Winnebago Suncruiser Owner's Manual
  1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. Suncruiser
  6. Owner's manual

Winnebago Suncruiser Owner's Manual

Hide thumbs Also See for Suncruiser:
Table of Contents

Advertisement

Quick Links

See also: Basic Operation Manual , User Manual
Rev. 1513150625
Part No. 161500-15-023
Copyright 2014 Winnebago Industries, Inc. All rights reserved.

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Suncruiser and is the answer not in the manual?

Questions and answers

Related Manuals for Winnebago Suncruiser

Summary of Contents for Winnebago Suncruiser

  • Page 1 Rev. 1513150625 Part No. 161500-15-023 Copyright 2014 Winnebago Industries, Inc. All rights reserved.

  • Page 3: Table Of Contents

    TABLE OF CONTENTS 1 – INTRODUCTION About this Manual ..........................1-1 Safety Messages Used in this Manual ....................1-1 Pre-Delivery Inspection ........................1-2 Before Driving ..........................1-2 Front Axle Tire Alignment ....................... 1-2 Service and Assistance ........................1-2 Reporting Safety Defects ........................1-2 Occupant and Cargo Carrying Capacity Label .................
  • Page 4 Table Of Contents Park Brake – Foot Pedal ........................3-7 Tow/Haul Transmission Mode ......................3-7 Hazard Warning Flashers ........................3-7 Map Light Switch ..........................3-8 Battery Boost Switch ........................3-8 Air Conditioner/Heater – Automotive (Dash) .................. 3-8 Heater – Rear Coach (Automotive) ....................3-9 Defrost Fans ............................
  • Page 5 Table Of Contents Propane Vaporization in Cold Weather .................... 5-6 6 – ELECTRICAL Electrical Cautions ..........................6-1 Electrical System – House 120-Volt AC ..................6-1 Power Cord – External ........................6-1 Inverter Unit – 1000W ........................6-3 Inverter/Charger Unit – 2000W ......................6-4 Power Center .............................
  • Page 6 Table Of Contents TV Digital Satellite System – Automatic ..................8-9 Exterior Entertainment Center (Adjustable) ..................8-9 Exterior Entertainment Center (Flip-up) ..................8-10 9 – FURNITURE AND SOFTGOODS Lounge Chair – Swivel ........................9-1 Buffet Table and Chairs ........................9-1 Sliding Buffet Table and Chairs .......................
  • Page 7 Table Of Contents Stainless Steel Appliances ......................11-8 Galley Sink ............................. 11-9 Range and Refrigerator ........................11-9 Vinyl Flooring ..........................11-9 Bathroom ............................11-10 Doors and Windows ........................11-10 Vehicle Storage – Preparation ...................... 11-10 Vehicle Storage – Removal ......................11-11 Chassis Service and Maintenance ....................

  • Page 9: Introduction

    DA NG E R The instructions included in this manual are intended as a guide, and in no way extend the responsibilities of Winnebago DANGER indicates a hazardous situation Industries beyond the standard written which, if not avoided, will result in death or warranty as presented in this manual.

  • Page 10: Pre-Delivery Inspection

    National Highway Traffic Safety Administration any problems before delivery. (NHTSA) in addition to notifying Winnebago Industries, Inc. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety...

  • Page 11: Occupant And Cargo Carrying Capacity Label

    However, NHTSA cannot become involved in individual problems between you, your dealer, or ® Winnebago Industries To contact NHTSA, you may either call the Vehicle Safety Hotline toll-free at: 1-888-327-4236; (TTY: 1-800-424-9153) or go to their website at http://www.safercar.gov...

  • Page 12: Vehicle Certification Label

    These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.

  • Page 13: Specifications And Capacities

    80 gal. Notes: All information is based upon the most recent data available. Visit the Winnebago Industries, Inc. web page – www.winnebagoind.com – for the most current product information. The height of each model is measured to the top of the tallest standard feature and is based on the curb weight of a typically equipped unit.

  • Page 14: Owner And Vehicle Information

    Motorhome Serial Number ___________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...

  • Page 15: Safety And Precautions

    SECTION 2 – SAFETY AND PRECAUTIONS GENERAL WARNINGS DRIVING SAFETY • Only seats equipped with seat belts are to be occupied while the vehicle is moving. WARNING • Make sure all passengers have seat belts fastened. Lap belts should fit low on the hips and upper thighs.

  • Page 16: Fuel And Propane Gas

    SECTION 2 – SAFETY AND PRECAUTIONS • Do not adjust tilt steering in a moving vehicle. • Do not operate the cruise control on icy or WARNING extremely wet roads, winding roads, in heavy traffic, or in any other traffic situation where a constant speed cannot be maintained.

  • Page 17: Propane Gas Leaks

    SECTION 2 – SAFETY AND PRECAUTIONS DANGER DANGER Do not use gas cooking appliances for IF YOU SMELL PROPANE comfort heating. Can lead to carbon 1. Extinguish any open flames and all monoxide poisoning, which can lead to smoking materials. death or serious injury.

  • Page 18: Carbon Monoxide Warning

    RV application. We area. recommend obtaining a replacement from your ® Winnebago Industries dealer. CARBON MONOXIDE ALARM Further Information Your coach is equipped with a Carbon See the manufacturer’s user guide provided in...

  • Page 19: Smoke Alarm

    RV application. We injury. recommend obtaining a replacement from your ® Winnebago Industries dealer. Replacement Further Information When replacing this alarm, we recommend replacing only with the same model, or with one Please read the information provided by the that is also listed for RV application.

  • Page 20: Fire Extinguisher

    Extinguisher, the replacement must be the same weight rating for either axle. type and size as the one originally supplied in your coach. We recommend obtaining a replacement only from your Winnebago ® Industries dealer or a reliable RV parts supplier.

  • Page 21: Maintenance

    SECTION 2 – SAFETY AND PRECAUTIONS MAINTENANCE • Do not remove the radiator cap while engine and radiator are still hot. Always check coolant level visually at the see-through coolant reservoir. • Never get beneath a vehicle that is held up by a jack only.

  • Page 22: Slideout Rooms

    SECTION 2 – SAFETY AND PRECAUTIONS ventilation may allow formaldehyde and other SLIDEOUT ROOMS contaminants to accumulate in indoor air. Ventilation to dilute the indoor air may be obtained from a passive or mechanical ventilation system. Always be sure to thoroughly WARNING ventilate your recreational vehicle before and during each use.

  • Page 23: Roof And Ladders

    Mold can grow with the smallest of problem occur. a nutrient base. Just small amounts of dirt or dust If Winnebago Industries determines that mold on the carpet can be enough to allow the mold is present due to conditions it determines is not a process to begin.

