Winnebago suncruiser Owner's Manual
  1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. Suncruiser
  6. Owner's manual
Winnebago suncruiser Owner's Manual

Winnebago suncruiser Owner's Manual

Hide thumbs Also See for suncruiser:
Table of Contents

Advertisement

Quick Links

Download this manual See also: Basic Operation Manual, Owner's Manual
About this Manual ............................................................................................................................ 1-1
Safety Messages Used in this Manual .............................................................................................. 1-1
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ............................................................................................................... 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Specifications and Capacities ........................................................................................................... 1-4
Owner Information ........................................................................................................................... 1-6
Emergency Information .................................................................................................................... 1-6
2007 New Vehicle Limited Warranty ............................................................................................... 1-7
General Warnings ............................................................................................................................. 2-1
Driving Safety ................................................................................................................................... 2-1
Propane Gas Leak Detector .............................................................................................................. 2-1
Carbon Monoxide Warning .............................................................................................................. 2-2
Carbon Monoxide Alarm .................................................................................................................. 2-2
Smoke Alarm .................................................................................................................................... 2-3
Fire Extinguisher ............................................................................................................................... 2-3
Emergency Exits ............................................................................................................................... 2-4
Formaldehyde Information ............................................................................................................... 2-5
Mold, Moisture and Your Motor Home ............................................................................................ 2-5
Roadside Emergency ........................................................................................................................ 2-6
Jump Starting .................................................................................................................................... 2-7
Engine Overheat ............................................................................................................................... 2-7
Seats .................................................................................................................................................. 3-1
Seat Belts .......................................................................................................................................... 3-2
Child Restraints ................................................................................................................................. 3-3
Key One Lock System ...................................................................................................................... 3-4
Power Electric Mirrors ...................................................................................................................... 3-4
Rearview Monitor System ................................................................................................................ 3-5
Power Sunvisors ............................................................................................................................... 3-5
Brake-Shift Interlock ........................................................................................................................ 3-6
Foot-Pedal Parking Brakes ............................................................................................................... 3-6
Automatic/Pull-Button Parking Brakes ............................................................................................ 3-6
Grade Brake ...................................................................................................................................... 3-6
Fuel Pump Shut-Off Switch .............................................................................................................. 3-7
Over-Drive Switch ............................................................................................................................ 3-7
Tow/Haul Transmission Mode ......................................................................................................... 3-8
Rev. 0715090608

TABLE OF CONTENTS

Copyright 2006 Winnebago Industries, Inc. All rights reserved.
June 2009
Part No. 132000-15-007

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the suncruiser and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Winnebago suncruiser

Summary of Contents for Winnebago suncruiser

  • Page 1: Table Of Contents

    Foot-Pedal Parking Brakes ....................... 3-6 Automatic/Pull-Button Parking Brakes .................... 3-6 Grade Brake ............................3-6 Fuel Pump Shut-Off Switch ......................3-7 Over-Drive Switch ..........................3-7 Tow/Haul Transmission Mode ......................3-8 Rev. 0715090608 June 2009 Part No. 132000-15-007 Copyright 2006 Winnebago Industries, Inc. All rights reserved.
  • Page 2 Table of Contents Hazard Warning Flashers ........................3-8 Map Light Switch ..........................3-8 Battery Boost Switch ........................3-8 Auto Air Conditioner/Heater ......................3-8 Rear Coach Heater ..........................3-9 Defrost Fans ............................3-9 In-Dash Radio ........................... 3-9 CB Radio Power Wiring ......................... 3-10 Engine Access ..........................
  • Page 3 Table of Contents 120-Volt AC System ......................... 6-1 External Power Cord ......................... 6-1 Power Center ............................. 6-3 120-Volt Circuit Breakers ......................... 6-3 120-Volt Receptacles (Outlets) ......................6-4 Ground Fault Circuit Interrupter ....................... 6-4 Electrical Generator .......................... 6-5 12-Volt DC System ........................... 6-6 Auxiliary Battery Disconnect Switch ....................
  • Page 4 Table of Contents Dinette/Bed Conversion ........................9-2 Rest Easy Multi-Position Lounge ..................... 9-4 Sleep Number® Bed ......................... 9-6 Day/Nighter Pleated Blinds ......................9-6 Wood Furniture and Cabinetry ......................9-6 SLIDEOUT / LEVELING 10 Slideout Room Operation – Hydraulic ................... 10-1 Slideout Room –...
  • Page 5 Table of Contents Tool and Ladder Storage ......................... 12-6 Roof Ladder ............................ 12-6 Storage Compartment Doors ......................12-7 Power Awning ..........................12-7 Windows ............................12-8 Power Roof Vent ..........................12-8 Effects of Prolonged Occupancy ....................12-9...

  • Page 7: Introduction

    DANGER indicates a directly hazardous are intended as a guide, and in no way situation which, if not avoided, will result extend the responsibilities of Winnebago in death or serious personal injury. Industries beyond the standard written warranty as presented in this manual.

  • Page 8: Pre-Delivery Inspection

    CAUTION indicates a potentially you may take your motor home to any authorized hazardous situation which, if not avoided, Winnebago or Itasca dealership and request their could result in damage mainly to assistance. equipment or property, but in some cases...

  • Page 9: Vehicle Certification Label

    2. Chassis manufacture date. 9. Rear Axle Wheel Configuration: Single or 3. Month and year of manufacture at Winnebago Dual as it relates to the inflation. Industries. 10. Serial Number: This is the serial number 4.

