Schedules - Perkins WK 1300 Series EDi User Handbook Manual

4

Schedules

The schedules which follow must be applied at the interval (hours or months) which occur first.
A Every day or every 8 hours
B Every 450 hours or 6 months
C Every 900 hours or 12 months
D Every 3600 hours or 24 months
A B C D E F
(1) If one is fitted.
(2) By a person who has had the correct training.
(3) Also if the coolant system has been drained.
(4) The system should be flushed and a new canister fitted.
(5) The oil change interval will change with the sulphur content of the fuel (see the table below and the "Fuel specification" on page
29). The interval to change the canister of the lubricating oil filter is not affected.
(6) Use a suitable test kit.
18
G
Ensure that the coolant is at the correct level
Check the intercooler and the coolant radiator for debris
Check, and adjust if necessary, the antifreeze mixture
Test the level of coolant conditioner, and adjust if necessary
Check the condition of the drive belt
(4)
Renew the coolant
Renew the canister of the coolant filter
Inspect the thermostat
Drain water from the fuel pre-filter
Renew the canister of the fuel filter and renew the fuel strainer
Ensure that the atomisers are checked
Check the amount of lubricating oil in the sump
Check the lubricating oil pressure at the gauge
Renew the engine lubricating oil
Renew the canister of the lubricating oil filter
Clean or renew the air filter element (or earlier if in extremely dusty conditions)
Ensure that the valve tip clearances of the engine are checked and, if necessary, adjusted
Ensure that the turbocharger impeller and the turbocharger compressor casing are cleaned
(2)
Ensure that the alternator, the starter motor, and the turbocharger are checked
Inspect the electrical system
Fuel sulphur content (%)
<0.5
0.5 to 1.0
>1.0
1300 Series EDi Models WK to WS
E Every 5000 hours
F Every 6700 to 7500 hours
G Annually
Operation
(3)
(2)
(1)
(2)
(1)
(5)
(2)
Oil change interval
Normal
75% of normal
50% of normal
(2)
(2)
User's Handbook, TPD 1352E, issue 4
(2)