  • Page 24: Roadside Emergency

    ® flat tire whenever possible. However, if an Winnebago Industries does not assume emergency requires you to change the tire responsibility for damage incurred while towing yourself, please exercise extreme caution and this vehicle.

  • Page 25: Jump Starting

    SECTION 2 – SAFETY AND PRECAUTIONS For information on what to do in case of overheating, consult your chassis manual. WARNING Stay out from beneath the motorhome while it is suspended by the towing assembly. Do not allow passengers to occupy a towed vehicle.

  • Page 27: Driving Your Motorhome

    SECTION 3 – DRIVING YOUR MOTORHOME Front Seats The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago Lift to ® Industries . It also includes passenger seating in...

  • Page 28: Co-Pilot Footrest

    SECTION 3 – DRIVING YOUR MOTORHOME Armrest Adjustment –If Equipped The armrests may be swung upward out of the way for easy exit or access to the front seats. A roller on the underside of the front of the armrest also lets you adjust the resting angle for personal comfort, whether the seat is upright or reclined.

  • Page 29: Seat Belts

    SECTION 3 – DRIVING YOUR MOTORHOME Adjustment To lengthen belt, swivel the tab end at a right angle to belt and pull strap to desired length. To shorten, pull loose end of belt. To Fasten Be sure belt is not twisted. Grasp each part of the belt assembly and push tongue into buckle.

  • Page 30: Child Restraints

    SECTION 3 – DRIVING YOUR MOTORHOME The shoulder belt is designed to lock only 1. Look for the label certifying that it meets all during a sudden stop, sudden body movement or applicable safety standards. a collision. At all other times it will move freely 2.

  • Page 31: Keyone Lock System

    The key number for your coach is registered in our factory database, so if you ever lose your ® keys, any Winnebago Industries dealership can order a new key for you. Mirror Heat Switch (Located on driver side trim panel) MIRRORS –...

  • Page 32: Front Drop-Down Solar/Night Shade (12-Volt)

    SECTION 3 – DRIVING YOUR MOTORHOME FRONT DROP-DOWN SOLAR/ NIGHT SHADE (12-VOLT) Your coach is equipped with a 12V Front Drop-Down Solar/Night Shade that provides privacy and solar heat protection as well as a sunvisor feature. The power switches for the 12V Front Drop- Down Solar/Night Shade are located on the dash or driver side trim panel, depending on model.

  • Page 33: Brake-Shift Interlock

    “hunting” by the automatic Should the Automatic Safety Retraction transmission while towing. It also improves feature deploy, go to your nearest Winnebago power delivery and uses engine braking to help ® Industries dealer for service before operating control vehicle speed when descending hills.

  • Page 34: Map Light Switch

    SECTION 3 – DRIVING YOUR MOTORHOME Press and Hold the Battery Boost switch in the MAP LIGHT SWITCH ON (up) position while turning ignition key for emergency starting power. Turn the driver side Map Light on using the light dimmer wheel (located on dash). Roll it up NOTE: The House/Coach Battery Disconnect to maximum position until you feel it click into switch near the entrance door must be...

  • Page 35: Heater - Rear Coach (Automotive)

    SECTION 3 – DRIVING YOUR MOTORHOME NOTE: The dash air conditioner/heater is not • The middle position on the switch is OFF. designed to heat and cool the entire interior of the coach, but is intended only to provide heating and cooling for the cab area.

  • Page 36: Radio Power Switch

    SECTION 3 – DRIVING YOUR MOTORHOME USB Cable –If Equipped Your coach may be equipped with a cable to connect your USB to play through your radio. The USB cable is located on the dash beverage tray. See the manufacturer’s information in your InfoCase for operating instructions.
  • Page 37 SECTION 3 – DRIVING YOUR MOTORHOME NOTE:The House/Coach Battery Disconnect reverse. The “Camera Polarity” setting switch must be ON while listening to the is found under “Camera Settings” in the dash radio, as the audio relay is powered system menu. by house batteries.

  • Page 38: Infotainment Center/Gps

    SECTION 3 – DRIVING YOUR MOTORHOME Satellite Radio Radio Power Switch –If Equipped The Radio Power switch lets you connect the dash radio to the coach batteries with the ignition Your coach may be equipped with a ® switch turned off for listening while parked. This SiriusXM satellite radio receiver that plays prevents accidental draining of the chassis...
  • Page 39 SECTION 3 – DRIVING YOUR MOTORHOME Basic Operating Instructions Refer to the manufacturer’s owner manual The GPS navigation system can help you and/or quick start guide provided in your confidently chart your course through the most InfoCase for a complete explanation of features dense concrete jungle or remote country and operating/set-up instructions.

  • Page 40: Cb Radio Power Wiring

    SECTION 3 – DRIVING YOUR MOTORHOME Radio Power Switch The Radio Power switch lets you connect the dash radio to the coach batteries with the ignition switch turned off for listening while parked. This prevents accidental draining of the chassis battery with prolonged use of the radio.

  • Page 41: Engine Access - Interior

    SECTION 3 – DRIVING YOUR MOTORHOME • Insert hex wrench into the hole located on the top center of the engine cover (as shown) or the front edge of engine cover (depending on model) to unlock. -Typical installation shown NOTE: On certain models, there may also be To Close Hood Panel additional screws to remove at the lower •...

  • Page 42: Engine Cooling System

    SECTION 3 – DRIVING YOUR MOTORHOME Further Information NOTE: If your coach is featured with a beverage tray, it may need to be removed to Refer to the chassis manual in your InfoCase provide additional clearance before for information and precautions on filling, removing the engine cover.

  • Page 43: Suspension Alignment And Tire Balance

    SECTION 3 – DRIVING YOUR MOTORHOME should be checked and replaced, when necessary, with a new bulb of the same size. A failure of WARNING more than one light, such as both taillights not operating, may indicate a burned out fuse. Check fuse and replace with one of the same rating Make sure all replacement tires are of the when necessary.
  • Page 44 SECTION 3 – DRIVING YOUR MOTORHOME Further Information Refer to the chassis manual provided in your InfoCase for additional information about chassis-supplied fuses and circuit breakers. 3-18...

  • Page 45: Appliances And Systems

    SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motorhome are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. See Section 2 - Safety and Precautions of this manual for any safety and precautions you need to take regarding the operation of your appliances.

  • Page 46: Refrigerator - Residential

    SECTION 4 – APPLIANCES AND SYSTEMS REFRIGERATOR – RESIDENTIAL –If Equipped Your coach may be equipped with a “residential style” refrigerator. This refrigerator operates off of the 120-volt electrical system in your coach. -Typical View In order to operate, the refrigerator requires either the shoreline to be plugged in, the generator running, or inverter power.

