TUNING THE ENGINE
Checking the play in the throttle cable
15.1
Adjusting the play in the throttle cable
15.2
Setting the engine characteristics (EXC-F SIX DAYS)
15.3
Danger
Loss of approval for road use and insurance coverage The motorcycle is authorized for public road traffic in the homologous
(reduced) version only.
–
In the derestricted version, the motorcycle must be used only on closed off property remote from public road traffic.
–
Check the throttle grip for smooth operation.
–
Move the handlebar to the straight-ahead position. Move the throttle grip back-
wards and forwards to ascertain the play in the throttle cable.
Play in throttle cable
»
If the throttle cable play does not meet specifications:
–
Adjust the play in the throttle cable.
Danger
400192-10
Danger of poisoning Exhaust gases are poisonous and inhaling them may
result in unconsciousness and/or death.
–
When running the engine, always make sure there is sufficient ventila-
tion, and do not start or run the engine in an enclosed space without an
effective exhaust extraction system.
–
Start the engine and let it run idle. Move the handlebar to and fro over the entire
steering range.
The idle speed must not change.
»
If the idle speed changes:
–
Adjust the play in the throttle cable.
x
–
Check the throttle cable routing. (
–
Move the handlebar to the straight-ahead position.
–
Push back sleeves
–
Loosen nut
–
Loosen nut
the throttle grip.
Guideline
Play in throttle cable
–
Tighten nut
101458-10
–
Press and hold the throttle grip in the closed setting. Turn adjusting screw
until there is no play in throttle cable
–
Tighten nut
–
Push sleeves
–
Install the fuel tank.
–
Check the play in the throttle cable. (
–
Remove the seat. (
p. 62)
.
. Turn adjusting screw
in as far as possible.
. Turn adjusting screw
so that there is play in the throttle cable at
.
.
.
on. Check the throttle grip for smooth operation.
x
(
p. 56)
p. 52)
3... 5 mm (0.12... 0.2 in)
(
p. 89)
x
(
p. 89)
x
3... 5 mm (0.12... 0.2 in)
p. 89)
89
out