Slideout Room - Winnebago 2004 Chalet Owner's Manual

SECTION 2
DRIVING YOUR MOTOR HOME
TROUBLESHOOTING GUIDE
1. Panel does not function (buttons and lights
on panel do not work and system is not
responding).
• Ignition needs to be on with engine run-
ning.
• Transmission needs to be in park and park-
ing brake applied.
2. Red indicator light will not go out when legs
are retracted.
• Reed switch(es) not grounded.
• Reed switch is defective.
3. The action of one cylinder will not operate in
one direction (i.e. it will go down, but not up,
or vice versa).
• Hydraulic hoses are crossed.
• Wiring connections are crossed.
• Valve not operating.
4. Jacks won't extend after they had been
working previously.
• Directional valve is not shifting positions -
possibly due to foreign object obstructing
the valve itself, or the solenoid is not
working properly.
5. Pump continues to run after switch is
released.
• Pump motor solenoid is stuck - tap sole-
noid to unstick it or replace the solenoid.
This list represents a cross section of some
possible problems and their corresponding solu-
tions. If, after reviewing this manual, you still
have problems or questions in regard to the oper-
ation of the Level Best system, please contact
your Winnebago Industries dealer or the Kwikee
Service Department at 1-(800)-736-9961.

SLIDEOUT ROOM

The slideout living room provides a spacious
living area at the push of a button. The slideout
room is extended and retracted using a motorized
2-16
mechanism with an electronic control system.
The slideout control switch is located near the
leveling system pad on the lower left dash area.
The Kwikee DigiSync slideout room system
uses a digitally synchronized 12 VDC motorized
room mechanism to insure smooth operation and
positive weather seal.
The slideout control switch is located near the
OnePlace monitor panel.
OPERATING SAFETY PRECAUTIONS
Before Extending the Slideout Room:
1. Level the coach and set the Parking Brake.
2. If your coach has a luggage compartment
beneath the slideout room, make sure that the
luggage compartment doors are closed so
that they will not interfere with slideout
operation.
3. Make sure that there are no obstacles on the
outside of the coach that would interfere
with room extension or could be damaged
due to room extension.
4. Unfasten the safety travel straps inside the
coach.
If the slideout room has a couch or other
furniture, make sure no people or pets are seated
on them until the room has been fully extended.
CAUTION
Release slideout room travel straps
before attempting to extend slide-out
room. Fasten travel straps before
driving vehicle. See instructions
below.
TRAVEL STRAPS
The travel latches must be released before
attempting to extend the room or damage to the
coach will result.
The travel straps are designed only to help
keep the room extension secured against the
coach sidewall to maintain an effective weather
seal while the vehicle is in motion. They are not
designed to withstand the force exerted by the
hydraulic extension mechanism and will not
prevent accidental extension of the room.
The travel latches are located near the floor at
the front and rear ends of the slideout room.