  • Page 47: Ice Maker

    SECTION 4 – APPLIANCES AND SYSTEMS Basic Refrigerator Operation ICE MAKER Temperature controls are factory preset for –If Equipped your convenience. When you first use your refrigerator, make sure the controls are still set to Some refrigerators are equipped with an the recommended setting as shown.
  • Page 48 SECTION 4 – APPLIANCES AND SYSTEMS drain quickly if the refrigerator is powered from NOTE: Allow 24 hours for your refrigerator to the inverter when the engine is not running. Other cool completely before storing food. 120 volt appliances and other 120 volt devices Ice Maker are not intended to operate with inverter power •...

  • Page 49: Refrigerator Service Access Compartment

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information See the manufacturer’s user guide provided in your InfoCase for further key features as well as operating, safety, maintenance, and troubleshooting information. REFRIGERATOR SERVICE ACCESS COMPARTMENT (Exterior) Refrigerator Access Compartment The exterior refrigerator service compartment -Typical View allows access to the rear of the refrigerator for inspection, maintenance, and service.

  • Page 50: Range And Oven

    SECTION 4 – APPLIANCES AND SYSTEMS RANGE AND OVEN –If Equipped NOTE: See the appliance manufacturer’s user guide provided in your InfoCase for complete operating instructions and safety precautions. The Range and optional Oven in your motorhome operate on propane gas and will provide most of the functions of the range in your Oven Burner Knob home.

  • Page 51: Microwave Oven/Range Hood

    SECTION 4 – APPLIANCES AND SYSTEMS Unlike homes, the amount of oxygen supply is limited due to the size of the recreational vehicle, and proper ventilation when using the cooking appliances avoids dangers of asphyxiation. It is especially important that cooking appliances not be used for comfort heating, as the danger of asphyxiation is greater when the appliance is used for long periods of time.

  • Page 52: Battery Charge Meter

    SECTION 4 – APPLIANCES AND SYSTEMS Sensors Gen Start Gen Stop Hourmeter Water Tank Typical - Your coach may or may not be -Typical View equipped with all of the features shown. Tank Capacities See “Tank Capacities” in Section 1 - Water And Holding Tank Levels Introduction.

  • Page 53: Power Control System (Pcs)

    SECTION 4 – APPLIANCES AND SYSTEMS • An interior light should be turned on to POWER CONTROL SYSTEM provide a small load which draws off the (PCS) battery surface charge. –If Equipped Water Heater Switches The Power Control System (PCS) monitors See Water Heater information elsewhere in the electrical usage of the appliances and this section for operating instructions.

  • Page 54: Water Heater - Gas Tankless

    SECTION 4 – APPLIANCES AND SYSTEMS See the Water Heater manufacturer’s operation manual provided in your InfoCase for complete operating instructions, safety warnings, and maintenance information before operating the Water Heater. 1. Pressurize the water system by turning on pump or city water pressure. 2.

  • Page 55: Water Heater - Gas/ Electric

    SECTION 4 – APPLIANCES AND SYSTEMS Be sure the Water Heater is filled with water before starting either electric or propane gas operation. To fill the Water Heater, turn the Water Pump switch ON and open a hot water faucet anywhere in the coach. When water begins to flow steadily from the faucet, the Water Heater is full.

  • Page 56: Motoraid Water Heater

    SECTION 4 – APPLIANCES AND SYSTEMS NOTICE Any leak in the heat exchanger or its supply or return lines could cause loss of coolant and subsequent engine failure. We recommend that you periodically inspect these connecting lines and the heater to insure that no leaks have developed.

  • Page 57: Pressure-Temperature Relief Valve (Tankless Water Heater)

    SECTION 4 – APPLIANCES AND SYSTEMS PRESSURE-TEMPERATURE CAUTION RELIEF VALVE (TANKLESS WATER HEATER) On occasion, water may be seen seeping from Hot water can escape from tank causing injury. Operate this valve only when the the water heater pressure temperature relief tank water is cold.

  • Page 58: Electronic Thermostat

    SECTION 4 – APPLIANCES AND SYSTEMS 3. Pull the handle of the P-T valve straight out and allow water to flow until it stops. • LCD Display Screen • System Button • Zone • Setpoint Buttons Button • Mode Button Electronic Thermostat (Located near monitor panel) •...

  • Page 59: Heat Pump

    SECTION 4 – APPLIANCES AND SYSTEMS To Run Fan Only (No Heat or Air) • Fan High/Fan Low: Sets the fan to run continuously at high or low speed. The upper • Press the System Button and select “Cool”. cooling unit will not run to produce cooling. •...

  • Page 60: Air Conditioner Filters

    NOTE: It is normal for some water to run off the roof when using your air conditioner in “heat pump” mode. ® See your Winnebago Industries dealer for service and proper cleaning of the drain lines. 4-16...

  • Page 61: Washer/Dryer - Stackable

    SECTION 4 – APPLIANCES AND SYSTEMS Air Filter (Located on back side of Return Air Vent) -Typical View NOTE: There are multiple Supply and Return Water Supply Faucets Vents throughout the coach. Therefore, you must remember to remove each The Washing Machine Water Supply Faucets separate air filter from each Return Air are located along side the Stackable Washer/ Vent to clean.

  • Page 62: Washer/Dryer - Prep Package

    Typically, the plumbing is located inside a * Model 37F shown rear storage cabinet (pull out drawer or remove shelving and panels to access). We recommend obtaining parts and service for the Washer/Dryer installation from your ® ® Winnebago or Itasca dealer. 4-18...

  • Page 63: Propane Gas

    SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY Tank Gauge & Tank Fill Overflow Sender The propane gas system supplies fuel for the Valve Valve gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides modern living conveniences wherever you travel.

  • Page 64: Propane Accessory Connection

    SECTION 5 – PROPANE GAS to the National Propane Gas Association, propane gas outlets in the United States do not WARNING offer any other type of liquefied petroleum gas than propane to the general public.) Check local phone directory yellow pages for locations of Do not fill propane container(s) to more local propane gas refilling stations or bulk than 80 percent of capacity.

  • Page 65: Safe Use Of The Propane Gas System

    SECTION 5 – PROPANE GAS “clockwise” to turn gas supply OFF. Rotate the shut-off valve “counter-clockwise” to turn gas CAUTION supply ON. See Section 2 - Safety and Precautions in this manual for other safety and precautions you need Turn valve off when not in use. to be aware of related to propane.

  • Page 66: Propane Gas Warnings And Precautions

    SECTION 5 – PROPANE GAS • Have the entire propane gas system inspected for possible leaks and missing or damaged DA NG E R parts at each filling. Also inspect before and after each trip, and any time trouble is suspected.

  • Page 67: Propane Gas Pressure Regulator

    SECTION 5 – PROPANE GAS • Never use an open flame to test for propane gas leaks. Replace all protective covers and caps on propane system after filling. Make sure valve is closed and door latched securely. • Portable fuel-burning equipment, including wood and charcoal grills and stoves, shall not be used inside the recreational vehicle.

