (approximately one ounce to 20 pounds or one pint to 100 gallons) to help guard against regulator freeze-ups. In very cold weather when a large volume of gas is being used for heating, it is possible to experience a loss of gas pressure.

  • Page 71: Electrical

    SECTION 6 ELECTRICAL Your coach is equipped with an electrical volt inverter system). When the power cord is system consisting of two separate voltages; a 12- connected to an outside power source, or when volt DC system and a 110-volt AC system. The the generator is in operation, the power converter 12-volt system consists of two internal power automatically changes a portion of the 110-volt...

  • Page 72: Connecting The Power Cord

    SECTION 6 ELECTRICAL A flip down hatch in the compartment floor lets you route the power cord through a passage in the bottom of the compartment so you can WARNING shut the compartment door while the power cord is connected. Do not connect the external power cord to any receptacle until you have contacted the owner and/or attendant of...

  • Page 73: Power Center

    SECTION 6 ELECTRICAL If the coach batteries have been extremely discharged, they will accept charge at a relatively high amperage rate. If they are only slightly WARNING discharged, they will charge at a lower amperage rate. The rate of charge will decrease as the Do not plug the power cord into an outlet batteries reach “full charge”, then will continue which is not grounded, or adapt the plug...

  • Page 74: Inverter/Charger Unit - 2000W

    SECTION 6 ELECTRICAL INVERTER/CHARGER UNIT - 2000W -Optional The inverter/charger is located on the wall of the shoreline compartment. The inverter/charger has a power/reset switch and a circuit breaker to protect the inverter and the AC input source from overloads. See the manufacturer’s operating information for complete explanation and instructions on this system.

  • Page 75: 110-Volt Receptacles (Outlets)

    SECTION 6 ELECTRICAL If the GFCI keeps tripping, have the electrical system checked and repaired if necessary before using again. The GFCI outlets are located in the bath and galley areas of the vehicle. Push to Reset circuit after monthly testing or ground fault tripping.

  • Page 76: Auxiliary 110-Volt Generator

    SECTION 6 ELECTRICAL AUXILIARY 110-VOLT GENERATOR WARNING Careless handling of the generator and electrical components can be fatal. Never touch electrical leads or appliances when your hands are wet, or when standing in water or on wet ground. Generator Hourmeter Do not attempt to repair the generator yourself.

  • Page 77: 12-Volt Dc System

    SECTION 6 ELECTRICAL 4. Do not operate the generator engine while The circuitry within the device prevents back parked if vegetation, snow, buildings, feeding of electricity from the chassis to coach vehicles, or any other object can deflect the battery so if 110-volt power is interrupted, the exhaust under or into the vehicle.

  • Page 78: Battery Access

    SECTION 6 ELECTRICAL inside the battery. This condition is called ‘sulfating’ and prevents the battery from either BATTERY ACCESS releasing or accepting a charge. If this condition The batteries are located on slide-out trays in occurs, the battery must be replaced. the battery compartment on the outside of the If a battery does not contain at least 80% charge coach.

  • Page 79: 12-Volt Fuses And Circuit Breakers

    SECTION 6 ELECTRICAL • Check the state of charge periodically to avoid freezing weather, the motor home should be discharge or sulfating. driven several miles to mix water and electrolyte to prevent freezing. • To ensure that the battery will always accept and hold a charge, follow these simple •...
  • Page 80 SECTION 6 ELECTRICAL House 12-Volt Circuit Breaker Panel - typical* *Typical view of breaker panel. Actual breaker location may vary according to floorplan. Breakers are labeled on panel. 6-10...

  • Page 81: Plumbing

    SECTION 7 PLUMBING Fresh Water Tank Filling FRESH WATER SYSTEM Procedures: Always fill the fresh water tank at an approved The fresh water system provides water to the potable water filling facility or a known purified galley sink, shower, bathroom lavatory, toilet and drinking water source.

  • Page 82: Water Pump

    SECTION 7 PLUMBING City Water Use Connect hose to city water connection as described in previous steps. Turn Fresh Water valve to Normal position and turn demand water pump switches OFF. NOTE: Always keep the tank fill valve in Normal position unless you are filling the tank.