  • Page 10: Specifications And Capacities

    SECTION 1 INTRODUCTION SPECIFICATIONS AND CAPACITIES Model Length 33' 8" 35' 11" 36' 0” 38' 1" 38' 10" 38' 11" 33' 8" 35' 11" 36' 0” 35' 11" 36' 0” Exterior Height 12' 2" 12' 2" 12' 2" 12' 1" 12' 0"...
  • Page 11 SECTION 1 INTRODUCTION Specifications and Capacities Notes: Ford Chassis 6.8L Super-Duty V10 SOHC Triton engine, 362-hp, TorqShift , 5-speed overdrive ® ® ™ transmission, 130-amp. alternator, 4-wheel ABS, Tires 22.5", Wheels stylized aluminum Workhorse Chassis 8.1L Vortec V8, 340-hp, Allison 1000 Series 6-speed electronic overdrive ™...

  • Page 12: Owner Information

    Motor Home Serial Number ____________________________________________________________ Vehicle Chassis Identification Number (VIN) _______________________________________________ Vehicle Mileage at Time of Delivery______________________________________________________ Selling Dealer Name and Address_______________________________________________________ __________________________________________________________________________________ EMERGENCY INFORMATION YOUR WINNEBAGO INDUSTRIES DEALER Name _____________________________________________________________________________ Address ___________________________________________________________________________ __________________________________________________________________________________ Contact Person _____________________________________________________________________ Phone ____________________________________________________________________________ CHASSIS DEALER/SERVICE CENTER...

  • Page 13: 2007 New Vehicle Limited Warranty

    Structural defects of the subfloor, floor, and slide-out room Winnebago does not authorize any person to create for it any other assembly. Floor lamination failure and lamination failure of the obligations or liability in connection with this vehicle.
  • Page 14 If you are touring or have moved, contact any unresolved warranty disputes for recreational vehicles. This dispute Winnebago Industries motor home dealer in the United States or resolution program reviews eligible product and service related Canada for warranty service.

  • Page 15: Safety/Precautions

    SECTION 2 SAFETY/PRECAUTIONS • Driving through water deep enough to wet the GENERAL WARNINGS brakes may affect stopping distance or cause the vehicle to pull to one side. Check brake • Only seats equipped with seat belts are to be operation in a safe area to be sure they have occupied while the vehicle is moving.

  • Page 16: Carbon Monoxide Warning

    SECTION 2 SAFETY/PRECAUTIONS CARBON MONOXIDE WARNING WARNING Never use an open flame to test for gas leaks. When testing for gas line leaks with WARNING a soapy water solution, DO NOT use a detergent containing ammonia or Avoid inhaling exhaust gases, as they chlorine.

  • Page 17: Smoke Alarm

    RV application. We recommend obtaining a replacement from Your motor home is equipped with a smoke your Winnebago Industries dealer. alarm located on the ceiling in the lounge area. The smoke alarm is powered by a 9-volt battery FIRE EXTINGUISHER and has a sensor that is designed to detect smoke.

  • Page 18: Emergency Exits

    This window will be type and size, or larger, as the one originally marked EXIT and have a red handled latch. supplied in your coach. We recommend obtaining a replacement only from your Winnebago Industries dealer or a reliable RV parts supplier.

  • Page 19: Formaldehyde Information

    SECTION 2 SAFETY/PRECAUTIONS MOLD, MOISTURE AND YOUR MOTOR HOME What is Mold? Molds are part of the natural environment. They are as old as the Earth itself. And mold spores are almost everywhere at some level waiting to grow. Mold plays a part of nature by breaking down dead organic matter such a fallen leaves and dead trees.

  • Page 20: Roadside Emergency

    DO NOT jerk your foot off the accelerator. If Winnebago Industries determines that mold Just ease back on the accelerator slowly and is present in the Winnebago/Itasca motor home gently to continue momentum. The deflated as a result of a manufacturing defect reported to tire will slow the vehicle.

  • Page 21: Jump Starting

    We recommend that you ask for an underlift (wheel lift or frame lift) type towing assembly for WARNING safe towing. Winnebago Industries does not assume responsibility for damage incurred while towing Do not attempt to push start this vehicle. this vehicle.

  • Page 23: Driving Your Motor Home

    SECTION 3 DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago Industries. It also includes passenger seating in the living area of the coach.

  • Page 24: Seat Belts

    SECTION 3 DRIVING YOUR MOTOR HOME Lap Belts • Swivel the seat the rest of the way to face the living area. The lap belts must be worn as low as possible • Tilt the steering wheel down. and fit snugly across the hip area. Always sit erect and well back into the seat.

  • Page 25: Child Restraints

    SECTION 3 DRIVING YOUR MOTOR HOME • Inspect the belts and hardware periodically. Check for cuts, frays, and loose parts. WARNING Damaged parts should be replaced. Do not remove or modify the belt system. Snug and low belt positions are essential. •...

  • Page 26: Key One Lock System

    If your coach has a dinette, it may be equipped keys, any Winnebago Industries dealership can with a child seat tether anchor loop located on the order a new key for you.

  • Page 27: Rearview Monitor System

    SECTION 3 DRIVING YOUR MOTOR HOME Mirror Arm/Head Adjustment The monitor screen ‘wakes up’ automatically when transmission is shifted into Reverse. A If you cannot adjust a mirror properly using microphone built into the rear camera lets you the control switch, the mirror may need a coarse hear warning sounds or verbal directions from an adjustment by rotating the mirror head.

  • Page 28: Brake-Shift Interlock

    SECTION 3 DRIVING YOUR MOTOR HOME NOTE: Do not position visors where they will AUTOMATIC/PULL-BUTTON impair the driver’s forward vision or side PARKING BRAKES mirror view. (24,000 Lbs GVWR Workhorse Chassis) This chassis is equipped with parking brakes that apply automatically when the transmission is shifted into Park.

