Disposing Of Batteries; Making Sure Batteries Are Ready For Use; Important Information About Rechargeable Batteries - 3M G5 Operating Instructions Manual

Disposing of Batteries

Making Sure Batteries are Ready for Use

Important Information about Rechargeable Batteries

3M™ Drive-Thru Systems Model G5 and Model XT-1
Operating Instructions
To help protect the environment and conform to regulations, G5 rechargeable
batteries must be returned to 3M at the end of their useful life. Contact your 3M
representative for additional instructions.
Follow these tips to make sure batteries are always ready for use:
•
Recharge a low battery as soon as it is removed from the headset.
When a battery is low, repeat messages are heard in the headset till the
battery's State of Charge (SoC) dips below the critical threshold at
which point the headset shuts off.
•
Keep the battery and charger contacts clean. Use a cotton swab and
approved cleaner in accordance with manufacturer's instructions to
clean the contact surfaces.
•
Remember that a battery recharge takes approximately 3 ½ hours.
•
Remember that batteries discharge fastest during Talk and Page
operation. Avoid unnecessary communications.
Keep the following information in mind as you operate the system and as you
establish operating procedures:
•
Each G5 battery contains an internal protective device to prevent
unsafe discharge rates. But, as with any battery, avoid shorting across
the battery contacts with metal items. Never carry a battery in a pocket
or place it in a drawer where it can accidentally be shorted by keys,
coins etc.
•
Have adequate charging capacity for the number of headsets in your
system.
•
Batteries perform best at moderate temperatures. Extremes of heat and
cold reduce their performance.
•
An unused G5 battery loses five percent of its charge per week.
Batteries that have not been used for several weeks should be recharged
before use.
Each battery has a USE BY label followed by a six character code. The first 2
characters refer to the month and the next four characters refer to the year. Once
the calendar date is past the Use By date of the battery, you should replace that
battery. Batteries are generally usable for two years beyond that date. Batteries
used more often will need replacement sooner.
Do not open, crush, expose to heat above 55ºC/130ºF or incinerate the battery.
WARNING
November 6 2014 – Revision 2.1
Maintenance
Page 51 of 77