  • Page 83: Water Purifier System

    SECTION 7 PLUMBING are using water. When you open a faucet, the • Twist the inlet cap (bowl) counterclockwise to water line pressure drops and the pump begins to unscrew from the strainer assembly. run, and it will continue to run as long as the •...

  • Page 84: Disinfecting Fresh Water Systems On Rv's

    SECTION 7 PLUMBING activated carbon filter that removes chlorine and other impurities, resulting in clean, taste-free and odorless drinking water. • Insert a new water filter cartridge up into the filter head as far as possible and turn it clockwise a quarter turn. •...

  • Page 85: Shower Hose Vacuum Breaker

    SECTION 7 PLUMBING prepare the chlorine solution. One gallon of the solution should be used for each 15 gallons EXTERIOR SHOWER of tank capacity. The exterior auxiliary shower is located in the 2. Complete filling of tank with fresh water. water center compartment.

  • Page 86: Waste Water System (Holding Tanks)

    SECTION 7 PLUMBING Further Information Please refer to the toilet manufacturer’s information provided in your Owner InfoCase for operating and maintenance instructions. WASTE WATER SYSTEM (HOLDING TANKS) The drainage system is self-contained and uses two separate holding tanks to contain the waste water until it can be dumped at an appropriate waste water disposal site.
  • Page 87 SECTION 7 PLUMBING 8. It is advisable to add an odor control chemical to the sewage holding tank. These chemicals are available at most R.V. stores. NOTE: We recommend that you dump all hold- ing tanks before traveling to avoid carry- ing unnecessary weight.

  • Page 88: Utility Light

    SECTION 7 PLUMBING Using On-Site Sewer Hook-Ups The drain hose may remain attached to the dump outlet and be routed out the flipdown hatch in the bottom of the compartment while the motor home is parked and connected to an on-site sewage hook-up.
  • Page 89 SECTION 7 PLUMBING To Drain Water Lines Water Line Drain Valves in Water Center Models 34H & 36G *Models 32T and model 39K do not have these valves. Place the exterior shower head on the ground and open the shower faucets to drain the water lines on these models.

  • Page 90: Winterizing Procedure

    SECTION 7 PLUMBING 4. Remove the filter cartridge from the water filter assembly below the galley sink. Drain Plug Water Heater Service Access Water Filter Assembly below galley sink WINTERIZING PROCEDURE • Raise the valve handle on the filter base. Blow Out Procedure •...
  • Page 91 “blow-out” plug can be purchased at any 8. At this time, if your coach is equipped with an Winnebago or Itasca dealer. P/N 701705-01- optional refrigerator ice maker, dishwasher or 000.) washer/dryer, the water lines for these appliances must also be drained.
  • Page 92 SECTION 7 PLUMBING CAUTION CAUTION Limit air pressure to 30 psi to avoid Leave Bypass valve handle in ‘Normal damage to pump or water lines. Operation’ position if draining water and blowing out water lines. Place in ‘Bypass’ position ONLY when using antifreeze NOTE: DO NOT burst air into the system.
  • Page 93 SECTION 7 PLUMBING • Turn the Winterization Valve 2 to Normal. This will stop the flow from the suction tube and revert the tank line flow to the pump. • Replace the protective cap onto the end of the suction tube to keep out insects and debris when not in use.
  • Page 94 SECTION 7 PLUMBING Close dump valves to prevent valve shafts 3. Be sure the ice bin is in place and the from rusting and to prevent entry by rodents automatic shutoff arm is down. and insects. Refit the dust cap onto the drain 4.
  • Page 95 SECTION 7 PLUMBING 8. Advance the Program Selector knob to REGULAR in Cotton Heavy Duty 9. Let the machine fill until you see antifreeze in the drum 10. Advance the Program Selector knob to RESET. Wait 5 seconds (Status/Door Lock LED will blink) 11.

  • Page 96: Water System Drain Valve Locations

    SECTION 7 PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS SYSTEM DRAIN VALVE LOCATIONS Water Lines: Model 32T- One (1) valve near the water pump in a storage compartment on the right side of the coach. Model 34H- One (1) valve near the water pump in a storage compartment on the right side of the coach.

