Operating Guidelines - Golden Blount EL GRANDE HD5030-TV Installation And Operating Instructions Manual

1. INSTALL GB DOOR TRACKS AND HINGE SPRINGS AS ILLUS-
TRATED IN (FIGURE 13.1) USING 6 SCREWS IN FIREPLACE
CHASIS.
2. SCREW HANDLES ON TO DOORS.
3. INSTALL DOORS AS SHOWN IN (FIGURE 13.2).
HINGE SPRINGS CAN BE MOVED TO ADJUST DOOR ALIGNMENT.
DOOR LOCKING TABS CAN BE SET BY BENDING UP OR DOWN.
SEE (FIGURE 13.3).
USE MILD SOAP AND WATER TO CLEAN METAL SURFACES.
DO NOT USE BRASS OR ABRASIVE CLEANERS.
ALLOW GLASS TO COOL BEFORE CLEANING.
BURN WITH DOORS ONLY IN FULL OPEN POSITION.
BROKEN OR DAMAGED COMPONENTS NEED TO BE REMOVED
CAREFULLY. BROKEN GLASS OR HARDWARE CAN BE RE-
PLACED BY ORIGINAL FACTORY PARTS ONLY. BROKEN GLASS
MUST BE REPLACED BY COMPLETE FACTORY ASSEMBLED
BIFOLD ONLY.
DO NOT SUBSTITUTE ANY MATERIALS NOT MANUFACTURED
SPECIFICALLY FOR THIS APPLIANCE.
DO NOT STRIKE OR SLAM GLASS DOORS WHEN CLOSING.
DO NOT OPERATE THIS APPLIANCE IF GLASS IS BROKEN.
ALLOW GLASS TO COOL BEFORE CLEANING GLASS PANES. GLASS PANES CAN BE
CLEANED WITH A NON-ABRASIVE GLASS CLEANER.
Upon completing the gas line connection,
a small amount of air will be in the lines.
When first lighting the pilot light, it will
take a few minutes for the lines to purge
themselves of this air. Once the purging
is complete, the pilot and burner will light
and operate as indicated in the instruction
manual. Subsequent lighting of the appli-
ance will not require such purging.
CAUTION: DURING THE INITIAL
PURGING AND SUBSEQUENT LIGHT-
ING, NEVER ALLOW THE GAS VALVE
CONTROL KNOB TO REMAIN DE-
PRESSED IN THE "PILOT" POSITION
WITHOUT PUSHING THE RED IGNITOR
BUTTON AT LEAST ONCE EVERY
SECOND.
OPTIONAL GLASS DOOR INSTALLATION
NOTE!
CAUTION!

OPERATING GUIDELINES

WARNING: CHILDREN AND ADULTS SHOULD
BE ALERTED TO THE HAZARDS OF HIGH
SURFACE TEMPERATURE AND SHOULD STAY
AWAY TO AVOID BURNS OR CLOTHING
IGNITION. YOUNG CHILDREN SHOULD BE
CAREFULLY SUPERVISED WHEN THEY ARE IN
THE SAME ROOM AS THE APPLIANCE.
IMPORTANT: TURN OFF GAS BEFORE SER-
VICING APPLIANCE. IT IS RECOMMENDED
THAT A COMPETENT SERVICE TECHNICIAN
PERFORM THESE CHECKUPS AT THE BEGIN-
NING OF EACH HEATING SEASON.
WARNING: THE FLOW OF COMBUSTION AND
VENTILATION AIR MUST NOT BE OBSTRUCTED.
13
DOOR TRACK
(TOP)
HINGE SPRING
BRIDGE
DOOR TRACK
(BOTTOM)
FIGURE 13.1
DOOR TRACK
(TOP)
HINGE SPRING
DOOR TRACK
(BOTTOM)
FIGURE 13.2
FIGURE 13.3
CLIP