Club Car 1995 Golf Car Maintenance Service Supplement page 9

SYMPTOM
1. Vehicle will not run -
no solenoid "click"
2. Vehicle will not run -
solenoid "clicks"
POWERDRIVE TROUBLE SHOOTING GUIDE
PROBLEM
Batteries
Key Switch
F&R Anti-arcing
Limit Switch
Solenoid
Accelerator
Accelerator Pedal Limit Switch
Diode
Controller Electrical Leakage
On-board Computer
Batteries
Solenoid
F&R Switch
Potentiometer
Controller
Motor
POSSIBLE CAUSES
1) battery connections
2) batteries discharged
1) loose wires
2) failed switch
1) loose wires
2) failed switch
3) cam not activating switch
1) loose wires
2) failed coil
1) accelerator rod disconnected
1) loose wires
2) failed switch
3) improperly wired
1) failed diode
1) dirt or acid residue on
controller
1) battery connections
2) on-board computer
solenoid lockout failure
1) battery connections
2) batteries discharged
1) loose wires
2) failed power
contacts
1) loose wires
2) failed contacts
1) loose wires
2) improperly wired
3) short or open circuit
4) improperly adjusted
1) loose wires
2) defective controller
1) loose wires
2) open/shorted windings
REFER TO
Test Procedure 1
Test Procedure 2
F&R Anti-arcing Limit Switch,
Electrical Components,
Section 17C
Test Procedure 5
Accelerator, Pedal,
& Rod Adjustment
Section 21
Test Procedure 4
Diode, Electrical Components,
Section 17C
Test Procedure 10
Figure 17-1
Test Procedure 11
Test Procedure 1
Figure 17-1 or 17-2
Test Procedure 7
Test Procedure 6
Figure 17-1 or 17-2
Test Procedure 9
Test Procedure 10
Motor, Section 20
17-7