  • Page 68: Propane Vaporization In Cold Weather

    SECTION 5 – PROPANE GAS tank control valve closed when not in use, even when tank is empty, to prevent moisture from collecting on the inside. If regulator freeze-up should occur, you may attempt to thaw the regulator using a light bulb. DO NOT USE AN OPEN FLAME OR HEAT LAMP.

  • Page 69: Electrical

    SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motorhome that is • 12-volt DC system (battery current);...

  • Page 70: Connecting The Power Cord

    SECTION 6 – ELECTRICAL be used is designed to mate with the prongs of the power cord plug, the electrical connection can be WARNING expected to carry rated load. Connecting The Power Cord This connection is for 208Y/120-Volt or To connect to an external source, remove the 120/240 Volt AC, 3-pole, 4 wire, 60 Hz cord from the utility compartment and plug it into 50 Ampere supply.

  • Page 71: Inverter Unit - 1000W

    SECTION 6 – ELECTRICAL Inverter Unit (Located inside an exterior compartment) -Typical View WARNING NOTICE Service inlet access must be closed when utility connections are not in use. Do not store items too closely around the Park Fuses or Breakers inverter unit in the storage compartment.

  • Page 72: Inverter/Charger Unit - 2000W

    SECTION 6 – ELECTRICAL When the inverter is not being used, it should be shut off at the control panel. The inverter NOTICE could drain the house batteries if the shoreline is not connected to external power and the House/ Coach Battery Disconnect switch is on.

  • Page 73: Power Center

    SECTION 6 – ELECTRICAL Inverter/Charger Control Panel POWER CENTER The inverter/charger has a wall-mounted (Converter) control panel that can be programmed for several The power converter is generally located charging options. It will also display warnings for under a cabinet in the galley, living area, or in the overload conditions or other operating failure power cord compartment, depending on the conditions.

  • Page 74: Circuit Breakers - House 120-Volt Ac

    SECTION 6 – ELECTRICAL Thermal Overload A thermal overload device inside the converter will shut down the converter if it becomes overheated. This can result from operating above its maximum limit for an extended period of time or by obstruction of ventilation to unit.

  • Page 75: Electrical Generator

    SECTION 6 – ELECTRICAL • Push to Reset circuit after WARNING monthly testing or ground fault tripping. Do not plug the power cord into the generator receptacle while the generator is running. Electrical shock can cause personal injury. • Push to Test at Automatic Power Transfer Switch least monthly.

  • Page 76: Generator Operation

    SECTION 6 – ELECTRICAL The following label is located near the 120- volt house circuit breaker panel and at the Generator to warn you to disconnect specific electrical connections before servicing the Generator and storing the coach. AGS Control Pad (Located near monitor panel) Generator Operation See the AGS user guide for more information...

  • Page 77: Electrical System - House 12-Volt Dc

    SECTION 6 – ELECTRICAL Operation Warnings and Cautions WARNING The exhaust of all internal combustion engines contains carbon monoxide (CO). This poisonous gas is colorless, odorless, tasteless, and lighter than air. The exhaust systems of both your motorhome engine and your generator engine have Generator Start/Stop Buttons been installed with your safety in mind.

  • Page 78: House/Coach Battery Disconnect Switch

    SECTION 6 – ELECTRICAL Converter The house batteries can also provide emergency power to start the engine if the chassis See “Power Center.” battery is discharged. (See “Battery Boost Chassis Battery Switch” in Section 3 - Driving Your Motorhome). The chassis battery is used to operate the House batteries are automatically charged by engine starter and automotive accessories and the chassis alternator while the engine is running.

  • Page 79: Battery Access

    SECTION 6 – ELECTRICAL BATTERY ACCESS The house/coach batteries (and chassis batteries in certain models) are located beneath the interior entrance steps. With the Residential Refrigerator, the house batteries are accessed by a separate exterior door. • Unfasten the step retainer, then lift the step upward and remove to service batteries.
  • Page 80 SECTION 6 – ELECTRICAL energy is removed from the battery, it should be replaced by the engine alternator or the coach WARNING converter system. If a battery sits unused for 30 days or more, especially during warm weather, it can develop a California Proposition 65 Warning: deposit of sulfate crystals on the metal plates Battery posts, terminals, and related...

  • Page 81: Circuit Breakers - House 12-Volt

    If your coach is going to be unoccupied for year. ® two weeks or more, Winnebago Industries • Check the battery fluid level every month, or recommends disconnecting the chassis batteries more often in hot weather. Fill to in your coach to avoid battery discharge.
  • Page 82 SECTION 6 – ELECTRICAL Automotive Chassis and House House 12-Volt Circuit Breaker Panel 12-Volt Circuit Breaker Panel -Typical View (Located inside passenger compartment) A label on the panel states the amperage rating -Typical View and circuit protected for each breaker. NOTE: Breakers are labeled on panel.

  • Page 83: Plumbing

    SECTION 7 – PLUMBING FRESH WATER SYSTEM The Fresh Water System provides water to the galley sink, shower, bathroom lavatory, toilet, and water heater. Water may be supplied by either of two sources: • A fresh water tank and water pump located within the motorhome, or •...
  • Page 84 SECTION 7 – PLUMBING Fresh Water Valve Fresh Water Valve (Located in water service center) (Located in water service center) -Typical View -Typical View 4. Turn city water supply ON. Using City Water 5. Use the level display on the monitor panel to When connected to an outside source of water, oversee filling of the tank, or when the tank is the water bypasses the water pump and storage...

  • Page 85: Utility Light

    SECTION 7 – PLUMBING Using Tank Water (Gravity Fill) NOTE: Ensure the Fresh Water valve is in NORMAL position to use the water • Turn Water Pump switch ON. While the pump. If the valve is in Tank Fill position, switch is on, the water pump will the pump will run continuously without automatically supply tank water as needed.
  • Page 86 SECTION 7 – PLUMBING NOTE: We recommend that you check and clean We recommend that you turn the Water Pump the strainer after each tankful of water switch off whenever you will be away from the during the first few uses of the Water vehicle or not using the water system.

  • Page 87: Cold Water Filter

    SECTION 7 – PLUMBING Water Pump Water Pump (Located in compartment behind (Located on passenger side above water entrance door) heater. Remove water heater door to access.) * Models 32H and 35P shown * Model 38Q shown COLD WATER FILTER –If Equipped To obtain filtered cold water for drinking or cooking, simply open the galley sink cold water...

  • Page 88: Ice Maker Water Filter

    SECTION 7 – PLUMBING Replacing the Cold Water Filter Cartridge You should replace the filter cartridge every season and when water flow from the faucet is too slow for convenience. The cartridge must be replaced at least every 12 months. •...

