Casablanca Ceiling Fans Owner's Manual

Ceiling fans
Hide thumbs Also See for Ceiling Fans:

Advertisement

V
Safety and the proper operation of your Casablanca fan both require a thorough knowledge
of the product and proper installation; therefore, before attempting to install and operate your
Casablanca fan, read this owner's manual completely and carefully. Retain this manual for
future reference.
CAUTION: To avoid possible electrical shock, make certain that electricity is turned off
at the circuit breaker or fuse box before attempting any installation procedure.
Parts List ��������������������������������������������������������������������������3
Introduction �����������������������������������������������������������������������5
Before You Start ������������������������������������������������������������������������������������������������������������������������������������������������ 5
Safe Use ������������������������������������������������������������������������������������������������������������������������������������������������������������ 5
Mounting Recommendations �������������������������������������������������������������������������������������������������������������������������� 6
Sloped Ceiling Installation ������������������������������������������������������������������������������������������������������������������������������� 6
Fan Installation ��������������������������������������������������������������������7
Getting Started �������������������������������������������������������������������������������������������������������������������������������������������������� 7
Mounting Bracket Installation �������������������������������������������������������������������������������������������������������������������������� 7
Pipe Scroll Hardware ���������������������������������������������������������������������������������������������������������������������������������������� 8
Decorative Scroll Assembly ���������������������������������������������������������������������������������������������������������������������������� 8
10' Ceiling Installation �������������������������������������������������������������������������������������������������������������������������������������� 9
8' Ceiling Installation ��������������������������������������������������������������������������������������������������������������������������������������� 11
Hanging the Fan �����������������������������������������������������������������������������������������������������������������������������������������������12
Wiring ���������������������������������������������������������������������������������������������������������������������������������������������������������������13
Securing the Canopy ���������������������������������������������������������������������������������������������������������������������������������������15
Blade Installation ���������������������������������������������������������������������������������������������������������������������������������������������16
Light Kit Installation �����������������������������������������������������������������������������������������������������������������������������������������17
W-74 Wall Control Preparation ������������������������������������������������������������������������������������������������������������������������19
W-74 Control Installation ��������������������������������������������������������� 19
Installing the W-74 Wall Control ����������������������������������������������������������������������������������������������������������������������19
Single W-74 Installation �����������������������������������������������������������������������������������������������������������������������������������19
Dual W-74 Installation ������������������������������������������������������������������������������������������������������������������������������������� 20
W-74 Operation ������������������������������������������������������������������ 21
Operation Power ��������������������������������������������������������������������������������������������������������������������������������������������� 21
Operation Speed Control ������������������������������������������������������������������������������������������������������������������������������� 21
Operation Reversing Airflow ������������������������������������������������������������������������������������������������������������������������� 21
Operation CFL Mode �������������������������������������������������������������������������������������������������������������������������������������� 22
Changing Frequency Setting ������������������������������������������������������������������������������������������������������������������������� 22
Operation Lights ��������������������������������������������������������������������������������������������������������������������������������������������� 22
Automatic Demonstration Program �������������������������������������������������������������������������������������������������������������� 23
Operation Safe-Exit® �������������������������������������������������������������������������������������������������������������������������������������� 23
Operation Home-Safe® Program ����������������������������������������������������������������������������������������������������������������� 24
Operation Fan-Minder™ Program ����������������������������������������������������������������������������������������������������������������� 24
Light-minder® Program ��������������������������������������������������������������������������������������������������������������������������������� 24
Troubleshooting Tips ������������������������������������������������������������� 25
Care Recommendations ���������������������������������������������������������� 26
Product Specifications ����������������������������������������������������������� 26
Owner's Manual
icente
READ AND SAVE THESE INSTRUCTIONS!
CONTENTS
P/N C3243001
RL0210
1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Ceiling Fans and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Casablanca Ceiling Fans

