Modu-Fire ® Forced Draft Boiler Fire Test Report - Harsco Industrial 1004905923 Installation & Owner's Manual

8 MODU-FIRE
Boiler Serial #:
Installation Name:
State:
Installer Name:
1. Factory Fire-Test: (copy from boiler label)
High
Inlet Gas
Oxygen (O2)
Carbon Dioxide (CO2)
Carbon Monoxide (CO)
Stack Temperature
Main Flame Signal
Inlet AirTemperature
Start-Up Field Test: DATE:
High
Inlet Gas
Oxygen (O2)
Carbon Dioxide (CO2)
Carbon Monoxide (CO)
Stack Temperature (net)
Main Flame Signal
Inlet Air Temperature
14. Condensate drain from boiler connected to stack drain with Stainless Steel or High-Temp (500
Performed by:
Additional Comments:
Please return a copy to Harsco Industrial, Patterson-Kelley, ATTN: Boiler Technical Service
Harsco Industrial, Patterson-Kelley 100 Burson Street · E. Stroudsburg, PA 18301
Phone: (570) 476-7261 Fax: (570) 476-7247
®
FORCED DRAFT BOILER FIRE TEST REPORT
®
MODU-FIRE FORCED DRAFT BOILER
START-UP REPORT
Model#:
Address:
Zip:
Type of Installation:
Low
"w.c.
%
%
ppm
° F
Yes/No
° F
Low
"w.c.
%
%
ppm
° F
Yes/No
° F
www.harscopk.com
®
MODU-FIRE Forced Draft Gas-Fired Boiler 2500-3000
Date:
Contact:
2. Sealed Combustion:
2a. Combustion Air Temperature:
"w.c. 2b. Approximate Elevation:
% 3. Water Inlet Temperature:
% 4. Water Outlet Temperature:
ppm 5. Water Flow:
° F 5a. Glycol ?
Yes/No 6. Operating Temperature Setpoint:
(from internal OR external control)
° F
7. Gas Valve a. Low Fire Setting (N)
b. High Fire Setting (V)
8. Approximate Stack Lengths:
9. Stack Pressure (measured where stack exits boiler):
"w.c.
% 10. Electrical Supply Power: L1 to L2
%
ppm Less than 1 volt between neutral and ground: YES or NO
° F 11. Total Cycles:
Yes/No 12. Total Hours:
° F 13. Any Faults? Describe with
code, time and description:
o
F) Silicon piping or tubing, and then trapped: YES or NO
55
City:
Phone:
YES or NO
° F
Ft.
° F
° F
gpm
YES or NO
° F
Ft. Horizontal
Ft. Vertical
Flue Pipe Diameter
"w.c. (High)
"w.c. (Low)
Volts
L1 to N Volts