  • Page 89: Disinfecting Your Fresh Water System

    SECTION 7 – PLUMBING DISINFECTING YOUR FRESH WATER SYSTEM ® (As required by NFPA 1192 Standard on Recreational Vehicles) To ensure complete disinfection of the potable water system, it is recommended that the following procedure be followed on a new system, one that has not been used for a period of time, or one that could have become contaminated.

  • Page 90: Shower Hose Vacuum Breaker

    SECTION 7 – PLUMBING ppm chlorine concentration should be allowed to stand in the system for at least 1 hour.) 5. Drain the water tank and refill with fresh water. 6. Open each faucet again and run fresh water to flush chlorinated water from the lines.

  • Page 91: Toilet - Electric Flush

    SECTION 7 – PLUMBING Important “Don’ts” See winterizing instructions at the end of this section to prepare the toilet for storage in freezing • Don't use facial tissue or regular toilet tissue in conditions. the RV toilet. These will not disintegrate sufficiently and will often cling to the sides of Further Information the holding tank.

  • Page 92: Dumping Holding Tanks

    SECTION 7 – PLUMBING appropriate waste water disposal site. This means NOTE: Black and Gray Waste Tank Drain you can use the toilet, sinks and shower even in positions may be reversed depending on areas where utility hookups are not available. floorplan and tank location.

  • Page 93: Waterline & Tank Drain Valves

    SECTION 7 – PLUMBING 3. Attach a garden hose from a city water them to be carried out with the liquids when the hydrant to the Black Waste Tank Flush Inlet dump valve is opened. If the valve is left open, fitting in the water service center.

  • Page 94: Water Heater Bypass Valve

    SECTION 7 – PLUMBING Waterline Drain Valve Water Tank Drain Valve - Typical Installation -Typical Installation WATER HEATER BYPASS VALVE –If Equipped Your coach may be equipped with a water heater bypass valve for easier winterization of waterlines using RV antifreeze. See Water System Drain Valve Locations chart at the end of this section for valve location on your model.

  • Page 95: Winterizing Procedures

    SECTION 7 – PLUMBING 4. Remove the Water Filter Cartridge (if WINTERIZING PROCEDURES equipped). Remove and discard the filter cartridge from the filter cold water faucet/ice You can winterize the water and plumbing maker filter assembly located below the system of your coach using one of the following galley sink.
  • Page 96 30 psi or less to force air through the system. A blow-out plug can be purchased • Also, open the Pressure-Temperature Relief ® ® at any Winnebago or Itasca dealer. valve to prevent air locking while draining. 7-14...
  • Page 97 SECTION 7 – PLUMBING caustic chemicals such as bleach or laundry detergents into the toilet bowl or holding tanks. Although these products City Water Connection may have a deodorizing effect, they may damage plastic and rubber parts in the system. 16.
  • Page 98 SECTION 7 – PLUMBING Your coach is equipped with a manually • Twist the filter cartridge “counter-clockwise” operated waterline winterization system for your about a quarter-turn and pull it down and out convenience in winterizing fresh waterlines. of the filter socket. The system features a winterization (diverter) •...
  • Page 99 SECTION 7 – PLUMBING Fill Lines 5. Turn the Water Pump switch on. 6. Open each hot and cold water faucet handle/ knob in the coach – one at a time each in turn until antifreeze solution just begins to flow from the faucet, then close.
  • Page 100 SECTION 7 – PLUMBING CAUTION Hot water can escape from tank causing injury. Operate relief valve or remove drain plug only when the tank water is cold. • Also, open the Pressure-Temperature Relief valve at the top right portion of the tank to Pressure-Temperature Relief Valve prevent air locking in the tank while (Lift handle only when water heater is cold)

  • Page 101: Winterizing Optional Appliances

    SECTION 7 – PLUMBING See instructions for removal from storage in 2. Close all drain valves. Section 11 - Maintenance and Storage. 3. Turn the water supply ON. 4. Ensure the ice bin is in place and the wire shut- WINTERIZING OPTIONAL off arm is lowered to the ON position.
  • Page 102 SECTION 7 – PLUMBING Winterizing Washer/Dryer (Stackable) –If Equipped Method 1 – Drain Water If you have decided to completely drain the coach waterlines, follow these steps to winterize your Washer/Dryer: 1. With the Washer/Dryer power OFF, pour 1/2 quart of RV-type antifreeze into the Washer drum.
  • Page 103 SECTION 7 – PLUMBING 2. Press ON/OFF button, set water temperature to WARM, then press START. Let machine fill until the drum turns (this could take up to 1 to 2 minutes). 3. Press ON/OFF button to turn power OFF. 4.

  • Page 104: Water System Drain Valve Locations

    SECTION 7 – PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS SYSTEM DRAIN VALVE LOCATION Waterline Drain Valves • Model 32D: Compartment in front of passenger side rear wheel. • Models 32H and 35P: Compartment behind entrance door. • Model 37F and 38Q: Compartment behind passenger side rear wheel lip.

  • Page 105: Entertainment

    Secondary Source Selector Control (Located in front passenger overhead cabinet) (Located in your InfoCase Box) NOTE: There will be a slight delay when To Watch Satellite TV changing sources. Winnebago • Connect Satellite Receiver to the Accessory ® Industries recommends setting each Connection Cable (Satellite Receiver 1 or 2.)
  • Page 106 SECTION 8 – ENTERTAINMENT Accessory Connection Cables * Satellite Receiver 1 and Satellite Receiver 2 • Infrared Emitter (Located in a front overhead cabinet or near the lounge TV, depending on model) To Watch Broadcast TV (Antenna) NOTE: Auxiliary AV Component Cable not provided. •...

  • Page 107: Front Tv Ignition Switch Interlock

    SECTION 8 – ENTERTAINMENT To Watch Cable TV FRONT TV IGNITION SWITCH • Power “OFF” the TV Signal Amplifier Power INTERLOCK switch (located in overhead cabinet above –If Equipped entry door) and press the SOURCE or FUNCTION/TV SOURCE button on the TV If your coach is equipped with a front remote and select “TV”...
  • Page 108 SECTION 8 – ENTERTAINMENT ™ The Blu-ray /DVD Home Theater System 5. Insert Blu-ray or DVD into player. Blu-ray or operates from 120-volt AC household current DVD will begin to load automatically. The only, so you must have either the shoreline Home Theater System screen will typically connected, the generator running, or the inverter show “LOADING”.

  • Page 109: Tv (Dining Buffet) - Power Lift

    SECTION 8 – ENTERTAINMENT Program Home Theater Remote to Road vibration may damage the TV and/or operate TV power lift mechanism in the extended position. If you encounter significant road vibration, lower • On the Home Theater remote, the TV into stored position to avoid possible Hold down the Power button property damage.

