Winnebago JOURNEY SE Instruction Manual
  1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. Journey SE
  6. Instruction manual
Winnebago JOURNEY SE Instruction Manual

Winnebago JOURNEY SE Instruction Manual

Hide thumbs Also See for JOURNEY SE:
Table of Contents

Advertisement

Quick Links

Download this manual
About this Manual ............................................................................................................................ 1-1
Safety Messages Used in this Manual .............................................................................................. 1-1
Owner InfoCase ................................................................................................................................ 1-2
Chassis Owner's Manual .................................................................................................................. 1-2
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ............................................................................................................... 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Vehicle Certification Label ............................................................................................................... 1-3
Body and Chassis Specifications ...................................................................................................... 1-4
Tank Capacities ................................................................................................................................. 1-5
Owner Information ........................................................................................................................... 1-6
Emergency Information .................................................................................................................... 1-6
2006 New Vehicle Limited Warranty ............................................................................................... 1-7
General Warnings ............................................................................................................................. 2-1
Driving .............................................................................................................................................. 2-1
Formaldehyde Information ............................................................................................................... 2-1
LP Gas Leak Detector ....................................................................................................................... 2-1
Carbon Monoxide Warning .............................................................................................................. 2-2
Carbon Monoxide Alarm .................................................................................................................. 2-2
Smoke Alarm .................................................................................................................................... 2-3
Fire Extinguisher ............................................................................................................................... 2-3
Emergency Exits ............................................................................................................................... 2-4
Roadside Emergency ........................................................................................................................ 2-4
Jump Starting .................................................................................................................................... 2-5
Engine Overheat ............................................................................................................................... 2-6
Effects of Prolonged Occupancy ...................................................................................................... 2-6
Seats .................................................................................................................................................. 3-1
Seat Belts .......................................................................................................................................... 3-2
Child Restraints ................................................................................................................................. 3-3
Power Door Locks ............................................................................................................................ 3-3
Power Electric Mirrors ...................................................................................................................... 3-4
Rearview Monitor System ................................................................................................................ 3-6
Rev. 0605060911

Table of Contents

September 2006
Copyright 2006 Winnebago Industries, Inc. All rights reserved.
Part No. 132000-36-006

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the JOURNEY SE and is the answer not in the manual?

Questions and answers

Related Manuals for Winnebago JOURNEY SE

Summary of Contents for Winnebago JOURNEY SE

  • Page 1: Table Of Contents

    Seats ..............................3-1 Seat Belts ............................3-2 Child Restraints ..........................3-3 Power Door Locks ..........................3-3 Power Electric Mirrors ........................3-4 Rearview Monitor System ........................ 3-6 Rev. 0605060911 September 2006 Part No. 132000-36-006 Copyright 2006 Winnebago Industries, Inc. All rights reserved.
  • Page 2 Table of Contents Electronic Compass and Outside Thermometer ................3-6 Power Sunvisors ..........................3-6 Vehicle Information Center ......................3-6 Parking Brakes ..........................3-7 Exhaust Restriction Braking System ....................3-7 Map Light Switch ..........................3-8 Hazard Warning Lights ........................3-8 Signal Lever/Headlight Hi/Lo Beam ....................3-9 Steering Column Tilt/Telescope .......................
  • Page 3 Table of Contents Range and Oven ..........................4-2 Microwave Oven ..........................4-2 Range Hood ............................4-3 OnePlace Systems Monitor Panel ..................... 4-3 Solar Charger Panel .......................... 4-5 Powerline Energy Management System ................... 4-5 Gas/Electric Water Heater ........................ 4-6 Pressure-Temperature Relief Valve ....................4-6 Motor Aid Water Heater ........................
  • Page 4 Table of Contents PLUMBING 7 Fresh Water System .......................... 7-1 Water Pump ............................7-2 Water Purifier System ........................7-3 Disinfecting Fresh Water Systems on RV’s ..................7-4 Shower Hose Vacuum Breaker ......................7-5 Exterior Shower ..........................7-5 Toilet ..............................7-5 Waste Water System (Holding Tanks) .....................
  • Page 5 Table of Contents Plastic Parts - Cleaning ........................11-3 Interior Softgoods ........................... 11-4 Cabinetry ............................11-5 Vinyl Wallboard ..........................11-5 Care and Maintenance of your Solid Surface Countertop .............. 11-5 Galley Sink ............................. 11-6 Range and Refrigerator ........................11-6 Bathroom ............................11-6 Doors and Windows ........................

  • Page 7: Introduction

    Winnebago personal injury. Industries beyond the standard written warranty as presented in this manual.

  • Page 8: Owner Infocase

    Supplement for more details. If you need warranty repairs while traveling you may take your motor home to any authorized Winnebago or Itasca dealership and request their CHASSIS OWNER’S MANUAL assistance. Throughout this manual, frequent reference is See the dealership directory in your Owner made to the vehicle chassis owner’s manual that...

