Final Gear Oil; Brakes - Suzuki UF50 Service Manual

2-8 PERIODIC MAINTENANCE

FINAL GEAR OIL

Inspect initially at 1 000 km (2 months) and every
6 000 km (12 months) thereafter.
Remove the final gear oil level bolt 1 and inspect the oil level.
If the oil level is below the brim of the final gear oil level hole,
add oil until it runs out from the level hole.
Final gear oil viscosity and classification: SAE 10W-40
Tighten the final gear oil level bolt 1 to the specified torque.
Final gear oil level bolt: 12 N·m (1.2 kgf-m)

BRAKES

Inspect initially at 1 000 km (2 months) and every
3 000 km (6 months) thereafter.
REAR BRAKE LEVER PLAY
Turn the adjusting nut 1 until the rear brake lever play A is
within specification.
Rear brake lever play A: 15 – 25 mm
REAR BRAKE SHOE WEAR
This motorcycle is equipped with a brake lining wear limit indi-
cator 1 on the brake cam lever.
To check brake lining wear, perform the following steps.
Make sure that the rear brake lever play is properly adjusted.
Squeeze the rear brake lever. Make sure that the indicator 1
is within the range A embossed on the crankcase.
If the indicator goes beyond the range, the brake shoe as-
sembly should be replaced with a new set of shoes. (
5-30)
FRONT BRAKE PADS
( 5-11)
1
1
A
1
A