  • Page 29: Fuel Pump Shut-Off Switch

    SECTION 3 DRIVING YOUR MOTOR HOME See your chassis manual for location and reset procedures for this switch. NOTE: It is possible to accidentally trigger the fuel pump shut-off switch by abruptly striking an object such as a curb or parking block.

  • Page 30: Tow/Haul Transmission Mode

    SECTION 3 DRIVING YOUR MOTOR HOME TOW/HAUL TRANSMISSION MODE Roll panel light (Ford Chassis only) dimmer wheel upward fully to This mode locks out Overdrive and helps turn driver side reduce gear ‘hunting’ by the automatic map light on. transmission while towing. It also improves power delivery and uses engine braking to help control vehicle speed when descending hills.

  • Page 31: Rear Coach Heater

    SECTION 3 DRIVING YOUR MOTOR HOME Fan Switch Mode Selector Temp Control Further Information Please read the information provided by the manufacturer, which is included in your IN-DASH RADIO InfoCase. The radio in your coach can receive AM/FM NOTE:The dash air conditioner is not designed stereo and Weather band stations.

  • Page 32: Cb Radio Power Wiring

    SECTION 3 DRIVING YOUR MOTOR HOME Radio Remote Controls A steering wheel mounted remote control for the radio lets you change radio stations or CD selections without taking your eyes off the road or hands off the wheel. See the radio owner’s guide in your InfoCase for remote control instructions.
  • Page 33 SECTION 3 DRIVING YOUR MOTOR HOME the same time toward the hood panel to release Transmission the latches. Then pull the hood panel outward Engine Coolant Engine Oil Fill Fluid Dipstick Reservoir slightly and raise it into the open position. Windshield Washer Engine Oil Hood Latch Locations...

  • Page 34: Engine Cooling System

    SECTION 3 DRIVING YOUR MOTOR HOME NOTE: There may also be screws to remove at Refer to your chassis manual for information the lower front corners. and precautions on filling, servicing and checking the fluid level. • Lift the rear end of the cover upward and slide rearward, then pull the cover from the TIRES opening.

  • Page 35: Lights

    SECTION 3 DRIVING YOUR MOTOR HOME Out-of-balance tires will not roll smoothly and can lead to vibrations and uneven tread wear such as cupping and flat spots. Tires may need to be balanced if uneven wear is detected or if ride comfort decreases noticeably.
  • Page 36 SECTION 3 DRIVING YOUR MOTOR HOME CAUTION Observe the engine temperature gauge more frequently than normal. If overheating occurs, pull off to the side of the road and allow the engine to thoroughly cool before refilling the radiator and restarting the engine. Descending A Hill When going down a long grade, you may need to manually shift to a lower gear rather than...

  • Page 37: Appliances & Systems

    SECTION 4 APPLIANCES & SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. REFRIGERATOR The refrigerator in your coach can operate Bubble must be at least 1/2 inside circle from either of two energy sources available to the Normal vehicle leveling to provide comfort...

  • Page 38: Ice Maker

    SECTION 4 APPLIANCES & SYSTEMS To Open: operate on 120-VAC household current if the shoreline is connected or the auxiliary 1. Use a screwdriver or coin to turn the latch generator is running. knobs to the vertical position as shown. AU (Automatic Mode) - Refrigerator will automatically start operating on 120-VAC household current if the shoreline is...

  • Page 39: Microwave Oven/Range Hood

    SECTION 4 APPLIANCES & SYSTEMS Unlike homes, the amount of oxygen supply is To Light Range Top Burners limited due to the size of the recreational vehicle, • Turn the desired burner knob to HI LITE position • Immediately spin the IGNITOR knob clockwise and proper ventilation when using the cooking at least one full turn to light the burner appliances avoids dangers of asphyxiation.

  • Page 40: One Place Systems Monitor Panel

    SECTION 4 APPLIANCES & SYSTEMS provides illumination for food preparation. The At the touch of a button this panel can display hood fan and light switches are located on the the fresh water and holding tank levels, propane microwave control panel. gas tank level, plus the battery and house battery condition.

  • Page 41: Tank Capacities

    SECTION 4 APPLIANCES & SYSTEMS Water Level Sensors Water Pump Switch Battery Voltage Meter Water Tank Press the “House Battery” switch position to check the level of charge (voltage) in the 12-volt For example, if the fluid level is 1-2” below house batteries.

  • Page 42: Solar Charger Panel

    SECTION 4 APPLIANCES & SYSTEMS electrical loads as necessary to avoid nuisance SOLAR CHARGER PANEL tripping of the shoreline circuit breaker. This –If Equipped system works together with the energy efficient central air conditioner to allow both compressors The 10-watt roof-mounted solar charger panel to operate at the same time on a 30-amp shoreline uses the sun to help keep your house batteries connection.

  • Page 43: Water Heater - Gas

    SECTION 4 APPLIANCES & SYSTEMS Water Supply Faucets The washing machine water supply faucets are located inside the cabinet door above the machine. Always turn supply faucets off when not using washing machine to avoid possible water leaks if a hose or hose gasket should fail. To Open the Door During a Wash Cycle: Follow these steps if you need to open the door to your washer-dryer after a cycle has...

  • Page 44: Water Heater - Gas/ Electric

    SECTION 4 APPLIANCES & SYSTEMS For Propane Gas Operation Press the Water Heater switch on the Monitor Panel. The “Pilot Out” light will glow for about 10-15 seconds, then it will go out. The “Heater On” indicator will remain lit. If the “Pilot Out” light comes on during gas operation, it means that the burner has gone into “lockout”...

