Refilling Tank; Air In The Lp Gas Tank; Traveling With Lp Gas; Regulator - Winnebago Sunflyer Manual

REFILLING LP TANK
There are many LP gas refueling stations lo-
cated throughout the country. These stations are
listed in the telephone directory Yellow Pages
under "Gas - Liquified Petroleum - Bottled and
Bulk."
Since the LP tank is permanently mounted to
the frame, the motor home must be taken to an LP
dealership for filling. Do not attempt to remove
the LP tank from the vehicle. The tank is
equipped with a fill adapter with both internal
and external threads which allows easy filling
with any LP filling equipment. The tank is full
when liquid LP gas appears at the overflow
valve.
NOTE: The LP tank is equipped with an auto-
matic 80% stop-fill device.
WARNING
Make sure the filling attendant uses
the 80% overflow valve when filling
the tank. A tank should never be filled
above 80% level to allow for vapor-
ization and liquid expansion.
Do not place LP gas containers inside
the vehicle. LP gas containers are
equipped with safety devices which
relieve excessive pressure by dis-
charging gas to the atmosphere.
Do not place LP gas containers, gaso-
line, or other flammable liquids
inside the vehicle. Fire or explosion
may result.

AIR IN THE LP GAS TANK

If your LP gas appliances do not stay lit or re-
quire frequent adjustment, even though you
know the LP tank contains sufficient fuel, the
problem may be air in the LP gas tank. Air in the
tank mixes with the LP gas vapors causing them
to burn poorly. This condition could linger for
weeks if the air is not purged from the tank. Most
LP gas dealers have equipment for purging air
from LP gas tanks and will purge before refilling
the tank.
LP GAS SYSTEM
TRAVEL WITH LP GAS
It is illegal for vehicles equipped with LP
tanks to travel on certain roadways or through
certain tunnels in the U.S. To avoid inconve-
nience, check state regulations concerning flam-
mable gas transportation.
WARNING
Do not alter or remove LP tank gauge
at any time.
WARNING
DO NOT FILL CONTAINER TO
MORE THAN 80 PERCENT OF CA-
PACITY. Make sure the motor home
is level when filling. It is possible to
accidentally overfill the tank if the ve-
hicle is unlevel, with the fill valve on
the uphill side. Overfilling the LP gas
tank can result in uncontrolled gas
flow, which can cause fire or explo-
sion. A properly filled container will
contain approximately 80 percent of
its volume as liquid LP gas.
All pilot lights must be extinguished
and supply valve closed before refill-
ing LP gas tanks or vehicle fuel tanks.
Do not smoke or expose an open
flame while near an LP refueling area.
LP gas is heavier-than-air and ex-
tremely flammable.
Never use an open flame to test for
LP gas leaks.
Replace all protective covers and caps
on LP system before filling.
Never fill the LP tank with engine or
generator running.

REGULATOR

The pressure regulator is protected from the
elements by a plastic cover which should be left
SECTION 5
5-3