  • Page 9: Vehicle Certification Label

    1. Chassis manufacturer. 10. Serial Number: This is the serial number 2. Chassis manufacture date. assigned to the completed vehicle by 3. Month and year of manufacture at Winnebago Winnebago Industries. Industries. 11. Vehicle Identification Number (VIN): This 4. Gross Vehicle Weight Rating: Total...

  • Page 10: Body And Chassis Specifications

    SECTION 1 INTRODUCTION BODY AND CHASSIS SPECIFICATIONS Model 36SG Length (Bumper to Bumper) 36’ 6” Interior Width 8’ 0.5” Exterior Width 8’ 5.5” Interior Height 6’ 8” Exterior Height * 11’ 8”* Exterior Storage (cu. ft.) 121.9 5-Speed GCWR (lbs.) 33,000 GVWR (lbs.) 27,910...

  • Page 11: Tank Capacities

    SECTION 1 INTRODUCTION TANK CAPACITIES Chassis Fuel Tank Freightliner - Diesel fuel - dual fills (all models) ........90 gal. LP Gas Tank Model 36SG .

  • Page 12: Owner Information

    Motor Home Serial Number _____________________________________________________________ Vehicle Chassis Identification Number (VIN) _______________________________________________ Vehicle Mileage at Time of Delivery ______________________________________________________ Selling Dealer Name and Address ________________________________________________________ ___________________________________________________________________________________ EMERGENCY INFORMATION YOUR WINNEBAGO INDUSTRIES DEALER Name _______________________________________________________________________________ Address _____________________________________________________________________________ ___________________________________________________________________________________ Contact Person _______________________________________________________________________ Phone ______________________________________________________________________________...

  • Page 13: 2006 New Vehicle Limited Warranty

    Winnebago Industries, Inc. of Forest City, Iowa warrants each new Winnebago Industries motor home to the owner for use in the U.S.A. and Canada as follows: WINNEBAGO INDUSTRIES’ RESPONSIBILITY...
  • Page 14 CHANGES IN DESIGN Winnebago Industries, Inc. reserves the right to make changes in design and changes or improvements upon its products without imposing any obligation upon itself to install the same upon its products theretofore manufactured.

  • Page 15: Safety & Precautions

    SECTION 2 SAFETY & PRECAUTIONS not been affected. Never operate any vehicle if a difference in braking efficiency is GENERAL WARNINGS noticeable. • Only seats equipped with seat belts are to be • Adverse weather conditions and extremes in occupied while the vehicle is moving. terrain may affect handling and/or •...

  • Page 16: Carbon Monoxide Warning

    SECTION 2 SAFETY & PRECAUTIONS CARBON MONOXIDE WARNING WARNING Avoid inhaling exhaust gases, as they contain carbon monoxide, which is a colorless, odorless and poisonous gas. LP Gas Leak Detector The best protection against carbon monoxide entry into the vehicle body is a properly maintained engine exhaust and ventilation WARNING system.

  • Page 17: Smoke Alarm

    SECTION 2 SAFETY & PRECAUTIONS Press button to test Press button to test Smoke Alarm Carbon Monoxide Alarm Further Information Further Information See the manufacturer’s information in your Owner InfoCase for further instructions on Please read the information provided by the battery replacement and testing of the smoke manufacturer, which is included in your Owner alarm.

  • Page 18: Emergency Exits

    SECTION 2 SAFETY & PRECAUTIONS WARNING WARNING This window should be kept closed while Do not test the fire extinguisher by driving to avoid drawing dangerous discharging it. Partial discharge can exhaust gases into the vehicle. cause leakage of pressure or contents which would render the unit inoperative when needed.

  • Page 19: Jump Starting

    SECTION 2 SAFETY & PRECAUTIONS Never get beneath a vehicle that is held up by Winnebago Industries does not assume a jack only. responsibility for damage incurred while towing this vehicle. If You Get A Flat Tire NOTE:Consult the chassis owner’s manual for •...

  • Page 20: Engine Overheat

    SECTION 2 SAFETY & PRECAUTIONS Ventilate with Outside Air ENGINE OVERHEAT Partially open one or more windows and a roof vent to circulate outside air through the If you see or hear steam escaping from the coach. In cold weather, this ventilation may engine compartment or have any other reason to increase use of the furnace, but it will greatly suspect an extreme engine overheating condition,...

  • Page 21: Driving Your Motor Home

    SECTION 3 DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago Industries. It also includes passenger seating in the living area of the coach.

  • Page 22: Seat Belts

    SECTION 3 DRIVING YOUR MOTOR HOME • Reverse the procedure to face the seat protection of the safety belt, never let more than forward. one person use the same safety belt at any one time, and do not let the safety belts become Power Seat damaged by pinching them in the doors or in the •...

  • Page 23: Child Restraints

    SECTION 3 DRIVING YOUR MOTOR HOME Unfastening: Press the release button in the A child restraint system is designed to be buckle. Hold onto the tongue when you release it secured in a vehicle seat by a lap belt or the lap from the buckle to keep it from retracting too belt portion of a lap-shoulder belt.