  • Page 1: Table Of Contents

    READ AND SAVE THESE INSTRUCTIONS! Safety and the proper operation of your Casablanca fan both require a thorough knowledge of the product and proper installation; therefore, before attempting to install and operate your Casablanca fan, read this owner’s manual completely and carefully. Retain this manual for future reference.
  • Page 2: Parts List

    arts PARTS LIST Parts List Item # Item Name Hanging System Canopy Trim Ring Ceiling Plate Hardware Pack A Wood Screw #10 Wood Screw #8 Washer Screw, 10-32 Receiver 5” Pipe Assembly 13” Pipe Assembly Adaptor Cover Hardware Pack B Set Screw (Pre-Installed) Screw #6-32 X .62 Screw #6-32 X 1.5...
  • Page 3 icente Model # C32G611L Asm. Dwg. # 98973-07 Finish Northern Sienna Qnty Part # 99411-16-000 G0151-03-000 89346-02-000 87942-07-611 87942-64-611 76976-01-611 98968-07-000 G0113-36-000 88828-09-000 G0111-01-000 89440-19-000 G0168-03-000 88829-06-000 G0171-02-000 98969-01-000 G0106-01-611 89350-02-000 65567-01-000 64801-01-232 65520-01-000 76323-01-000 63852-05-000 Call our Support Center toll free at 1-888-227-2178...
  • Page 4 PLEASE INSPECT ALL PACKAGING PRIOR TO DISCARDING! Your Casablanca fan was crafted with pride and care and inspected thoroughly prior to shipment� Before you begin to assemble and install your Casablanca fan, remove all parts from the carton and check them against the Parts Guide in this manual�...
  • Page 5: Introduction

    • This fan is designed to be installed on an existing electrical outlet box. The outlet box must be UL Listed for ceiling fan installations� If it is not, a new box must be installed� Casablanca extension poles are available for sloped or high ceiling installations�...
  • Page 6: Mounting Recommendations

    MOUNTING RECOMMENDATIONS Before mounting your Casablanca fan, read the following helpful recommendations� The location of the fan, air circulation, and fan size are all important factors to consider before installation� Location Ceiling fans have practical uses in almost every room in your home�...
  • Page 7: Fan Installation

    If you do not have an existing fixture located After turning the power OFF at its source (either where you wish to place your Casablanca fan, the circuit breaker or fuse box), lower the old an approved ceiling fixture outlet box must be fixture and disconnect the wiring�...
  • Page 8: Pipe Scroll Hardware

    MOUNTING BRACKET INSTALLATION (CONT.) Step 3. Align the slotted holes in the ceiling plate with the pilot holes you drilled in the wood support structure� For proper alignment use slotted holes directly across from each other� Joist Note: The isolators should be flush against the ceiling�...
  • Page 9: 10' Ceiling Installation

    icente 10' CEILING INSTALLATION Step 1. Remove the Paper Shield from the top of the motor� Step 2. Loosen Set Screw on Motor Adaptor� Step 3. Feed the wires from the top of the fan through the Motor Adaptor Cover and the Scroll Scroll Assembly Assembly�...
  • Page 10 CAUTION: Failure to fully lock in the downrod before securely tightening the set screw may cause the fan to separate from the downrod during normal operation! Step 10. Securely retighten the setscrew on the Motor Adapter� Set Screw Step 11. Align the (5) Scroll Arm with the five holes on top of the motor�...
  • Page 11: 8' Ceiling Installation

    icente 8' CEILING INSTALLATION Step 1. Remove the Paper Shield from the top of the motor� Downrod Step 2. Loosen Set Screw on Motor Adaptor� Step 3. Feed the wires from the top of the fan through the Motor Adaptor Cover, Trim Ring, Canopy Canopy, and downrod�...
  • Page 12: Hanging The Fan

    UP-LIGHT ASSEMBLY Upper Bulb (5) Step 1. Remove each of the 5 Upper Bulbs from their packs and Screw into the Bulb Sockets around the top part of the fan� Note: When replacing bulbs, only replace with max 15 watt bulbs� HANGING THE FAN Step 1.
  • Page 13: Wiring

    icente WIRING HARDWARE Orange Wire Caps (3) Blue Wire Caps (4) Receiver WIRING Power From Line Power Ceiling (IN) Step 1. Locate the White wire marked "NEUTRAL IN" and connect it to the White Neutral Wire from Line Neutral your ceiling using one of the supplied orange wire (IN) caps�...
  • Page 14 Step 6. Connect the White wire marked NEUTRAL OUT from the receiver and connect it to the White White-Neutral Wire coming from the fan with a blue wire cap� to Fan Step 7. Use the Red wire marked FAN OUT from the receiver and connect it to the Red Wire coming from the fan with a blue wire cap�...
  • Page 15: Securing The Canopy

    icente CANOPY HARDWARE Canopy Screw (4) Screw Driver SECURING THE CANOPY Canopy Screws Step 9. Carefully tuck the wires around the Receiver and Hanging Bracket as not to loosen the wire caps� Step 10. Insert 2 Canopy Screws into the Hanging Plate diagonally across from each other so they match the keyholes on the canopy�...
  • Page 16: Blade Installation

