Vermiculite Panel Replacement; Stone - HearthStone hase-Bari 8170 Owner's Manual

V P
ERMICULITE ANEL
1. Remove packing material from spaces along
front edges of the outer left and outer right
panels.
2. Remove the panel lock plate above the outer
right panel.
3. Slide outer right panel slightly to the right, tilt top
into firebox, and remove the panel.
4. Slide all other panels to the right, tilt, and
remove.
5. To remove the upper panel, remove the screw
securing the air tube, slide the air tube to the
left, and remove it. Drop down the upper panel.
6. Install the side panels by placing each one into
the right most position and then slide it to the
left. All side panels are identical.
7. Replace the side panel lock plate.
8. Push side panels together tightly and center
them so the spaces along the front edges are
equal, Insert packing
separation.
9. To install the upper panel, insert the panel rear
edge first into the space below the baffle plate –
hold in place and insert the air tube. Seat air
tube to the right and reinstall screw.
Figure 17: Panel Detail
Hearthstone Quality Home Heating Products, Inc ®
R :
EPLACEMENT
to prevent panel
S
TONE
The stone panels on this stove are large and heavy
(150 pounds total). Use a second person to assist in
mounting the panels to avoid injury, or damaging the
panels. Despite the mass of each piece of
soapstone, they will break if dropped. See the Stone
Install Instructions included with the Stone Kit.
Occasional cleaning is all that is necessary to
maintain the natural beauty of your stove's
soapstone finish. The soapstone pieces have a
smooth, unpolished surface, and will absorb liquids
applied to them. Clean the soapstone only with
water, or any non-abrasive glass cleaner and a soft
cloth. Wipe dust from the stone with a clean cloth.
To avoid staining, do not use chemical agents to
wash the stone; do not use waxes or any polishing
agents on the stone.
Take care not to scratch or chip the soapstone. Do
not set items that can scratch or chip the stone on
top of your stove. You can use 240 grit sandpaper to
easily repair, or blend in minor scratches
Often, with use and over time, subtle earth tones of
brown, green, red, and yellow may appear in the
soapstone. This is a natural reaction in the
soapstone. Surface or hairline fractures may also
appear in the stone after a stove is used. Such
changes are normal and do not affect the operation
or the integrity of the stove and do not require
replacement. If you observe a completely broken
stone, contact your dealer for service.
25
Bari Model 8170