  • Page 24: Power Electric Mirrors

    SECTION 3 DRIVING YOUR MOTOR HOME NOTE:Keys should always be removed when leaving the vehicle. Since doors can be locked without keys, make sure they have been removed from the ignition before locking the coach. POWER ELECTRIC MIRRORS The electric mirrors are adjusted using a multi-directional switch located on the driver’s side armrest.
  • Page 25 SECTION 3 DRIVING YOUR MOTOR HOME The mirrors also contain heating elements to defog or de-ice the mirror glass during cold weather operation. An ON-OFF switch for the mirror heaters is located near the remote mirror controls. If you cannot adjust the mirror properly using the control switch, the mirror may need a coarse adjustment by repositioning the mirror arm and/ or rotating the mirror head.

  • Page 26: Rearview Monitor System

    SECTION 3 DRIVING YOUR MOTOR HOME ELECTRONIC COMPASS AND OUTSIDE THERMOMETER See the compass manufacturer’s guide in your Owner InfoCase for operating instructions, Mirror Arm Pivot Bolt on underside of mounting base. calibration, specifications and other information. (Shown with access plug removed.) POWER SUNVISORS REARVIEW MONITOR SYSTEM -Optional...

  • Page 27: Parking Brakes

    SECTION 3 DRIVING YOUR MOTOR HOME except that it provides additional vehicle operating conditions, performance data and diagnostic information. Parking Brake Knob Use the parking brakes whenever the vehicle is parked. Never try to drive the vehicle with the Vehicle Information Center park brake applied.

  • Page 28: Map Light Switch

    SECTION 3 DRIVING YOUR MOTOR HOME MAP LIGHT SWITCH Turn the map light on using the Panel Light brightness thumbwheel control. Roll it up towards “Cargo/Dome” until you feel it click into the map light ‘on’ position. How It Works The exhaust brake generates “braking”...

  • Page 29: Signal Lever/Headlight Hi/Lo Beam

    SECTION 3 DRIVING YOUR MOTOR HOME To Adjust Telescoping Column SIGNAL LEVER/HEADLIGHT Push the lever toward the dash. Push or pull HI/LO BEAM the steering wheel to slide the steering column in or out to the desired length. Release the lever to The signal lever controls the turn signals and lock the column into position.

  • Page 30: Auto Air Conditioner/Heater

    SECTION 3 DRIVING YOUR MOTOR HOME AUTO AIR CONDITIONER/ IN-DASH RADIO HEATER The dash radio in your coach can receive AM/FM stereo and Weather band stations. It also Controls for the air conditioner, heater, has a compact disc (CD) player for your listening defroster and vent are all combined into one enjoyment through quality high-output speakers control panel.

  • Page 31: Fuel Selection

    SECTION 3 DRIVING YOUR MOTOR HOME switch turned off for listening while parked. This Consult your chassis guide or diesel engine prevents accidental draining of the chassis (start- guide for more information on fuel requirements ing) battery with prolonged use of the radio. and additives.

  • Page 32: Engine Block Heater

    SECTION 3 DRIVING YOUR MOTOR HOME ENGINE BLOCK HEATER Your coach is equipped with an engine coolant heater to assist starting in freezing temperatures. The power cord is located in the rear cargo compartment on the driver side of the coach.

  • Page 33: Fuel/Water Separator

    SECTION 3 DRIVING YOUR MOTOR HOME • Remove the screws that fasten the wardrobe steps beside the bed, then remove the step boards and set aside. CAUTION • Lift the false floor panels from the bottom of the wardrobe and set aside. Please take precautions to protect carpet •...

  • Page 34: Engine Cooling System

    SECTION 3 DRIVING YOUR MOTOR HOME CHASSIS BATTERY CUTOFF SWITCH The battery cutoff switch disconnects chassis electrical loads from the chassis (starting) batteries to avoid discharge by direct systems such as engine computers, clock chips, sensors, etc. This feature is intended to conserve battery charge when the vehicle is not in use.

  • Page 35: Windshield Washers And Wipers

    SECTION 3 DRIVING YOUR MOTOR HOME Twist Locks to Remove Cover Automotive Fuse/Breaker (Behind “Hood” Panel) Windshield Washer Reservoir behind front “hood” panel. TIRES Improper tire pressure can result in tire overloading and abnormal wear and also affects Good Fuse Bad Fuse handling, ride characteristics and fuel economy.

  • Page 36: Lights

    SECTION 3 DRIVING YOUR MOTOR HOME your personal needs. Thereafter, the alignment • Store or secure all loose items inside the motor should be periodically inspected to help prevent home before traveling. Possible over- looked uneven tire wear. items such as canned goods or small appliances on the countertop, cooking pans on Any excessive or abnormal tire wear may the range, or free-standing furniture items can...

  • Page 37: Roof Loading

    SECTION 3 DRIVING YOUR MOTOR HOME Weighing There is typically a scale operator to direct CAUTION you but the basic routine is to take three separate weights - front axle, whole vehicle, and rear axle. You will first drive only your front wheels onto The weight of the loaded vehicle the scale pad, then drive ahead so that the whole (including options, attachments,...