  • Page 97: Entertainment

    SECTION 8 ENTERTAINMENT • While driving - press Radio Power switch to VIDEO CONTROL CENTER ‘Engine’ position. • While parked (with key off) - press Radio The video selector system allows you to Power switch to ‘House’ position. switch the antenna, cable TV, satellite TV system •...

  • Page 98: Compact Disc Changer

    SECTION 8 ENTERTAINMENT • Press Radio Power switch (on dash) to changer operates through the dash radio using a HOUSE position. remote control unit provided in your Owner InfoCase. • Press Speaker Source Select switch to TV See the Compact Disc Changer System position to activate Surround Sound speakers.

  • Page 99: Digital Satellite Television System

    SECTION 8 ENTERTAINMENT Operation TV Signal Amplifier See the antenna manufacturer’s operation, The amplifier power switch is located on the care and maintenance information in your Owner video selection system panel in the video center InfoCase. cabinet above the driver and passenger seats or entertainment center cabinet.

  • Page 100: Portable Satellite Dish, Cable Tv And Phone Hook-Ups (Input)

    See your connected. authorized Winnebago Industries dealer for proper installation and sealing of roof mounted components.

  • Page 101: Exterior Entertainment Center

    SECTION 8 ENTERTAINMENT Exterior Input Connections for Satellite Dish, Rear Phone Jack Cable TV and Phone (in Water Center or Shoreline Compartment) EXTERIOR ENTERTAINMENT Front Phone Jack CENTER On rear facing end of the passenger sidewall armrest just behind the copilot seat. The exterior entertainment center contains a stereo radio/CD player and convenient TV hook- ups for your outside listening or viewing...

  • Page 102: Two-Way Radios

    SECTION 8 ENTERTAINMENT TWO-WAY RADIOS Optional If your coach is equipped with the available two-way radios, the built-in charger station is located in the lower face of the dash near the entrance door - for easy access as you head out the door.

  • Page 103: Furniture & Softgoods

    SECTION 9 FURNITURE & SOFTGOODS SWIVEL GLIDER LOUNGE CHAIR This chair is not equipped with a seat belt and is not intended for seating while the coach is in motion. The chair has a glide-lock mechanism to prevent chair movement while the coach is moving.

  • Page 104: Sleeping Facilities

    SECTION 9 FURNITURE & SOFTGOODS Dinette Chairs The dinette chairs are free-standing to allow greater freedom of movement than typical booth style dinettes or pedestal seats. Folding dinette chairs are also provided for additional seating when needed. The folding chairs are typically stored in the bedroom wardrobe or under the bed.

  • Page 105: Dinette/Bed Conversion

    SECTION 9 FURNITURE & SOFTGOODS DINETTE/BED CONVERSION Dinette to Bed: 1. Lift the seats and remove the seat support ‘bumpers’ to allow the seats to lie flush for use as a bed. Do not lose bumpers because you must refit them when reverting back to dinette seat configuration.

  • Page 106: Rest Easy Multi-Position Lounge

    SECTION 9 FURNITURE & SOFTGOODS Wall REST EASY MULTI-POSITION Support LOUNGE - Optional Table Bracket 2. Make sure that the table leg is secured into the floor support bracket and the leg brace is locked. CAUTION Do not recline the lounge completely flat unless the footrest section is extended.
  • Page 107 SECTION 9 FURNITURE & SOFTGOODS return to upright position, you can hook your heels over the front edge of the footrest section and pull it back with you. Then, when you want to get up, simply push the footrest section forward with your feet to provide a gap for you to exit.

  • Page 108: Sleep Number® Bed

    People are drawn to the natural beauty of and the wood is considered part of the natural wood. At Winnebago Industries, our craftsmen aging process and is not to be considered defect work with the art found in each piece of wood to or damage.
  • Page 109 SECTION 9 FURNITURE & SOFTGOODS Additionally, wood species exhibit other defining characteristics, such as mineral deposits/streaks, knots, sap runs, pin holes and wormholes. These markings make the wood unique and contribute to its enduring beauty. Therefore, since wood is a product of nature and will have certain natural characteristics and variances they are not covered under the warranty.