  • Page 45: Pressure-Temperature Relief Valve

    SECTION 4 APPLIANCES & SYSTEMS For Quick Recovery Operation (Dual Heating) CAUTION Turn On both Water Heater switches; the gas one on the monitor panel and the electric one. This will help reheat the water heater tank more Operate this valve only when the water quickly than a single source would alone.

  • Page 46: Motor Aid Water Heater

    SECTION 4 APPLIANCES & SYSTEMS MOTOR AID WATER HEATER –If Equipped The motor aid uses heat from the chassis engine cooling system to heat water in the water heater while driving. Hoses are routed from the engine to a heat exchanger surrounding the water heater tank.

  • Page 47: Electronic Thermostat

    SECTION 4 APPLIANCES & SYSTEMS Heating: and periodic maintenance. See the Coach Maintenance Schedule for recommended • Slide the thermostat switch to “Gas Heat” intervals. position. NOTE: If the furnace burner has any residuals NOTE:Follow proper furnace lighting of metal protectant or lubricants used procedures described previously in this during manufacture of the furnace, it may section.
  • Page 48 SECTION 4 APPLIANCES & SYSTEMS • Adjust the temperature setpoint to personal preference if needed. See “Changing Temperature Setpoints”. To Run Fan Only (No Heat or Air) • Set Thermostat switch to OFF. • Slide Fan Mode switch to On. •...

  • Page 49: Furnace-A/C Thermostat Operation Chart

    SECTION 4 APPLIANCES & SYSTEMS FURNACE-A/C THERMOSTAT OPERATION CHART The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard references to heat functions when using the “Cool Only” thermostat in the rear bedroom. A heat pump can be thought of as an air HEAT PUMP conditioner running in reverse.

  • Page 50: Central Air Conditioner

    SECTION 4 APPLIANCES & SYSTEMS The efficiency of a heat pump decreases as the CENTRAL AIR CONDITIONER outdoor air temperature drops, so supplementary heat is often needed when the outside NOTE:See “Electronic Thermostat” for temperature nears freezing. This system is set to instructions on turning the air automatically start the gas furnace to assist the conditioner on and changing the...
  • Page 51 SECTION 4 APPLIANCES & SYSTEMS Beneath Bed Raise mattress board and lift out filter access panel. A finger hole is provided for panel removal. A/C Filter Size: 14” x 20” x 1” NOTE: Do not block the filter in any way, such as by setting packages or newspapers, etc.

  • Page 53: Propane Gas

    SECTION 5 PROPANE GAS PROPANE GAS SUPPLY WARNING The propane gas system supplies fuel for the gas range/oven, water heater, furnace and refrigerator (while in gas mode). When used and Do not alter or remove propane tank handled properly, this system is safe and gauge at any time.

  • Page 54: Safe Use Of The Propane Gas System

    SECTION 5 PROPANE GAS phone directory yellow pages for locations of local propane gas refilling stations or bulk DAN GE R dealerships. NOTE: If you travel outside the U.S. with your DO NOT FILL CONTAINER TO MORE motor home, you may find butane or THAN 80 PERCENT OF CAPACITY.

  • Page 55: Propane Gas Warnings And Precautions

    SECTION 5 PROPANE GAS • Exercise caution at all times. Be familiar with PROPANE GAS WARNINGS the distinctive odor of propane gas. If a leak is AND PRECAUTIONS suspected, turn off the supply valve immediately. Have the propane gas system It is illegal for vehicles equipped with propane checked by your dealer or other qualified tanks to travel on certain roadways or through...

  • Page 56: Propane Gas Pressure Regulator

    SECTION 5 PROPANE GAS NOTE:If your model is equipped with a propane powered electrical generator, there will be two regulators stacked one upon another. One regulates the house propane supply pressure; the other regulates pressure to the generator. • Never use an open flame to test for propane gas leaks.

  • Page 57: Propane Vaporization In Cold Weather

    SECTION 5 PROPANE GAS tank and bottle manufacturers and propane gas dealers take every precaution to reduce moisture, but sometimes only a fraction of an ounce entering the tank can cause problems. To help avoid the possibility of freeze-up, always keep tank control valve closed when not in use, even when tank is empty, to prevent moisture from collecting on the inside.

  • Page 59: Electrical

    SECTION 6 ELECTRICAL Your coach is equipped with an electrical portion of the 120-volt current to 12-volt DC system consisting of two separate voltages: current. All equipment in the motor home that is normally powered by the house batteries is then •...

  • Page 60: Connecting The Power Cord

    SECTION 6 ELECTRICAL Connecting The Power Cord To connect to an external source, remove the cord from the utility compartment and plug it into a suitable 50-amp power receptacle to provide external power to the coach and converter/ charger system. NOTE: Some parks do not have 50-amp service available, so you will need to connect to a standard 30-amp service pole using an...

  • Page 61: Power Center

    SECTION 6 ELECTRICAL Park Fuses or Breakers Charging Section Most campgrounds are equipped with a fuse The converter charges house batteries while or circuit breaker at the receptacle. This protects 120-volt external power is connected. The the park’s wiring, as well as the power cord on converter will automatically “sense”...

  • Page 62: 120-Volt Receptacles (Outlets)

    SECTION 6 ELECTRICAL Shut off the equipment (example: roof air shock if a ground fault develops. If such a conditioner) and allow a brief cooling period. condition occurs, the GFCI will break the circuit Then reset the breaker by moving the switch to by turning off the power to the protected outlets.