  • Page 38: Car Or Trailer Towing

    SECTION 3 DRIVING YOUR MOTOR HOME rear axle weight also should not exceed the axle is 12,000 lbs., then the load on each rear dual corresponding Axle Weight Rating specified on set (left rear duals or right rear duals) should not the Vehicle Certification Label.
  • Page 39 SECTION 3 DRIVING YOUR MOTOR HOME listed Gross Weight Ratings. See “Vehicle Certification Label” in the Introduction Section for information on gross weight ratings. CAUTION Towing will affect vehicle handling, durability and fuel economy. Exceeding any of Exceeding any of the recommended the listed Gross Weight Ratings will result in gross vehicle weight ratings may result in unacceptable overall vehicle performance.

  • Page 40: Trailer Wiring Connector

    SECTION 3 DRIVING YOUR MOTOR HOME Gross Combination Weight Rating TRAILER WIRING (GCWR): CONNECTOR This is the maximum allowable weight of the motor home and loaded trailer, including the Your coach is pre-wired for trailer or car tow- items noted in GVWR above. The “trailer” can ing lights with a 7-pin socket on the rear bumper.

  • Page 41: Tool And Ladder Storage

    SECTION 3 DRIVING YOUR MOTOR HOME overheat, which could cause you to lose control • Slide the open ends of the C-shaped brackets of the vehicle. See your chassis owner’s manual over the lowest ladder rung as shown in the for specific information.

  • Page 42: Storage Compartment Doors

    SECTION 3 DRIVING YOUR MOTOR HOME When the air pressure is less than what you need to inflate an item, you must start the coach STORAGE COMPARTMENT engine to run the system air compressor to refill DOORS the tank. The high-density gaskets used on the exterior storage compartments are designed to provide a more positive seal against dust and weather.

  • Page 43: Appliances & Systems

    SECTION 4 APPLIANCES & SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. REFRIGERATOR The refrigerator in your coach can be operated Bubble must be 1/2 inside circle from either of two power sources available to the If over 1/2 of the bubble is inside the circle in...

  • Page 44: Range And Oven

    SECTION 4 APPLIANCES & SYSTEMS The range has a “Pilot Off” position on the oven control which allows the oven pilot to be turned off when traveling or refilling the LP tank. Avoiding Asphyxiation The following warning label has been located in the cooking area to remind you to provide an adequate supply of fresh air for combustion.

  • Page 45: Range Hood

    SECTION 4 APPLIANCES & SYSTEMS RANGE HOOD The range hood vent is built into the underside of the microwave oven. The range hood fan carries cooking odors and gas fumes to the outside of the coach. A light on the underside of the hood provides illumination for food preparation.
  • Page 46 SECTION 4 APPLIANCES & SYSTEMS illuminate when the pump switch is turned on. Water will be available as soon as a faucet is opened. For your convenience, a switch is also located in the water center compartment. Water Pump Switch The approximate fluid levels are measured by sets of electronic sensors (detector cells) on the sides of the tanks.

  • Page 47: Solar Charger Panel

    SECTION 4 APPLIANCES & SYSTEMS • Voltage above 13V typically indicates that the See “Battery Storage and Maintenance” battery is being charged by the inverter in this section. charger system. *The solar panel circuit breaker is located in the automotive breaker panel SOLAR CHARGER PANEL behind the front ‘hood’...

  • Page 48: Gas/Electric Water Heater

    SECTION 4 APPLIANCES & SYSTEMS For Electric Operation GAS/ELECTRIC WATER Turn on the Water Heater electric element HEATER switch. The shoreline must be connected or generator running for electric operation. (with Motor Aid water heating system) The gas/electric water heater has a dual power feature.

  • Page 49: Motor Aid Water Heater

    SECTION 4 APPLIANCES & SYSTEMS Open Lift handle straight out to open P-T valve Water Heater Exterior Service Access 4. Let the handle of the P-T valve snap shut. 5. Close the faucet and turn on the water supply Normally there is an air gap at the top of the before switching the water heater on.

  • Page 50: Water Heater By-Pass Valve

    SECTION 4 APPLIANCES & SYSTEMS 5. After about 30 seconds, the furnace burner will light. WATER HEATER BY-PASS 6. The furnace will now cycle off and on VALVE automatically as the thermostat demands just Your coach is equipped with a water heater like a household furnace.
  • Page 51 SECTION 4 APPLIANCES & SYSTEMS seconds after you release the temperature selector Temperature Selector button, the display will return to showing the current room temperature. Cooling (A/C): • Slide the thermostat switch to Cool position. • Slide the Fan Mode and Fan Speed Switches to the desired positions.

  • Page 52: Thermostat Operation

    SECTION 4 APPLIANCES & SYSTEMS THERMOSTAT OPERATION The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard references to heat functions when using the “Cool Only” thermostat in the rear bedroom. NOTE: The thermostat is equipped with a replaceable 2 Amp fuse located on the back of the thermostat body.

