Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Cornelius ENDURO-175
Summary of Contents for Cornelius ENDURO-175
-
Page 1: Installation Manual
INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO--175 8 VALVE Release Date: March 24, 2004 Publication Number: 620917902INS Revision Date: August 3, 2010 Revision: D Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs. -
Page 2: Contact Information
Commercial Warranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal... -
Page 3: Table Of Contents
TABLE OF CONTENTS Safety Instructions ............1 Read and Follow ALL Safety Instructions . -
Page 4: Safety Instructions
Only trained and certified electrical, plumbing and refrigeration technicians should service this unit. ALL WIRING AND PLUMBING MUST CONFORM TO NATIONAL AND LOCAL CODES. FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY, DEATH OR EQUIPMENT DAMAGE. Publication Number: 620917902INS AFETY NSTRUCTIONS Recognize Safety Alerts - 1 - © 2004-2010, IMI Cornelius Inc. -
Page 5: Safety Precautions
NOTE: Many units incorporate the use of additional equipment such as icemakers. When any addition equipment is used you must check with the equipment manufacturer to determine the additional weight the counter will need to support to ensure a safe installation. © 2004-2010, IMI Cornelius Inc. Ice/Beverage Dispenser Installation Manual ARNING... -
Page 6: Description
220--240/1/50/60, 2.0 Amps total unit draw Std unit = 24--1/2 in. Wide X 30--11/16in. Deep Dimensions: High X 35--5/8 in. Z--Model = 24--1/2in. Wide X 23--1/16 in. Deep X 35--5/8 in. High - 3 - © 2004-2010, IMI Cornelius Inc. -
Page 7: Installation Instructions
9. The unit has to be placed in a horizontal position. 10. If the supply cord is damaged, it must be replaced by the manufacturer, it’s service agent or similarly qualified persons in order to avoid a hazard. © 2004-2010, IMI Cornelius Inc. Ice/Beverage Dispenser Installation Manual NSF International... -
Page 8: Adjust Water-To-Syrup Ratio
5. Set a syrup flow adjuster to get the desired ration. 6. Test the valve and adjust until a consistent ratio is delivered three consecutive times. 7. Repeat procedure for other valves. Publication Number: 620917902INS - 5 - © 2004-2010, IMI Cornelius Inc. -
Page 9: Gate Restrictor Plate
This plate may be adjusted as shown to reduce or increase the dispensing rate of ice, especially desirable when using glasses or other containers with small openings. Adjustment can be made by sliding up or down with nuts loosened, to obtain the desired amount of restriction. © 2004-2010, IMI Cornelius Inc. - 6 - Publication Number: 620917902INS... -
Page 10: Figure 2. Mounting Template
Ice/Beverage Dispenser Installation Manual Publication Number: 620917902INS COMMENDED COUNTER OPENING SIZE 9” X 12” FOR UTILITIES AND BEVERAGE TUBING. OPENING CAN BE LOCATED ANYWHERE WITHIN THE SHADED AREA. Figure 2. Mounting Template - 7 - © 2004-2010, IMI Cornelius Inc. -
Page 11: Figure 3. Drip Tray Drain Assembly
Ice/Beverage Dispenser Installation Manual Drip Tray Drain Assembly Figure 3. © 2004-2010, IMI Cornelius Inc. - 8 - Publication Number: 620917902INS... -
Page 12: Figure 4. Flow Diagram (Bc Models With Eight Beverage Faucets)
Ice/Beverage Dispenser Installation Manual FAUCETS VIEWED FROM THIS SIDE Figure 4. Flow Diagram (Bc Models With Eight Beverage Faucets) Publication Number: 620917902INS - 9 - © 2004-2010, IMI Cornelius Inc. -
Page 13: Figure 5. Flow Diagram (B Models With Eight Beverage Faucets)
Ice/Beverage Dispenser Installation Manual Figure 5. Flow Diagram (B Models With Eight Beverage Faucets) © 2004-2010, IMI Cornelius Inc. - 10 - Publication Number: 620917902INS... -
Page 14: Troubleshooting
B. No CO2 pressure in carbonator. C. Faucet brix requires adjusting. A. Empty syrup tank. B. Faucet brix requires adjusting. A. Unit standing with no ice in hopper -- no ice in cold plate cabinet. - 11 - © 2004-2010, IMI Cornelius Inc. -
Page 15: Flavor Syrups Do Not Dispense
FLAVOR DISPENSES MORE THAN .5 OZ Contact your local syrup or beverage equipment distributor for additional information and troubleshooting of beverage system. © 2004-2010, IMI Cornelius Inc. Ice/Beverage Dispenser Installation Manual A. No 24 volt power to PC board. B. No CO2 pressure. -
Page 16: Figure 6. Wiring Diagram (120V)
Ice/Beverage Dispenser Installation Manual Figure 6. Wiring Diagram (120V) Publication Number: 620917902INS - 13 - © 2004-2010, IMI Cornelius Inc. -
Page 17: Figure 7. Wiring Schematic (120V)
Ice/Beverage Dispenser Installation Manual Figure 7. Wiring Schematic (120V) © 2004-2010, IMI Cornelius Inc. - 14 - Publication Number: 620917902INS... -
Page 18: Figure 8. Wiring Diagram (220/240V Uni)
Ice/Beverage Dispenser Installation Manual Figure 8. Wiring Diagram (220/240V UNI) Publication Number: 620917902INS - 15 - © 2004-2010, IMI Cornelius Inc. -
Page 19: Figure 9. Wiring Schematic (220/240V)
Ice/Beverage Dispenser Installation Manual Figure 9. Wiring Schematic (220/240V) © 2004-2010, IMI Cornelius Inc. - 16 - Publication Number: 620917902INS... - Page 21 IMI Cornelius Inc. www.cornelius.com...
Need help?
Do you have a question about the ENDURO-175 and is the answer not in the manual?
Questions and answers