  • Page 63: Electrical Generator

    SECTION 6 ELECTRICAL To Stop the Generator ELECTRICAL GENERATOR Press and Hold the Generator switch in STOP –If Equipped position until you hear the generator come to a full stop, then release. See the generator manufacturer’s information WARNING provided in your InfoCase for detailed operating instructions, troubleshooting and maintenance.

  • Page 64: 12-Volt Dc System

    SECTION 6 ELECTRICAL House Batteries 1. Do not simultaneously operate the generator engine and a ventilator which could draw The house batteries supply power to 12-volt exhaust gases into the vehicle. equipment located in the living area of the motor 2.

  • Page 65: House Battery Access

    SECTION 6 ELECTRICAL WARNING Always refasten the battery retainer when returning a battery to the compartment. BATTERY CARE Lead -acid type batteries are electro-chemical Aux. Batt. Switch - typical devices for storing and releasing electrical (Near entrance door) charge. As such, they are simply an electrical reservoir, not an electrical source.
  • Page 66 SECTION 6 ELECTRICAL WARNING WARNING California Proposition 65 Warning: Before removing any battery cables or Battery posts, terminals and related battery, make sure all 12-volt equipment accessories contain lead and lead com- in the motor home is off and the power pounds, chemicals known to the state of cord has been disconnected.

  • Page 67: 12-Volt House Circuit Breakers

    SECTION 6 ELECTRICAL House Breaker Panel The House 12-Volt Breaker Panel is located WARNING behind the small cabinet door near the galley or below the refrigerator. To prevent wiring damage, it is essential when replacing the cables on the battery, or when using a “booster”...

  • Page 69: Plumbing

    SECTION 7 PLUMBING FRESH WATER SYSTEM The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet and water heater. Water may be supplied by either of two sources: • a fresh water tank and water pump located within the motor home, or •...

  • Page 70: Utility Light

    SECTION 7 PLUMBING 2. Turn Fresh Water Valve to Normal position These devices simply connect in-line between and turn the water pump switches OFF. the supply hose and the city water input on the coach. Water pressure regulators are commonly available at any well stocked RV dealership and many large retail discount or home supply centers.
  • Page 71 SECTION 7 PLUMBING Pump Strainer Water Pump Switch The pump is equipped with a cleanable The water pump switch is located on the strainer to capture any possible tank borne systems monitor panel. (Some models may have particles that could damage pump components. an additional switch in the water service center.) While the switch is “ON”, the pump will NOTE: We recommend that you check and clean...

  • Page 72: Filtered Water Faucet

    SECTION 7 PLUMBING Water Pump Access Panel (typical) Water Filter Assembly (Located below Galley Sink) * Typical View - your coach may vary Replacing the Water Filter Cartridge Replace the filter cartridge when water flow from the faucet is too slow for convenience. •...

  • Page 73: Central Water Filtration System

    SECTION 7 PLUMBING • See Winterization Procedure at the end of this section. Also see filter manufacturer’s information in your InfoCase for further instructions or precautions. • When removing the coach from storage, always disinfect and flush the water system thoroughly before installing a new filter.

  • Page 74: Disinfecting Your Fresh Water System

    SECTION 7 PLUMBING See also “Winterizing Procedure” in this 100 ppm chlorine concentration should be section to prepare the water filtration system for allowed to stand in the system for at least 1 freezing conditions. See your dealer for hour.) replacement cartridges and O-rings.

  • Page 75: Shower Hose Vacuum Breaker

    SECTION 7 PLUMBING low level of chlorine in the tank at all times. The chlorine is then removed from drinking water by the Filtered Water Faucet. Add 1 teaspoon of chlorine bleach (sodium hypochlorite) to your tank for each 10 gallons of tank capacity.

  • Page 76: Waste Water System

    SECTION 7 PLUMBING See winterizing instructions at the end of this 2. Open the hose end valve (handle) and place section to prepare the toilet for storage in freezing the head of the sewer hose into the disposal conditions. opening. Push the handle forward to open the valve inside the hose head Further Information See the toilet manufacturer’s operation...
  • Page 77 SECTION 7 PLUMBING into gray tank. Gray water also rinses NOTE:If the hose will not collapse while storing, any black water solids from the drain open the hose end valve (handle) to hose. release air trapped inside the hose. 8. It is advisable to add an odor control chemical to the sewage holding tank.

  • Page 78: Water Line & Tank Drain Valves

    SECTION 7 PLUMBING Using On-Site Sewer Hook-Ups The drain hose may remain attached to the dump outlet and be routed out the flip-down hatch in the bottom of the compartment while the motor home is parked and connected to an on-site sewage hook-up.

  • Page 79: Water Heater Bypass Winterization Valve

    SECTION 7 PLUMBING WINTERIZING PROCEDURES You can winterize the water and plumbing system of your coach using one of the following two methods – 1) Blow out waterlines using compressed air or – 2) Fill waterlines with RV Drain water system antifreeze. Plug Method 1 –...
  • Page 80 30 psi or less to force air through refrigerator ice maker, dishwasher, or washer/ the system. A blow-out plug can be purchased dryer, the waterlines for these appliances must ® ® at any Winnebago or Itasca dealer. also be drained. 7-12...
  • Page 81 SECTION 7 PLUMBING NOTE: It is not necessary to add antifreeze to the toilet since the flush valve will be closed. City Water Connection Do not add automotive antifreeze or caustic chemicals such as bleach or laundry detergents into the toilet bowl or holding tanks.
  • Page 82 SECTION 7 PLUMBING Follow directions on the container to determine the correct amount to use for your coach. Your coach is equipped with a manually operated waterline winterization system for your convenience in winterizing fresh waterlines. The system features a diverter valve with siphon tube to draw non-toxic RV water system antifreeze into the waterlines.
  • Page 83 SECTION 7 PLUMBING See Water System Drain Valve chart at the end RV Antifreeze Siphon Tube of this section for location on your coach (Located in water center or near water pump) - Insert into container of RV water system antifreeze 4.
  • Page 84 SECTION 7 PLUMBING 15. Pour about one cup of RV antifreeze down each drain for the galley sink, lavatory sink, and shower/tub. This fills the drain trap pipes to prevent holding tank odors from entering the coach during storage. Dump and Clean Holding Tanks 16.