  • Page 53: Central Air Conditioner

    SECTION 4 APPLIANCES & SYSTEMS To Operate the Heat Pump: *The air filter is a disposable woven fiberglass type, which cannot be cleaned See the air conditioning/heat pump and should be replaced when coated with manufacturer’s information in you Owner dust.

  • Page 54: Electric Entrance Step

    SECTION 4 APPLIANCES & SYSTEMS This position is normally used to keep the step extended when parked at a campsite or whenever ELECTRIC ENTRANCE STEP people will be entering and exiting the vehicle The power switch for the electric entrance step frequently.

  • Page 55: Windows

    SECTION 4 APPLIANCES & SYSTEMS and gently free the glass with your fingers. A periodic light dusting of talcum powder on the gasket should prevent this from recurring. Horizontal Slider Windows Swing the latch handle straight out from the window. Grasp the sliding window edge frame and slide the window to the side.
  • Page 56 SECTION 4 APPLIANCES & SYSTEMS Fan Speed Fuse Fan On/Off Selector Switch Manual Dome Crank Power Roof Vent Galley or Bath Further Information See the power vent manufacturer’s operating instructions supplied in your Owner InfoCase. 4-14...

  • Page 57: Lp Gas

    SECTION 5 LP GAS LP GAS SUPPLY WARNING The LP gas system supplies fuel for the range, water heater, furnace and refrigerator (while in Do not alter or remove LP tank gauge at gas mode). When used and handled properly, this any time.

  • Page 58: Safe Use Of The Lp Gas System

    SECTION 5 LP GAS NOTE: If you travel outside the U.S. with your motor home, you may find butane or DAN GE R propane/butane mixtures available in addition to propane. Because gas- DO NOT FILL CONTAINER TO MORE burning RV appliances are designed to THAN 80 PERCENT OF CAPACITY.

  • Page 59: Lp Gas Warnings And Precautions

    SECTION 5 LP GAS LP Gas Leaks immediately. Have the LP gas system checked by your dealer or other qualified LP gas The following label is located in the vehicle service center. near the range area. If you smell gas within the •...

  • Page 60: Pressure Regulator

    SECTION 5 LP GAS Regulators are equipped with a protective cover. Make sure that the regulator vent faces downward and that the cover is kept in place to minimize vent blockage which could result in excessive gas pressure causing fire or explosion. PRESSURE REGULATOR The pressure regulator is protected from the elements by a plastic cover which should be left...
  • Page 61 SECTION 5 LP GAS If moisture begins to cause problems, have your LP gas dealer inject a small amount of dry methyl alcohol in your tank (approximately one ounce to 20 pounds or one pint to 100 gallons) to help guard against regulator freeze-ups. In very cold weather when a large volume of gas is being used for heating, it is possible to experience a loss of gas pressure.

  • Page 63: Electrical

    SECTION 6 ELECTRICAL Your coach is equipped with an electrical automatically changes a portion of the 110-volt system consisting of two separate voltages; a 12- current to 12-volt DC current. All equipment in volt DC system and a 110-volt AC system. The the motor home that is normally powered by the 12-volt system consists of two internal power auxiliary battery is then powered through the...
  • Page 64 SECTION 6 ELECTRICAL in the bottom of the compartment so you can shut the compartment door while the power cord is connected. WARNING Do not connect the external power cord to any receptacle until you have contacted the owner and/or attendant of the premises to verify proper polarity and grounding.

  • Page 65: Power Center

    SECTION 6 ELECTRICAL If the coach batteries have been extremely discharged, they will accept charge at a relatively high amperage rate. If they are only slightly WARNING discharged, they will charge at a lower amperage rate. The rate of charge will decrease as the Do not plug the power cord into an outlet batteries reach “full charge”, then will continue which is not grounded, or adapt the plug...

  • Page 66: Inverter/Charger Unit - 2000W

    SECTION 6 ELECTRICAL INVERTER/CHARGER UNIT - 2000W -Optional The inverter/charger is located on the wall of the shoreline compartment. The inverter/charger has a power/reset switch and a circuit breaker to protect the inverter and the AC input source from overloads. See the manufacturer’s operating information for complete explanation and instructions on this system.

  • Page 67: 110-Volt Receptacles (Outlets)

    SECTION 6 ELECTRICAL If the GFCI keeps tripping, have the electrical system checked and repaired if necessary before using again. The GFCI outlets are located in the bath and galley areas of the vehicle. Push to Reset circuit after monthly testing or ground fault tripping.

  • Page 68: Auxiliary 110-Volt Generator

    SECTION 6 ELECTRICAL AUXILIARY 110-VOLT GENERATOR WARNING Careless handling of the generator and electrical components can be fatal. Never touch electrical leads or appliances when your hands are wet, or when standing in water or on wet ground. Do not attempt to repair the generator Generator Hourmeter yourself.

  • Page 69: 12-Volt Dc System

    SECTION 6 ELECTRICAL Check auxiliary generator oil level frequently tank gauges, 110-volt generator starter, during periods of use. refrigerator and bath roof vent fan. The house battery may also be used to start the engine if the Refer to the generator manufacturer’s automotive battery is discharged.

