Troubleshooting Guide; Blown Fuse Or Circuit Breaker; Gate Does Not Open. Agitator Does Not Turn; Gate Does Not Open Or Is Sluggish. Agitator Turns - Cornelius TJ200 Operator's Manual

Should your unit fail to operate properly, check that there is power to the unit and that the hopper contains ice. If
the unit does not dispense, check the following chart under the appropriate symptoms to aid in locating the de-
fect.
Trouble

BLOWN FUSE OR CIRCUIT BREAKER

GATE DOES NOT OPEN. AGITATOR DOES
NOT TURN
GATE DOES NOT OPEN OR IS SLUGGISH.
AGITATOR TURNS.

GATE OPENS. AGITATOR DOES NOT TURN.

ICE DISPENSES CONTINUOUSLY.

SLUSHY ICE. WATER IN HOPPER.

ICE SOLIDIFIED IN HOPPER OR ICE AT
REAR CORNER ONLY.

NO ICE IN HOPPER

ICE PACKED IN HOPPER

BEVERAGES DO NOT DISPENSE.

BEVERAGES TOO SWEET.

BEVERAGES NOT SWEET ENOUGH.

BEVERAGES NOT COLD (UNITS WITH
BUILT-IN COLD PLATE).
Refer to manufacturer's instructions for troubleshooting ice maker.
91678

TROUBLESHOOTING GUIDE

A.
B.
C.
A.
B.
C.
A.
B.
A.
B.
C.
A.
B.
C.
A.
B.
C.
A.
A.
A.
A.
B.
A.
B.
C.
A.
B.
A.
Probable Cause
Short circuit in wiring.
Defective gate solenoid.
Defective agitator motor.
No power.
Bent depressor plate (does not actuate switch).
Defective dispensing switch.
Defective gate solenoid.
Weak gate spring.
Agitator motor protector tripped.
Defective agitator motor.
Defective agitator relay.
Stuck or bent depressor plate (does not release
switch).
Defective dispensing switch.
Improper switch installation.
Blocked drain.
Unit not level.
Ice maker malfunction.
Defective or improperly adjusted ice maker
thermostat.
Ice maker malfunction.
Defective or improperly adjusted ice maker control
(not shutting off).
No 24 Volt power to faucets.
No CO pressure.
2
Carbonator not working.
No CO pressure in carbonator.
2
Faucet brix requires adjusting.
Empty syrup tank.
Faucet brix requires adjusting.
Unit standing with no ice use - no ice in cold plate
cabinet.
10