  • Page 85: Water System Drain Valve Locations

    SECTION 7 PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS System Drain Valve Locations Water Line Drain Valves: Valves in the utility compartment on the passenger side of the coach, behind the main entrance door or right front slideout. Open exterior shower faucet and lay shower head on ground. Also, to drain any water left in the city water line, place the tip of your finger inside the city water connection and gently press the backflow valve (small “button”...

  • Page 87: Entertainment

    SECTION 8 ENTERTAINMENT To Watch VCR (if self-installed) VIDEO SELECTION SYSTEM • Press VCR button on MAIN TV section of –If Equipped Video Selection System panel. To Watch Rear/Bedroom TV (if equipped) • Video selection for the rear TV is similar to front TV viewing except all selections are made with buttons in the TV2 grouping.

  • Page 88: Dvd Home Theater System

    SECTION 8 ENTERTAINMENT • The DVD may load directly to the DVD HOME THEATER SYSTEM main title/menu screen or it may begin –If Equipped to play previews. You may be able to skip previews if desired by pressing the ‘Next’ button until you see the main menu screen.

  • Page 89: Compact Disc Changer

    SECTION 8 ENTERTAINMENT • Press the Speaker selector ELECTRICAL INVERTER switch on the dash to RADIO 600-Watt DC-to-AC position to connect the radio to the theater sound speakers. –If Equipped Volume is adjusted with radio The inverter changes 12-volt DC current into buttons or radio remote.

  • Page 90: Tv Signal Amplifier

    SECTION 8 ENTERTAINMENT Lowering Antenna to Travel Position TV ANTENNA Rotate antenna until pointer on directional The TV antenna on your motor home can be handle aligns with pointer on ceiling plate. easily raised, rotated a full 360° and lowered from inside the vehicle by simply turning a crank or directional handle.

  • Page 91: Tv Cable, Satellite And Phone Hook-Ups

    SECTION 8 ENTERTAINMENT Checking Amplifier Performance TV DIGITAL SATELLITE The TV signals available to an RV are entirely SYSTEM – MANUAL dependent on its location in relation to the –If Equipped transmitter (tower). Signals may vary from strong to no usable signal at all. We recommend The Digital Satellite Television System that the TV system be checked out in an area allows you to receive TV programs directly from...

  • Page 92: Tv Digital Satellite System - Automatic

    SECTION 8 ENTERTAINMENT TV DIGITAL SATELLITE TV DIGITAL SATELLITE SYSTEM – AUTOMATIC SYSTEM – IN-MOTION –If Equipped –If Equipped The Automatic Digital Satellite Television The dome antenna switch must be on to power System allows you to receive TV programs the in-motion satellite TV dish.
  • Page 93 SECTION 8 ENTERTAINMENT Entertainment Center...

  • Page 95: Furniture & Softgoods

    SECTION 9 FURNITURE & SOFTGOODS LOUNGE CHAIR HOOP BASE CAUTION The hoop base of the lounge chair is fastened to the floor with a clamp as shown. The chair must be clamped back into place and the glide mechanism locked before traveling.

  • Page 96: Sleeping Facilities

    SECTION 9 FURNITURE & SOFTGOODS WARNING Be sure all free-standing chairs and furniture items, and all other loose items are secured or stored properly while the vehicle is in motion. Possible overlooked items such as canned goods or small appliances on the countertop, cooking pans on the range can also become dangerous projectiles during a sudden •...
  • Page 97 SECTION 9 FURNITURE & SOFTGOODS 2. Release the catch on the table leg brace and fold the leg up against the bottom of the table. Bed to Dinette: 3. Remove the table from the wall support 1. Reattach the table onto the wall support and bracket by lifting the end of the table.

  • Page 98: Rest Easy Multi-Position Lounge

    SECTION 9 FURNITURE & SOFTGOODS To Recline Press the switch on the front of the armrest. Press ‘down’ to recline; ‘up’ to return upright. NOTE: Be sure house batteries contain adequate charge. If the batteries are partially discharged, the sofa may not fully recline or return to the upright position.
  • Page 99 SECTION 9 FURNITURE & SOFTGOODS To Convert to Bed Extend footrest section and push together with lounge seat cushion, then press recline button until entire lounge lies flat. Reverse steps to return to lounge seating. The gap between the footrest and seat provides ample room to enter and exit the lounge.

  • Page 100: Sleep Number® Bed

    –If Equipped –If Equipped People are drawn to the natural beauty of wood. At Winnebago Industries, our craftsmen work with the art found in each piece of wood to create cabinets of superior quality, backed by the Winnebago Industries warranty.
  • Page 101 SECTION 9 FURNITURE & SOFTGOODS light. Color differences or changes in wood can also be caused by exposure to harsh chemicals, extreme heat or other contributing external conditions. Any color change that occurs in both the finish and the wood is considered part of the natural aging process and is not to be considered defect or damage.