  • Page 70: Battery Care

    SECTION 6 ELECTRICAL 1. Turn off the Auxiliary Battery switch to avoid parasitic discharge (the trickle discharge caused by directly connected components like LP gas detectors or digital clock displays, etc.), and 2. Check the battery and recharge as necessary at least once a month during long storage periods.

  • Page 71: 12-Volt Fuses And Circuit Breakers

    SECTION 6 ELECTRICAL • Neutralize corrosion buildup or acid film on top of battery by washing with a baking soda/ water solution. Rinse with clear water. WARNING NOTE:Make sure vent caps are on securely to prevent baking soda solution from To prevent wiring damage, it is essential entering the battery and contaminating when replacing the cables on the battery,...
  • Page 72 SECTION 6 ELECTRICAL House 12-Volt Circuit Breaker Panel - typical* *Typical view of breaker panel. Actual breaker location may vary according to floorplan. Breakers are labeled on panel. 6-10...

  • Page 73: Plumbing

    SECTION 7 PLUMBING The gravity fill is located behind a small, lockable door on the sidewall toward the back of FRESH WATER SYSTEM the coach. The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet and water heater.

  • Page 74: Water Pump

    SECTION 7 PLUMBING faucets and toilet. A check valve built into the pump prevents water from entering the pump and filling the storage tank. NOTE: Because city water pressure varies from location to location, we recommend using an in-line water pressure regulator to prevent damage to any components, connections and seals in your fresh water system.

  • Page 75: Water Purifier System

    SECTION 7 PLUMBING Pump Strainer the pump switch be turned off whenever you are away from the vehicle or not using the water The pump is equipped with a cleanable system. A slow leak in a faucet could drain the strainer to capture any possible tank borne water system and discharge the coach battery.

  • Page 76: Disinfecting Fresh Water Systems On Rv's

    SECTION 7 PLUMBING DISINFECTING FRESH WATER SYSTEMS ON RV’S (As approved by the U.S. Public Health Service) To assure complete disinfection of your fresh water system, it is recommended that the following procedure be followed on a new system, one that has not been used for a period of time, or one that may have become contaminated.

  • Page 77: Shower Hose Vacuum Breaker

    SECTION 7 PLUMBING SHOWER HOSE VACUUM TOILET BREAKER The toilet in your motor home is very similar to the household type, except that it is designed to After using the shower, you may notice water use only a small amount of water per flush. It dripping from the shower faucet assembly.
  • Page 78 SECTION 7 PLUMBING solids while dumping or to provide more dump valve before the hose valve, the direct drainage while using on-site hose will fill with sewage water and be sewer hook-ups. difficult to move or could cause the hose to clog.
  • Page 79 SECTION 7 PLUMBING 7. Rinse end of sewer hose thoroughly with water and stow. 4. Turn the water on to begin flushing; allow water to run for about three minutes. NOTE:If the hose will not collapse while storing, open the hose end valve (handle) to 5.

  • Page 80: Utility Light

    SECTION 7 PLUMBING with the liquids when the dump valve is opened. If the valve is left open, the liquids will drain off, leaving solids in the tank. Should this accidentally happen, disconnect the hose, fill the tank about half full with water, and drive a few miles to dislodge the solids.

  • Page 81: Winterizing Procedure

    SECTION 7 PLUMBING See the following photos and descriptions for locations of the drain valves. Drain Plug Water Heater Water Line Drain Valve in RH Service Access Exterior Water Pump Compartment WINTERIZING PROCEDURE Blow Out Procedure 1. Level the motor home and drain the entire plumbing system as described in the following steps.
  • Page 82 SECTION 7 PLUMBING filter assembly below the galley sink. Water Filter Assembly below galley sink • Push the diverter up into the head as far as possible and turn it clockwise approximately • Raise the valve handle on the filter base. 90°...
  • Page 83 “blow-out” plug can be purchased at any convenience in winterizing fresh water lines. Winnebago or Itasca dealer. P/N 701705-01- The system features a diverter valve with 000.) suction tube to draw non-toxic RV water system antifreeze into the water lines.
  • Page 84 SECTION 7 PLUMBING CAUTION Leave Bypass valve handle in ‘Normal Operation’ position if draining water and blowing out water lines. Place in ‘Bypass’ position ONLY when using antifreeze solution in water lines. WARNING RV Antifreeze Draw Tube NEVER use automotive antifreeze/ in water center or near water pump coolant in your RV water system.
  • Page 85 SECTION 7 PLUMBING • Replace the protective cap onto the end of the bowl. Strainer is shown previously in this suction tube to keep out insects and debris section. when not in use. Your drainage and fresh water systems are Dump and Clean Holding Tanks now totally winterized.

  • Page 86: Water System Drain Valve Locations

    SECTION 7 PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS SYSTEM DRAIN VALVE LOCATIONS Water Lines: One (1) valve near the water pump in a storage compartment on the right side of the coach. Two (2) valves in the bottom of the water center compartment.