  • Page 110: Tv Antenna - Digital

    SECTION 8 – ENTERTAINMENT TV ANTENNA – DIGITAL • Signal Meter • Attenuator Dial Power Switch ® (Jack Digital HDTV Over-the-Air Antenna) Your coach is featured with a digital antenna, which provides crystal clear digital HD reception of over-the-air channels in addition to superior broad reception range.

  • Page 111: Tv Signal Amplifier

    TV (if equipped). (Input) ® See your authorized Winnebago Industries The portable satellite dish and cable television dealer for proper installation and sealing of roof input connectors are located in the utility mounted components.

  • Page 112: Tv Digital Satellite System (Automatic/In-Motion)

    SECTION 8 – ENTERTAINMENT • There must be a clear “line of sight” to the satellite. Mountains, buildings, trees, telephone poles and other obstructions can all block the satellite signal from reaching the dish. • When activated while parked, the dish antenna will seek the selected satellite automatically.

  • Page 113: Tv Digital Satellite System - Automatic

    SECTION 8 – ENTERTAINMENT Further Information 2. The antenna will start the “searching” process first locating the home position. Then it will See the Satellite System owner’s manual in lock onto three different satellites. The your InfoCase for a complete description of antenna will display an asterisk for each features and instructions.

  • Page 114: Exterior Entertainment Center (Flip-Up)

    SECTION 8 – ENTERTAINMENT To Swivel TV EXTERIOR ENTERTAINMENT CENTER (FLIP-UP) –If Equipped Your coach may be equipped with an Exterior Entertainment Center, which contains Audio/ Video Connections for your outdoor listening or viewing pleasure. NOTE: These electronic devices and speakers are not designed to be waterproof.
  • Page 115 SECTION 8 – ENTERTAINMENT Further Information Please read the manufacturer’s user guide in your InfoCase for complete operating instructions. TV lock mechanism (Pull to the left to release) 2. Pull the TV all the way out and flip-up. 3. Push the TV to the desired located. To store TV 1.

  • Page 117: Furniture And Softgoods

    SECTION 9 – FURNITURE AND SOFTGOODS LOUNGE CHAIR – SWIVEL –If Equipped (Typical View – Your coach may differ in appearance) This chair is not equipped with a seat belt and is not intended for seating while the vehicle is in motion.
  • Page 118 SECTION 9 – FURNITURE AND SOFTGOODS 3. Latch strap and tighten as necessary for security. WARNING Properly secure all free-standing chairs, furniture, and loose items prior to driving. Moving items can cause driver distraction, possibly resulting in an accident that can result in death or serious injury.

  • Page 119: Sliding Buffet Table And Chairs

    SECTION 9 – FURNITURE AND SOFTGOODS 3. Push edge of buffet table in to adjoin with the table extension. WARNING Properly secure all free-standing chairs, furniture, and loose items prior to driving. Moving items can cause driver distraction, possibly resulting in an accident that can result in death or serious injury.

  • Page 120: Inlounge

    SECTION 9 – FURNITURE AND SOFTGOODS 4. Latch strap and tighten as necessary for 3. Push edge of buffet table in until it locks into security. place. Buffet Table Extension • Reverse steps to store table extension leaf. 1. Grasp the edge of the buffet table and pull all Sliding Table the way out.
  • Page 121 SECTION 9 – FURNITURE AND SOFTGOODS 4. Repeat Steps 1 through 3 on opposite dinette seat. Reverse steps to store the sectional dinette extensions. WARNING Stow sectional dinette extensions before retracting slide rooms. Failure to observe 2. Grasp the pull strap (located at the front of the can cause injury and will cause sectional extension seat cushion) and pull UP equipment damage.

  • Page 122: Intable

    SECTION 9 – FURNITURE AND SOFTGOODS DINETTE/BED CONVERSION – DREAM DINETTE ™ –If Equipped (Typical View – Your coach may differ in appearance) Reverse steps to store bed into dinette position. INTABLE –If Equipped inTable Leg Adjustment It may be necessary to adjust the height of the inTable leg(s).

  • Page 123: Dinette - Extendable Table And Chairs

    SECTION 9 – FURNITURE AND SOFTGOODS 3. Release the lock rod on the bottom of the dinette table by pulling down. Lock Rod Reverse steps to convert back into dinette 4. Push table straight down. Lower dinette seat seating. cushions. Once the table is up, engage the lock rod by pushing the lock rod up.

  • Page 124: U-Shaped Dinette/Bed Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS 2. Insert dinette table extension (located in the NOTE: Two folding chairs are provided for rear wardrobe). Align table extension pegs additional seating when needed and are with table insert holes and push edge of stored in the rear wardrobe, under the dinette table in to adjoin with the table bed or exterior compartment, depending...
  • Page 125 SECTION 9 – FURNITURE AND SOFTGOODS 1. Release both latches on the table leg to unlock. 4. Arrange cushions to cover bed area. NOTE: The cushions to cover the dining table section are located under the center dinette seat (lift removable panel below seat cushion to access) or you may use 2.

  • Page 126: Sofa/Bed Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS Bed to Sofa SOFA/BED CONVERSION • Push the front edge of the sofa seat toward the –If Equipped wall while lifting upward on the backrest until (Typical View – Your coach may differ in the sofa is fully seated against the wall and appearance) security latch “clicks”...
  • Page 127 SECTION 9 – FURNITURE AND SOFTGOODS WARNING Keep people away from operating mechanism and pinch hazard areas during use. Failure to do so could cause injury. To Operate • Lift footrest up and away from lounge to raised position. • Press the Rest Easy Power switch (located on the inside of the lounge armrest) toward the inboard side of the lounge to recline.

  • Page 128: Digital Sleep Air Bed

    SECTION 9 – FURNITURE AND SOFTGOODS Tip for “Power Users” DIGITAL SLEEP AIR BED • If you have the footrest unlatched and ® by Innomax positioned against the seat cushion, it will move out with the lounge when you press the –If Equipped Rest Easy Power switch in the recline •...

  • Page 129: Bed - Power Lift

    SECTION 9 – FURNITURE AND SOFTGOODS BED – POWER LIFT NOTICE –If Equipped (Typical View – Your coach may differ in appearance) Bed must be in the fully upright (vertical) Your coach may be equipped with a power position to fully retract slideroom. lift/lower mechanism that raises and lowers the head of your bed with a touch of a switch to best suit your comfort needs.

  • Page 130: Wood Furniture And Cabinetry

    People are drawn to the natural beauty of and the wood is considered part of the natural ® wood. At Winnebago Industries , our craftsmen aging process and is not to be considered defect work with the art found in each piece of wood to or damage.