    BLADE HARDWARE Blade Screws Blade Iron Blade Washers Blades (5) Blade Irons (5) (21) Screws (11) (21) BLADE INSTALLATION Blade Screw Step 1. Attach a blade to a blade iron by first Blade Washer pressing the blade iron onto the blade, then attaching the blade using 4 blade screws and blade washers as shown in Figure #1�...
  • Page 17: Light Kit Installation

    icente LIGHT KIT HARDWARE Light Kit Screw (4) Light Kit Halogen Mounting Plate Mounting Plate Screw (3) Bulb (2) Lower Glass Light Kit Finial LIGHT KIT INSTALLATION Step 1. To attach the Light Kit Mounting Plate partially install two Mounting Plate screws into the switch housing mounting plate�...
  • Page 18 Step 9. Align the keyhole slots in the Light Kit with the Light Kit Screws and raise the Light Kit� Step 10. Turn the Light Kit clockwise until the Light Kit Screws are firmly situated in the narrow end of the keyhole slots�...
  • Page 19: W-74 Wall Control Preparation

    PC board on the fan� W-74 CONTROL INSTALLATION INSTALLING THE W-74 WALL CONTROL NOTE: W-74 Wall Control should only be installed on Casablanca's Direct-Touch Fans� The wall control installs in the same manner as an ordinary light switch, using an existing wall box and wiring�...
  • Page 20: Dual W-74 Installation

    2 BLACK WIRES W-74 NOTE: The RED wire is not used in this Wall Control application� DO NOT remove the crimped cap from the wire� Connect the green ground wire coming from the back of the W-74 control to the ground wire in the switch box�...
  • Page 21: W-74 Operation

    Direct - Touch W-74 2 BLACK Wall Control 6. Remove the two remaining wires from the three-way WIRES switch� Connect the black wire of these wires to a black wire on the W-74 control� Secure the splice with a wire nut� The remaining red wire is to be connected to the other red wire on the W-74�...
  • Page 22: Operation Cfl Mode

    SET TO ‘111111’ same area and want to control them separately� (Factory Setting) NOTE: DO NOT set dip switch setting in the (Figure 1) remote to ‘0000’, this may cause frequency interference from other Casablanca Products� DIP SWITCHES SET TO ‘000000’...
  • Page 23: Automatic Demonstration Program

    Direct - Touch Turn power OFF at the circuit breaker or fuse box and at the toggle switch, for the fan you want to change� Remove the screws and switch plate from the existing switch box� Remove the screws holding the switch in the switch box� Pull the existing W-74 switch from the switch box to expose the dip switches located on the side of the control as shown in Figure #1�...
  • Page 24: Operation Home-Safe® Program

    LIGHT-MINDER® PROGRAM The Light-Minder Program automatically turns OFF the fan mounted lights after two hours� To enter the Light-Minder Program: 1. To operate the lights for Light Minder Program – Turn the power button off for at least 5 seconds� 2.
  • Page 25: Troubleshooting Tips

    Consult the dealer or an experienced radio/TV technician for help. Note: Any changes or modifications to the transmitter or receiver not expressly approved by Casablanca Fan Company may void one’s authority to operate this remote control�...
  • Page 26: Care Recommendations

    Blades • The blades on this fan have been treated with Casablanca’s Dust Armor protection, making the blades less likely to attract dust and dirt� Use a dry or slightly damp lint free cloth to clean the blades� Do not use a furniture polish or any other cleaners that leave any residue, as they will damage the protective Dust Armor on the blades�...

This manual is also suitable for:

Vicente

Table of Contents

Save PDF