  • Page 87: Entertainment

    SECTION 8 ENTERTAINMENT • While parked (with key off) - press Radio Power switch to ‘House’ position. VIDEO CONTROL CENTER • Turn Radio On and adjust volume. The video selector system allows you to switch the antenna, cable TV, satellite TV system FRONT TV IGNITION SWITCH or VCR/DVD signal to any TV set location in the coach.

  • Page 88: Dc-Ac Inverter - 600 Watt

    SECTION 8 ENTERTAINMENT • Press TV/Video button on remote or front of video player to select “Video1” input shown on channel display area of TV screen. • The inverter must be switched on to operate. • Turn the inverter off when not in use to avoid draining the coach.

  • Page 89: Portable Satellite Dish, Cable Tv And Phone Hook-Ups (Input)

    SECTION 8 ENTERTAINMENT Check Antenna Light To check the antenna amplifier, raise the antenna, select a TV channel and rotate the The check antenna light will come on for 20 antenna for best picture. Then turn off the seconds when the ignition switch is turned on to amplifier power switch.
  • Page 90 Hookup jacks are located in the left or right front overhead compartment, depending on model. See your authorized Winnebago Industries dealer for proper installation and sealing of roof mounted components. Interior Connection for Satellite Dishes...

  • Page 91: Furniture & Softgoods

    SECTION 9 FURNITURE & SOFTGOODS WARNING Be sure all loose items are secured or stored properly while the vehicle is in motion. Possible overlooked items such as canned goods or small appliances on the countertop, cooking pans on the range, or free-standing furniture items can become dangerous projectiles during a sudden stop.

  • Page 92: Sleeping Facilities

    SECTION 9 FURNITURE & SOFTGOODS SLEEPING FACILITIES WARNING Do not use sleeping facilities while vehicle is moving. DINETTE/BED CONVERSION Dinette to Bed: 3. Remove the table from the wall support 1. Lift the seats and remove the seat support bracket by lifting the end of the table. Then ‘bumpers’...

  • Page 93: Rest Easy Multi-Position Lounge

    SECTION 9 FURNITURE & SOFTGOODS Wall REST EASY MULTI-POSITION Support LOUNGE - Optional Table Bracket 2. Make sure that the table leg is secured into the floor support bracket and the leg brace is locked. CAUTION Do not recline the lounge completely flat unless the footrest section is extended.
  • Page 94 SECTION 9 FURNITURE & SOFTGOODS return to upright position, you can hook your heels over the front edge of the footrest section and pull it back with you. Then, when you want to get up, simply push the footrest section forward with your feet to provide a gap for you to exit.

  • Page 95: Nighter Pleated Blinds

    People are drawn to the natural beauty of Any color change that occurs in both the finish wood. At Winnebago Industries, our craftsmen and the wood is considered part of the natural work with the art found in each piece of wood to...

  • Page 97: Slideout Rooms

    SECTION 10 SLIDEOUT ROOMS SLIDEOUT ROOM EXTENSION CAUTION Release slideout room travel strap before attempting to extend slideout room. Fasten travel strap before driving vehicle. See the following instructions. Your coach is equipped with slideout room • Pull a short length of the excess strap back extensions to enlarge your living areas at the push through the buckle to provide sufficient slack.
  • Page 98 SECTION 10 SLIDEOUT ROOMS Extending Procedure • Level the coach and set the Parking Brake. An interlock relay system will then provide power to the slideout control switches. WARNING • Release travel straps (galley). • Press the Slideout Room switch ‘OUT’ or Keep all persons clear of the slideout ‘EXTEND’...

  • Page 99: Slideout Room Troubleshooting

    SECTION 10 SLIDEOUT ROOMS 4. If the slideout room has a couch or other compartments which could be crushed or furniture, make sure no people or pets are cause damage to floor covering or cabinets seated on them until the room has been fully when the room is retracted.

  • Page 100: Slideout Room Emergency Retraction Procedures

    SECTION 10 SLIDEOUT ROOMS SLIDEOUT ROOM WARNING EMERGENCY RETRACTION PROCEDURES Stop engine, place transmission in neutral position and apply parking brake Front Slideout Rooms before lying beneath vehicle for this Emergency Crank-In Procedure procedure. (If slideout room will not retract using control switch) Step 1 - Relieve Hydraulic Line Pressure •...
  • Page 101 SECTION 10 SLIDEOUT ROOMS NOTE:The hydraulic pump is equipped with two types of hydraulic solenoid valves shown. The leveling jack solenoids have a T- handle on the valve shaft that can be turned by hand. The slideout room solenoid has a small 1/4” nut at the end of the valve shaft that requires you to use a 1/4”...
  • Page 102 SECTION 10 SLIDEOUT ROOMS • Loosen the locking screws at the crank-in bolt shafts as shown before trying to turn the bolts. CAUTION Retract Bolt The Retract Bolts must be ‘backed out’ to their original positions immediately after the crank-in procedure to avoid damaging the retract bolts and slideout mechanism the next time the room is extended.