  • Page 131: Slideout Rooms And Leveling

    The ignition key must be placed in the on or run position to operate the slideout room(s). The park brake must be applied for the room(s) to run. Winnebago recommends running the engine whenever you run the slideout rooms in or out, the engine alternator should insure the rooms have adequate 12-volt DC power to operate correctly.
  • Page 132 SECTION 10 – SLIDEOUT ROOMS AND LEVELING • Remove and Secure the Ignition Key. To Retract Slideout Room WARNING Before Retracting! • Be sure the coach is level and the Parking CRUSH HAZARD. Keep people and objects clear of the inside and outside of Brake is set.

  • Page 133: Slideout Room Retraction (With Power Lift Bed)

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING the slideout roof. Retract the slideout slowly, starting and stopping to allow water to drain off NOTICE room cover. Bed must be in the fully upright (vertical) position to fully retract slideroom. Further Information For further power bed operating instructions, refer to Section 9 - Furniture and Softgoods in this manual.

  • Page 134: Slideout Room Troubleshooting (Power Gear®) In Wall Slideout

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING If an error is detected on your slide system, the SLIDEOUT ROOM LED light on the control panel will blink an error TROUBLESHOOTING (POWER code. If an error code appears, see the In Wall GEAR ) IN WALL SLIDEOUT Slideout manufacturer’s user guide in your...
  • Page 135 SECTION 10 – SLIDEOUT ROOMS AND LEVELING Manual Mode • Light will flash fault • Light will flash if Manual Mode lets you individually move the code if system park brake not set two room arms by pressing the IN and OUT malfunctions buttons on the touchpad.

  • Page 136: Slideout Room Troubleshooting (Lippert)

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING SLIDEOUT ROOM • Light will flash fault • Light will flash if TROUBLESHOOTING code if system park brake not set malfunctions (LIPPERT) –If Equipped Battery Voltage or Circuit Breaker Problems If the slideout room will not work: •...
  • Page 137 SECTION 10 – SLIDEOUT ROOMS AND LEVELING Error Codes • Press the Mode button 6 times, quickly. Press a 7th time and hold for approximately 5 When an error occurs during slideout room seconds. operation, the slideout control panel (located in Red and green LED lights will begin to flash, driver side compartment) will use LED display confirming the override mode.

  • Page 138: Slideout Emergency Retraction (Lippert)

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING Crank-In Procedure 5. While maintaining pressure on ratchet wrenches, re-engage the motor brake by 1. Disengage the motor brake, which appears as moving lever clockwise slightly - or to right a flat “square” protrusion on the protective when facing end of motor (repeat for motor at boot at the end of the motor.
  • Page 139 SECTION 10 – SLIDEOUT ROOMS AND LEVELING 2. Using a flat-head screwdriver, push it up 5. Using a flat-head screwdriver, push bottom of underneath the screw cover and pull up to slideout motor UP to disengage release the cover. Remove the rest of the cover (approximately 1/2”...

  • Page 140: General Slideout Care

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING Slideout Travel Support -Typical installation shown • Place support item (e.g. 2x4 wood • Ensure slideout motor is disengaged board) above interior slideout room as approximately 1/2” from base. shown. 6. Push slideout room in to travel position, 8.

  • Page 141: Leveling System

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING In addition, certain caulks and sealers may include chemicals that may adversely effect the performance of the seals. See your authorized dealer for caulks and sealers recommended for your coach. LEVELING SYSTEM The Hydraulic Leveling System makes selecting a parking site easier and faster by reducing the effect of uneven ground.
  • Page 142 SECTION 10 – SLIDEOUT ROOMS AND LEVELING The Auto Level Remote switches are located just inside the entrance door and in the exterior service center. “Jacks Down” Light (Located on dash) -Typical View NOTICE • Do not try to drive vehicle unless “TRAVEL”...

  • Page 143: Checking Hydraulic Oil Level

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING 4. See the Leveling System Operation Guide Breather/Fill Cap supplied in your InfoCase for troubleshooting instructions or operating the Leveling System if jacks fail to retract or any other functions fail. Further Information See the manufacturer’s operation guide provided in your InfoCase for complete operating instructions, safety precautions, and...

  • Page 145: Maintenance And Storage

    • Have the sealant replaced if you notice any of seams, etc., should also receive immediate the above. Your local Winnebago Industries attention. Delaying these repairs may allow water dealer has the correct and necessary parts and leakage and result in damage to interior ceiling experience to help you maintain your sealants.

  • Page 146: Undercarriage

    SECTION 11 – MAINTENANCE AND STORAGE Rinsing and washing the surface helps remove UNDERCARRIAGE the fallout and neutralize the acid. After the initial 60-day cure stage, a coat of wax or Buildup of mud and dirt under the body of the polish can help protect the surface from these vehicle can cause damaging rust or corrosion on types of contaminates.
  • Page 147 SECTION 11 – MAINTENANCE AND STORAGE NOTE: When driving in wintry conditions, the • With area to be washed still wet from the rinse, road surface may be covered with heavy use the recommended soapy mixture to clean salts or small rocks to improve road the area.

  • Page 148: Exterior Graphic Care

    SECTION 11 – MAINTENANCE AND STORAGE Protective Film higher than 60 degrees for 60 days. Failure to observe this precaution could –If Equipped void your paint warranty. Your coach may be equipped with a protective • We recommend a silicone-free polish with an film to defend against everyday road hazards.

  • Page 149: Front End Masks And Paint Damage

    LIGHTS cleaning products to use on plastic parts. Exterior Light Lenses ® Most Winnebago Industries vehicles have NOTICE polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical solvents and cleaners.

  • Page 150: Interior Soft Goods

    SECTION 11 – MAINTENANCE AND STORAGE • Contact with certain chemicals can cause areas. For best results, fabric cleaning should be etching, “crazing”, or cracking of the lens, referred to a professional carpet and upholstery which can significantly reduce the lens clarity cleaner.

  • Page 151: Cabinetry - Cleaning

    SECTION 11 – MAINTENANCE AND STORAGE Vinyl simulated wood panels may be cleaned with a mild, water-based cleaner and a soft cloth. UltraLeather Cleaning Chart Do not use solvents on vinyl wood panels. Detergent/ Cleaner/ Type of Stain Water Degreaser NOTE: Many cabinetry and furniture items ...

  • Page 152: Stainless Steel Appliances

    SECTION 11 – MAINTENANCE AND STORAGE If the stain is not water-base or oil-base STAINLESS STEEL material, you may need to gently remove it using APPLIANCES a plastic scraper (disposable plastic knife for example) followed by normal cleaning methods –If Equipped described above.

  • Page 153: Galley Sink

    SECTION 11 – MAINTENANCE AND STORAGE Rust Stains • Avoid contact with full-strength bleaches, household chemicals, and acid-based Apply a multipurpose cream detergent and rub cleaners. If this happens, rinse and wipe dry delicately with a soft cloth. If stain persists, it quickly.