  • Page 111: Slideout/Leveling

    SECTION 10 SLIDEOUT/LEVELING while in PARK, raising either one or both HYDRAULIC COACH of the rear wheels off the ground could allow the vehicle to roll off the jacks. LEVELING SYSTEM Your coach is equipped with a 4-point hydraulic leveling system. This leveling system is designed to diminish problems in selecting a parking site, making “set up”...
  • Page 112 SECTION 10 SLIDEOUT/LEVELING WARNING • Do not use the coach leveling system as a lift for changing tires or working under the vehicle. • Never check for hydraulic fluid leaks using your hands and/or any other NOTE:If one of the leveling jacks should fail to body part.

  • Page 113: Slideout Room Extension

    SECTION 10 SLIDEOUT/LEVELING SLIDEOUT ROOM EXTENSION CAUTION Release slideout room travel strap before attempting to extend slideout room. Fasten travel strap before driving vehicle. See the following instructions. Your coach is equipped with slideout room extensions to enlarge your living areas at the push •...
  • Page 114 SECTION 10 SLIDEOUT/LEVELING Extending Procedure • Level the coach and set the Parking Brake. An interlock relay system will then provide power to the slideout control switches. WARNING • Release travel straps (galley). • Press the Slideout Room switch ‘OUT’ or Keep all persons clear of the slideout ‘EXTEND’...

  • Page 115: General Slideout Care

    SECTION 10 SLIDEOUT/LEVELING CAUTION Although there is an awning over the roof of the slideout room, there is a possibility of debris getting onto the roof. Because the slideout roof is drawn into the interior of the coach when retracted, be sure there is no debris, such as excessive dirt, tree seeds, twigs, leaves, etc.

  • Page 116: Slideout Room Troubleshooting

    SECTION 10 SLIDEOUT/LEVELING • See the Leveling System/Room Extension • If the batteries and fuses are okay, there may Operator’s Manual in your Owner InfoCase be a failure in the hydraulic system or for maintenance information. electrical system. Retract the room using the following emergency retract procedures and contact your dealer for service.
  • Page 117 SECTION 10 SLIDEOUT/LEVELING • Open the slideout solenoid valves (with 1/4” nuts on the ends) to relieve hydraulic line pressure. DO NOT LOOSEN NUTS MORE THAN 4 FULL TURNS. Hydraulic Pump beneath Entry Step NOTE:The hydraulic pump is equipped with two types of hydraulic solenoid valves shown.
  • Page 118 SECTION 10 SLIDEOUT/LEVELING • Crank-in bolts are located on the outboard • Crank the wrench(es) clockwise slowly, until mounting plates of the slideout room as the room is fully retracted. Allow about 10 shown. These plates are located at both ends minutes to crank room in fully.

  • Page 119: Checking Hydraulic Oil Level

    “creep out” during transit. RH Front Slideout (Galley) room See your Authorized Winnebago Industries must be OUT but all other slideout Dealer for service of the slideout system before rooms must be IN and all leveling using again.
  • Page 120 SECTION 10 SLIDEOUT/LEVELING NOTE: Prior to removing the breather cap, either to check the oil level or to use the 1/4” nut driver, clean any debris from the top of the reservoir before returning the breather cap to the reservoir. Remove any paint chips or other debris from the dip- stick including debris inside the 1/4”...

  • Page 121: Maintenance & Storage

    Have the sealant replaced if you notice any of cause damaging rust on steel parts and can add the above. Your local Winnebago Industries needless weight to the vehicle. This, in effect, dealer has the correct and necessary parts and reduces the amount of cargo you can carry and experience to help you maintain your sealants.

  • Page 122: Exterior Finish

    Recaulking, if necessary, is quite Do Not overcoat decals with clear paint. simple. Appropriate compounds are sold at Winnebago and Itasca dealers, and the materials • Do Not let gasoline or other fuels drip and stay are quickly and easily applied. Also, inspect on decals for any length of time.