  • Page 103: Checking Hydraulic Oil Level

    The oil level should be between the two marks on the breather See your Authorized Winnebago Industries cap dipstick shown in the following illustration. Dealer for service of the slideout system before using again.
  • Page 104 SECTION 10 SLIDEOUT ROOMS NOTE: Prior to removing the breather cap, either to check the oil level or to use the 1/4” nut driver, clean any debris from the top of the reservoir before returning the breather cap to the reservoir. Remove any paint chips or other debris from the dipstick including debris inside the 1/4”...

  • Page 105: Maintenance & Storage

    Have the sealant replaced if you notice any of Corrosive materials, such as those used for ice and snow removal and dust control, also the above. Your local Winnebago Industries dealer has the correct and necessary parts and accumulate on the underside of a vehicle. These experience to help you maintain your sealants.

  • Page 106: Exterior Finish

    Appropriate compounds are sold at • Do Not let gasoline or other fuels drip and stay Winnebago and Itasca dealers, and the materials on decals for any length of time. Rinse are quickly and easily applied. Also, inspect immediately.

  • Page 107: Headlights And Exterior Lights

    Exterior Light Lenses head lamp manufacturer recommends turning on the headlights for several Most Winnebago Industries vehicles have hours or as necessary to evaporate and polycarbonate lenses on exterior lamps, which vent the moisture.

  • Page 108: Interior Softgoods

    SECTION 11 MAINTENANCE & STORAGE Fabric Upholstery The following products, compounds or solvents Some fabrics used in this motor home may must be wiped off immediately to avoid contain fire retardant and fade resistant additives damage: which can be damaged by use of improper •...

  • Page 109: Cabinetry

    SECTION 11 MAINTENANCE & STORAGE General Stains If a stain has dried on, allow the cleaner or soapy water time to soften the area, after which As with any stain or contamination, the quick the stain will wipe off. response is the best, especially when done in If the stain is not water-base or oil-base conjunction with the proper cleaner for the type material, you may need to gently remove it using...

  • Page 110: Galley Sink

    SECTION 11 MAINTENANCE & STORAGE replacement. If one of these materials does spill Marks or Discoloration. White automotive or drip onto the counter surface, wipe it up rubbing compound may be used to remove immediately to avoid damage. stubborn marks or discoloration. Use of these products will not damage the solid surface.

  • Page 111: Nighter Blinds

    SECTION 11 MAINTENANCE & STORAGE NIGHTER BLINDS PREPARING VEHICLE FOR STORAGE Tension Adjustment: Properly preparing your vehicle for storage The tension of the pleated blinds can be will lessen the possibility of damage to your adjusted if they become loose and will not stay up vehicle.

  • Page 112: Removal From Storage

    SECTION 11 MAINTENANCE & STORAGE following regular battery inspection and 3. Check window operation. maintenance, especially in cold weather. 4. Check cabinet and door hinges. Lubricate See “Battery Storage and Maintenance”. with penetrating oil, if necessary. 6. After charging batteries, turn the Aux Battery 5.

  • Page 113: Chassis Service And Maintenance

    SECTION 11 MAINTENANCE & STORAGE Also inspect weather seals around doors, etc., and if necessary, have a dealer replace immediately. CHASSIS SERVICE AND MAINTENANCE Consult the appropriate sections in your chassis operating guide for specific information regarding operating safety, service recommendations and maintenance schedules for the chassis section of your motor home.

  • Page 114: Coach Maintenance Chart

    SECTION 11 MAINTENANCE & STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. LP System Have LP system checked for leaks.
  • Page 115 SECTION 11 MAINTENANCE & STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items Headlights, Taillights and Marker Lights Turn Signals...
  • Page 116 SECTION 11 MAINTENANCE & STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect Replace Frame &...

  • Page 117: Recommended Sealant Application

    SECTION 11 MAINTENANCE & STORAGE RECOMMENDED SEALANT APPLICATION 11-13...
  • Page 119 Index 110-Volt AC System ........6-1 Driving ............2-1 110-Volt Circuit Breakers ......6-4 DVD/VCR Combo Player and Home Theater Surround Sound ........8-1 110-Volt Receptacles (Outlets) ....6-5 Effects of Prolonged Occupancy ....2-6 12-Volt DC System ........6-7 Electric Entrance Step ........
  • Page 120 Index Inverter/Charger Unit - 2000W ....6-4 Roadside Emergency ........2-4 Jump Starting ..........2-5 Roof ............11-1 Lights ............3-16 Roof Loading ..........3-17 Loading the Vehicle ........3-16 Safe Use of the LP Gas System ....5-2 LP Gas Furnace ..........4-8 Safety Messages Used in this Manual ..
  • Page 121 Index Water Pump ..........7-2 Water Purifier System ........7-3 Water System Drain Valve Locations ..7-14 Weighing Your Loaded Vehicle ....3-17 Windows ............ 4-13 Windshield Washers and Wipers ....3-15 Winterizing Procedure ......... 7-9 Wood Furniture and Cabinetry ....9-5...

Table of Contents