  • Page 154: Bathroom

    SECTION 11 – MAINTENANCE AND STORAGE Marks or Discoloration. White automotive BATHROOM rubbing compound may be used to remove stubborn marks or discoloration. Use of these Toilet products will not damage the solid surface. For instructions on the care of your toilet, refer Always follow label directions.

  • Page 155: Vehicle Storage - Removal

    SECTION 11 – MAINTENANCE AND STORAGE Disconnect switch off to avoid electrical 3. Check window operation. arcing when attaching and detaching charge 4. Check cabinet and door hinges. Lubricate clamps. with penetrating oil, if necessary. 5. Close all faucets and drain valves that are NOTE: We do not recommend leaving the open.

  • Page 156: Chassis Service And Maintenance

    SECTION 11 – MAINTENANCE AND STORAGE or cracks that may have appeared around the CHASSIS FUSES AND RELAYS window frames, vents, and any other joints. See Sealants – Inspection and General ® (Freightliner Chassis) Information at the beginning of this section. Chassis and dash component fuses and relays Re-sealing is quite simple and the material is are located behind driver side front hood panel.

  • Page 157: Coach Maintenance Chart

    SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System ...
  • Page 158 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: ...
  • Page 159 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants ...

  • Page 161: Miscellaneous

    SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motorhome’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available WARNING space when loading your motorhome.
  • Page 162 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motorhome is to weigh each “corner”...

  • Page 163: Car Or Trailer Towing

    SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual listed Gross Weight Ratings. See “Vehicle set (left rear duals or right rear duals) should not Certification Label” in the Introduction section exceed 6,000 lbs. for information on gross weight ratings.

  • Page 164: Trailer Wiring Connector

    SECTION 12 – MISCELLANEOUS located outside our recommended limits) places The following diagram shows proper excessive stress on the hitch. This abuse of the connection of trailer or tow vehicle wiring to the ball mount and the hitch may cause premature coach light system.

  • Page 165: Fireplace

    The equipped with a Class 3 hitch may have a POWER button will put the insert in standby label limiting vertical tongue load to 350 mode. This will turn off all functions at once lbs. All Winnebago Industries models 12-5...

  • Page 166: Fireplace

    SECTION 12 – MISCELLANEOUS Remote Operation but will hold the settings in the memory. By pressing the POWER button again the unit will turn on at the same settings. • Flame • Heater • Power NOTE: Holding the POWER button on the control panel for ten seconds will disable the heater function.

  • Page 167: Step (Entry) - Electric

    SECTION 12 – MISCELLANEOUS Control Panel • Power • Flame • Heater • Timer Entry Step Switch • Backlight (Located near the entrance door) -Typical View NOTE: Holding the POWER button on the The step has several automatic extend/retract control panel for ten seconds will disable functions that are controlled by the position of a the heater function.

  • Page 168: Tool And Ladder Storage

    SECTION 12 – MISCELLANEOUS Stationary Extended Mode - Step ROOF LADDER Switch OFF –If Equipped (Step Remains Extended) With the Step power switch in the OFF position, the step will extend when the screen WARNING door is opened and will stay extended whether the door is opened or closed.

  • Page 169: Storage Compartment Doors

    SECTION 12 – MISCELLANEOUS • Make sure you are physically capable to We recommend turning this switch OFF when safely use the ladder. Strength, flexibility, and the coach is not in use to avoid battery drain if a stability are required. compartment light is left on accidentally.

  • Page 170: Windows

    SECTION 12 – MISCELLANEOUS • To close, crank the window in snugly (by turning the window handle “clockwise”), then CAUTION back off 1/4 turn to help avoid glass warping, which can result in wind noise. • Push the lever back in on the window handle. Pinch Hazard.

  • Page 171: Power Roof Ventilator

    SECTION 12 – MISCELLANEOUS Fan Power Dome Crank Switch -Typical View Fan Speed Fuse Selector Power Roof Ventilator To Operate Ceiling Ventilator 1. Press the wall switch to raise the dome about 3" or more to allow the turbine fan to operate. (A built-in safety switch will not let the fan motor run unless the dome is partially open).

  • Page 172: Effects Of Prolonged Occupancy

    SECTION 12 – MISCELLANEOUS Further Information • The fan speed is controlled through the keypad on the fan or the wall UP/ON switch. See the power ventilator manufacturer’s Press the FAN ON switch to cycle through operating instructions supplied in your InfoCase four (4) speeds;...
  • Page 173 SECTION 12 – MISCELLANEOUS moisture can cause water stains or mildew, which can damage interior items such as upholstery and cabinets. When you recognize the signs of excessive moisture and condensation in your coach, you should take immediate action to minimize their effects.
  • Page 175 INDEX About this Manual ..........................1-1 Air Conditioner Filters .......................... 4-16 Air Conditioner/Heater – Automotive (Dash) ..................3-8 Audio/Video System Basic Operation ....................8-3 Awning – Power ........................... 12-9 Bathroom ............................11-10 Battery Access ............................6-11 Battery Boost Switch ..........................3-8 Battery Care ............................
  • Page 176 Index Electrical Cautions ..........................6-1 Electrical Generator ..........................6-7 Electrical Outlets – House 120-Volt AC ....................6-6 Electrical System – House 120-Volt AC ....................6-1 Electrical System – House 12-Volt DC ....................6-9 Electronic Thermostat ........................... 4-14 Emergency Exits ............................. 2-7 Engine Access –...
  • Page 177 Index Leveling System ..........................10-11 Lights ..............................3-17 Loading ..............................2-6 Loading the Vehicle ..........................12-1 Lounge Chair – Swivel ........................... 9-1 Maintenance ............................2-7 Map Light Switch ........................... 3-8 Microwave Oven/Range Hood ....................... 4-7 Mirrors – Power Electric ......................... 3-5 Mold, Moisture, and Your Motorhome ....................
  • Page 178 Index Roof ..............................11-1 Roof and Ladders ............................ 2-9 Roof Ladder ............................12-8 Safe Use of the Propane Gas System ...................... 5-3 Safety Messages Used in this Manual ....................1-1 Satellite Dish and Cable TV Connections ....................8-7 Sealants – Inspection and General Information ..................11-1 Seat Belts ..............................
  • Page 179 Index TV Signal Amplifier ..........................8-7 Undercarriage ............................11-2 U-Shaped Dinette/Bed Conversion ......................9-8 Utility Light ............................7-3 Vehicle Certification Label ........................1-4 Vehicle Storage – Preparation ......................11-10 Vehicle Storage – Removal ........................ 11-11 Vinyl Flooring ............................11-9 Washer/Dryer – Prep Package ......................4-18 Washer/Dryer –...

Table of Contents

Save PDF