  • Page 103: Slideout / Leveling

    SECTION 10 SLIDEOUT / LEVELING SLIDEOUT ROOM OPERATION – HYDRAULIC Your coach is equipped with slideout room extensions to enlarge your living area at the push of a button. The slideout room extends and retracts by a hydraulic mechanism with an electronic control system.
  • Page 104 SECTION 10 SLIDEOUT / LEVELING WARNING CAUTION Keep all persons clear of the slideout Holding a control switch in the “extend” or room and moving parts while extending or “retract” position for a time period longer retracting. Do not occupy the slideout than necessary to fully extend or retract room while it is being extended or the hydraulic cylinders, can cause...

  • Page 105: Slideout Room - Extreme Weather Precaution

    SECTION 10 SLIDEOUT / LEVELING • Start the engine so the alternator can provide maximum power for proper operation of CAUTION slideout mechanisms. • Set the Parking Brake. An interlock relay system will then provide power to the slideout Although there is an awning over the roof control switches.

  • Page 106: Slideout Room Troubleshooting - Hydraulic

    SECTION 10 SLIDEOUT / LEVELING Also, freezing rain and snow can prevent the slideout awning-cover (if equipped) from closing and may cause damage to the awning-cover, slideout room, weather seals and mechanisms. To avoid potential damage, we recommend retracting your slideout room(s) during extreme weather conditions.
  • Page 107 SECTION 10 SLIDEOUT / LEVELING Hydraulic Pump Access - open storage compartment door behind driver’s side front tire. Use 1/4” nut driver built into end of pump reservoir cap to open slideout solenoid valves. WARNING NOTE:Always clean away any dirt and debris from the top of the reservoir before Stop engine, place transmission in park removing the breather cap to avoid entry...
  • Page 108 SECTION 10 SLIDEOUT / LEVELING • After loosening the lock screws, fit the ratchet wrench onto the bolt head and begin cranking clockwise slowly a few turns, then alternate to the other side for a few turns. Have an assistant use an additional wrench, then crank both sides evenly together to speed this process.

  • Page 109: Checking Hydraulic Oil Level

    “creep Bedroom Slideout Rooms - out” during transit. Emergency Push-In Procedure See your Authorized Winnebago Industries In the unlikely event that your bedroom Dealer for service of the slideout system before slideout fails to retract using the power switch, using again.

  • Page 110: General Slideout Care

    SECTION 10 SLIDEOUT / LEVELING Checking Dipstick: • Clean the floors inside before retracting the room to avoid vinyl flooring scratches or The hydraulic oil level is checked with a carpet pile snags. dipstick built into the breather/filler cap on top of the oil reservoir, which is part of the hydraulic •...

  • Page 111: Leveling System

    SECTION 10 SLIDEOUT / LEVELING LEVELING SYSTEM WARNING –If Equipped The 4-point hydraulic leveling system is designed to minimize problems in selecting a • Do not use the coach leveling system ‘level’ parking site, making setup easier and as a lift for changing tires or working faster for you.
  • Page 112 SECTION 10 SLIDEOUT / LEVELING Jacks Down Light The “Jacks Down” reminder is intended to WARNING warn you to retract your leveling jacks before moving the vehicle. The light will come on briefly and a chime will sound when the ignition Keep all people clear of the coach while key is turned to the On or Run positions if the the leveling system is operating.
  • Page 113 SECTION 10 SLIDEOUT / LEVELING Turn T-handle out about six turns Leveling Jack Solenoid Valve In The Event Of Accidental Jack Extension 1. Bring the vehicle to a safe and complete stop as soon as possible. 2. Turn the leveling systems power switch on and press the ‘all up’...

  • Page 115: Maintenance/Storage

    • Have the sealant replaced if you notice any of reduces the amount of cargo you can carry and the above. Your local Winnebago Industries remain within GVWR and GAWR limits. dealer has the correct and necessary parts and Corrosive materials, such as those used for ice experience to help you maintain your sealants.

  • Page 116: Exterior Automotive Paint Finish

    SECTION 11 MAINTENANCE/STORAGE Driving EXTERIOR AUTOMOTIVE • Avoid driving on gravel roads. PAINT FINISH • Rinse off bugs and bird droppings with water –If Equipped daily. The body of your coach is fully or partially • Antifreeze, fuel, or windshield/window finished with the highest quality automotive solutions spilled on the painted surface should paint and clearcoat.

  • Page 117: Care Of Appliques And Decals

    SECTION 11 MAINTENANCE/STORAGE auto stores offer car wash detailing soaps that • If this does not work, as a last resort, use a bug are similar and do not have bleach in the removal product (like SEAFOAM Bugs-B- formulation (such as Meguiars #62). Gone or equivalent) in a shady area and follow the directions on label.

  • Page 118: Front End Masks And Paint Damage

    SECTION 11 MAINTENANCE/STORAGE • Never use aromatic solvents such as acetone, MEK, toluene, xylene, lacquer thinner, etc., on appliques or decals. Any solvent including CAUTION alcohol may soften or smear colors. • Fuel or antifreeze spilled on appliques or DO NOT use citrus based cleaners on decals should be rinsed off immediately with polycarbonate finishes.

  • Page 119: Hood Cowl Panel Cleaning

    Exterior Light Lenses Leather Upholstery Most Winnebago Industries vehicles have Driver / Passenger Seats –If Equipped polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical The optional leather seats are made of top solvents and cleaners.

  • Page 120: Cabinetry

    SECTION 11 MAINTENANCE/STORAGE Fabric Upholstery CABINETRY Some fabrics used in this motor home may Wooden items may be cleaned with a soft contain fire retardant and lightfastness additives cloth and a good quality wood finish cleaning which can be damaged by use of improper product.

  • Page 121: Range And Refrigerator

    SECTION 11 MAINTENANCE/STORAGE General Cleaning Tub and Shower Walls Rinse all food and beverage residue from the The tub and shower walls in the bathroom sink as soon as possible. Some food & beverage should be cleaned with a mild soap and water residues, if left to sit in the sink, may require the solution.