  • Page 123: Headlights And Exterior Lights

    If Exterior Light Lenses there is moisture in the head lamp, the Most Winnebago Industries vehicles have head lamp manufacturer recommends polycarbonate lenses on exterior lamps, which turning on the headlights for several...

  • Page 124: Interior Softgoods

    SECTION 11 MAINTENANCE & STORAGE INTERIOR SOFTGOODS CAUTION We recommend a weekly routine of vacuuming all fabrics and carpet throughout the DO NOT use citrus based cleaners on motor home to prevent an accumulation of dirt polycarbonate finishes. which can detract from the appearance and Citric compounds will damage the high- shorten the life of carpet and fabrics.

  • Page 125: Cabinetry

    SECTION 11 MAINTENANCE & STORAGE differences in stain hue may exist between one item and another. This is the WARNING distinctive character and beauty of real wood. When cleaning upholstery and fabric, do not use lacquer thinner, nail polish VINYL WALLBOARD remover, laundry soaps, or bleach.

  • Page 126: Galley Sink

    SECTION 11 MAINTENANCE & STORAGE To remove cuts and scratches, use a more aggressive cleaning powder such as Comet, a moistened steel wool soap pad or green scouring pad. We recommend that you finish the entire surface using the same cleaning material and scrubbing method to maintain a uniform appearance.

  • Page 127: Bathroom

    SECTION 11 MAINTENANCE & STORAGE BATHROOM The tub and shower walls in the bathroom should be cleaned with a mild soap and water solution. Do not use an abrasive cleaner on the shower walls and tub. The lavatory sink is made of the same composite material as the galley sink.

  • Page 128: Removal From Storage

    SECTION 11 MAINTENANCE & STORAGE Battery switch is turned off. The inverter/ charger is directly powered and is not affected CAUTION by the Aux Battery Switch. * Parasitic battery drain is the gradual Remove all food and items that may spoil drain by items connected directly to and/or cause odors from refrigerator and battery power such as clocks, radio...

  • Page 129: Chassis Service And Maintenance

    SECTION 11 MAINTENANCE & STORAGE 6. Add a few gallons of water to the fresh water Ice Maker Start-Up tank and turn on the water pump to check for 1. Close all drain valves. leaks especially at fittings. 2. Turn the water supply on. 7.

  • Page 130: Coach Maintenance Chart

    SECTION 11 MAINTENANCE & STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. LP System Have LP system checked for leaks.

  • Page 131: Safety Equipment

    SECTION 11 MAINTENANCE & STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items Headlights, Taillights and Marker Lights Turn Signals...
  • Page 132 SECTION 11 MAINTENANCE & STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants” at beginning of this section for proper inspection technique) Replace Frame &...

  • Page 133: Recommended Sealant Application

    SECTION 11 MAINTENANCE & STORAGE RECOMMENDED SEALANT APPLICATION 11-13...
  • Page 135 Index 110-Volt AC System ........6-1 DC-AC Inverter - 600 Watt ......8-2 110-Volt Circuit Breakers ......6-4 Digital Satellite Television System ....8-3 110-Volt Receptacles (Outlets) ....6-5 Dinette/Bed Conversion ....... 9-3 12-Volt DC System ........6-7 Disinfecting Fresh Water Systems on RV’s ............
  • Page 136 Index Ground Fault Circuit Interrupter ....6-5 Recommended Sealant Application ..11-13 Hazard Warning Lights ........ 3-9 Refrigerator ..........4-1 Headlights and Exterior Lights ....11-3 Refrigerator Service Access Compartment .. 4-1 Heat Pump ..........4-10 Removal From Storage ......11-8 Hydraulic Coach Leveling System ....
  • Page 137 Index Trip Tek Coach Computer ......3-7 TV Antenna ..........8-2 Two-Way Radios ......... 8-6 Underbody Cleaning ........11-1 Utility Light ..........7-8 Vehicle Certification Label ......1-3 Vehicle Information Center ......3-7 Video Control Center ........8-1 Vinyl Wallboard ........11-5 Washer/ Dryer ..........

Table of Contents

Save PDF