Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Cornelius ED 250 BCP
Summary of Contents for Cornelius ED 250 BCP
- Page 1 ® ENDURO ICE/BEVERAGE DISPENSER ED 250 BCP Operator’s Manual Release Date: June 7, 1999 Publication Number: 620916502OPR Revision Date: October 15, 2002 Revision: A Control Code: B Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs.
-
Page 3: Table Of Contents
WARRANTY ............11 © 2001-02, IMI Cornelius Inc. - Page 4 Publication Number: 620916502OPR - ii - © 2001-02, IMI Cornelius Inc.
- Page 5 CONTROL MODULE BEVERAGE FAUCET ON/OFF SWITCH REMOVABLE STRAW MANUAL/AUTO ICE HOLDER PANEL TOGGLE SWITCH LID/STRAW HOLDER CUP REST DRIP TRAY BEVERAGE FAUCETS (8) LOWER ACCESS PANEL FIGURE 1. PARTS IDENTIFICATION © 2002, IMI Cornelius Inc. - 1 - Publication Number: 620916502OPR...
-
Page 6: Start-Up And Operating Instructions
LIGHT Press for extra Indicates mode of ice, then press operation or amount cup size of adjustment CUP SIZE INCREASE DECREASE Small, Medium, Large or X-Large Cup Size Publication Number: 620916502OPR - 2 - © 2002, IMI Cornelius Inc. -
Page 7: Portion Control Panel Operations
1 blink for the shortest refill time-4 blinks for the longest refill. The fac- tory recommendation is 2 blinks. NOTE: Larger ice portions require more time to refill. © 2002, IMI Cornelius Inc. - 3 - Publication Number: 620916502OPR... - Page 8 CAUTION: The gate closes immediately when the toggle switch is moved to the auto position. Do not place fingers or foreign objects into the ice chute when operating the toggle switch. Publication Number: 620916502OPR - 4 - © 2002, IMI Cornelius Inc.
-
Page 9: Maintenance
3. Remove any remaining ice from the cold plate surface and discard. 4. Locate and remove any debris from the cold plate, drain trough and make certain that the drain holes are not clogged. 5. Reinstall the cold platecover. © 2002, IMI Cornelius Inc. - 5 - Publication Number: 620916502OPR... - Page 10 H. Using the mechanical spray bottle filled with sanitizing solution, spray the entire hopper interior, agitator assembly, and hopper lid. Allow to air dry. Replace the lid on the unit. Publication Number: 620916502OPR - 6 - © 2002, IMI Cornelius Inc.
-
Page 11: Beverage System
Submerge all disconnects (gas and liquid) in the soap solution and then clean them using a nylon bristle brush. (Do not use a wire brush). Rinse with clean water. Using a plastic pail, prepare approximately five (5) gallons of sanitizing solution. © 2002, IMI Cornelius Inc. - 7 - Publication Number: 620916502OPR... - Page 12 C supply, then relieve the system pressure before proceeding. If repairs are to be made to the ice dispensing system, make sure electrical power is disconnected from the unit. Publication Number: 620916502OPR - 8 - © 2002, IMI Cornelius Inc.
-
Page 13: Troubleshooting
E. Ice chute cover not properly installed.E. Make sure that cover is “snapped” into place. Defective ice chute interlock switch. F. Replace interlock switch. G. Defective interlock relay. G. Replace relay. © 2002, IMI Cornelius Inc. - 9 - Publication Number: 620916502OPR... - Page 14 AUTOMATIC AGITATION ual” position. position. B. Defective ice gate cylinder. B. Replace cylinder. C. Defective ice gate solenoid valve. C. Replace valve. D. Defective portion controller. D. Replace controller. Publication Number: 620916502OPR - 10 - © 2002, IMI Cornelius Inc.
-
Page 15: Warranty
Enduro Ice/Beverage Dispenser Operator’s Manual WARRANTY IMI Cornelius Inc. warrants that all equipment and parts are free from defects in material and workmanship under normal use and service. For a copy of the warranty applicable to your Cor- nelius, Remcor or Wilshire... - Page 16 Enduro Ice/Beverage Dispenser Operator’s Manual Publication Number: 620916502OPR - 12 - © 2002, IMI Cornelius Inc.
- Page 18 IMI Cornelius Inc. One Cornelius Place Anoka, MN 55303-1592 U.S.A.
Need help?
Do you have a question about the ED 250 BCP and is the answer not in the manual?
Questions and answers