  • Page 122: Preparing Vehicle For Storage

    SECTION 11 MAINTENANCE/STORAGE 3. Remove all foods and items that may cause odors from cabinets and refrigerator. 4. Clean and defrost the refrigerator. Prop the door open slightly to allow any odors to dissipate. Place an open box of baking soda inside the refrigerator to help absorb odors.

  • Page 123: Removal From Storage

    SECTION 11 MAINTENANCE/STORAGE 10. Close all windows and roof vents. Protect all 14. Clean wall and counter surfaces. appliance vent openings from contamination 15. Replace batteries if necessary and check out by animals or insects (e.g. bird nest, wasp electrical system to make sure all lights and nests, etc.) electrical components operate.

  • Page 124: Coach Maintenance Chart

    SECTION 11 MAINTENANCE/STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System Have propane gas system checked for leaks. Pressure regulator - inspect and adjust if needed Check propane tank condition, mounting and fittings Electrical System...
  • Page 125 SECTION 11 MAINTENANCE/STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items Headlights, Taillights and Marker Lights Turn Signals Horn...
  • Page 126 SECTION 11 MAINTENANCE/STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants” at the beginning of this section for proper inspection technique) Replace (see “Recommended Sealant Application”...

  • Page 127: Recommended Sealant Application

    SECTION 11 MAINTENANCE/STORAGE RECOMMENDED SEALANT APPLICATION 11-13...

  • Page 129: Miscellaneous

    SECTION 12 MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motor home’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available CAUTION space when loading your motor home.
  • Page 130 SECTION 12 MISCELLANEOUS chairs, etc., a full fuel tank, full propane tank, and You will receive a weight ‘ticket’ that states a partial tank of fresh water - but empty holding your current Front Gross Axle Weight, Rear tanks. Gross Axle Weight and Gross Vehicle Weight. You can compare these weights to the weight Finding a Scale ratings listed on your Vehicle Certification Label...

  • Page 131: Car Or Trailer Towing

    SECTION 12 MISCELLANEOUS When the front wheel has been weighed, pull CAR OR TRAILER TOWING the coach straight ahead until only the right rear wheel/dual set is on the scale pad as shown. Hitch pulling capacity: 5,000 lbs. max. Tongue weight 350 lbs.

  • Page 132: Trailer Wiring Connector

    SECTION 12 MISCELLANEOUS WARNING For safe towing and vehicle handling, maintain proper trailer weight distribution. The total weight of the motor home and the vehicle towed must not exceed the Gross Combined Vehicle Weight rating. See the “Body and Chassis Specification” chart in the Introduction Section.

  • Page 133: Electric Entrance Step

    The step is equipped with an automatic are independent of towing vehicle ratings.) retraction feature that stores the step NOTE: All Winnebago Industries models automatically when the Ignition Switch key is equipped with a Class 4 hitch have a turned to the On or Start positions and the label stating vertical tongue load is entrance door is closed.

  • Page 134: Tool And Ladder Storage

    SECTION 12 MISCELLANEOUS • Never ignore warning labels or weight limits TOOL AND LADDER STORAGE defined on your ladder. The following warning label is located on or near the ladder: The roof ladder extension and various supplied tools are stored in clips on the walls of one or two of the exterior storage compartments.

  • Page 135: Storage Compartment Doors

    SECTION 12 MISCELLANEOUS STORAGE COMPARTMENT DOORS The high-density gaskets used on the exterior storage compartments are designed to provide a more positive seal against dust and weather. Sometimes this seal firmness can inhibit complete latching of the compartment doors if they are simply ‘dropped shut’...

  • Page 136: Windows

    SECTION 12 MISCELLANEOUS Vertical Slider Windows WINDOWS Vertical windows have spring-loaded catches on both sides of the window that pop out to hold Crank-Out Windows the window in its fully raised position. Press the Turn the crank-out knob clockwise to open catches outward toward the frames while window;...

  • Page 137: Effects Of Prolonged Occupancy

    SECTION 12 MISCELLANEOUS To Operate Ceiling Ventilator moisture can cause water stains or mildew which can damage interior items such as upholstery and 1. Turn the Dome Crank Knob to raise the dome cabinets. about 3" or more to allow the turbine fan to When you recognize the signs of excessive operate.
  • Page 139 INDEX 120-Volt AC System ........6-1 DVD Home Theater System ......8-2 120-Volt Circuit Breakers ......6-3 Effects of Prolonged Occupancy ....12-9 120-Volt Receptacles (Outlets) ....6-4 Electric Entrance Step ........ 12-5 12-Volt DC System ........6-6 Electrical Cautions ........6-1 12-Volt House Circuit Breakers ....
  • Page 140 Index Key One Lock System ......... 3-4 Safe Use of the Propane Gas System ... 5-2 Leveling System ........10-9 Safety Messages Used in this Manual ..1-1 Lights ............3-13 Sealants ............11-1 Loading the Vehicle ........12-1 Seat Belts ............. 3-2 Lounge Chair Hoop Base ......
  • Page 141 Index Water Heater Bypass Winterization Valve 7-11 Water Line & Tank Drain Valves ....7-10 Water Pump ..........7-2 Water System Drain Valve Locations ..7-17 Weighing Your Loaded Vehicle ....12-1 Windows ............ 12-8 Wood Furniture and Cabinetry ....9-6...

This manual is also suitable for:

Adventurer 33v2007Adventurer 38j2007Adventurer 35a2007Adventurer 38t2007Adventurer 35l2007Adventurer 37b2007

Table of Contents