Table of Contents
Advertisement
INSTALLATION AND OPERATING INSTRUCTIONS
PLEASE READ THIS ENTIRE OWNER'S MANUAL BEFORE YOU INSTALL AND USE
CONTACT LOCAL AUTHORITIES HAVING JURISDICTION (BUILDING DEPARTMENT or FIRE
OFFICIALS) ABOUT PERMITS REQUIRED, RESTRICTIONS AND INSTALLATION INSPECTION
IN YOUR AREA.
YOUR NEW Heritage WOOD STOVE. To reduce the risk of fire, follow the installation
instructions. Failure to follow these instructions may result in property damage, bodily injury, or
even death.
SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE!
Non-Catalytic Wood Stove
OWNER'S MANUAL
Heritage
(8021)
Heritage Model# 8021
06-14-05
Advertisement
Table of Contents
Troubleshooting
Related Manuals for HearthStone Heritage 8021
Summary of Contents for HearthStone Heritage 8021
- Page 1 Heritage Non-Catalytic Wood Stove (8021) OWNER'S MANUAL INSTALLATION AND OPERATING INSTRUCTIONS PLEASE READ THIS ENTIRE OWNER’S MANUAL BEFORE YOU INSTALL AND USE CONTACT LOCAL AUTHORITIES HAVING JURISDICTION (BUILDING DEPARTMENT or FIRE OFFICIALS) ABOUT PERMITS REQUIRED, RESTRICTIONS AND INSTALLATION INSPECTION IN YOUR AREA. YOUR NEW Heritage WOOD STOVE.
-
Page 2: Table Of Contents
Gaskets ..................................19 Glass ....................................20 Stone....................................21 Cast Iron ..................................21 TROUBLESHOOTING ......................... 21 ..............................22 ROUBLESHOOTING UIDE & O ........................23 EPLACEMENT ARTS PTIONAL CCESSORIES SAFETY LABEL ............................ 24 HEARTHSTONE WOODSTOVE LIMITED WARRANTIES............25 Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... -
Page 3: Introducing Your Heritage Wood Stove
At 2.2 cubic feet capacity and 2.6 grams per hour particulate you can be proud to join the HearthStone family with our Premier Locate the stove centrally in your living area to allow the Soap Stone Wood Burning Stove. The front and the side heat to travel naturally to distant rooms. -
Page 4: Codes
Keep children and pets away from the stove; they closed tightly. could be burned by touching a hot stove. Inspect the stovepipe, chimney connector and Clean your chimney system as needed. (See page 19) chimney, as recommended. Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... -
Page 5: Periodic Checklist
Optional Equipment Rear Heat Shield 90-68210 completely. The stove should not be fired again until the Outside Air Kit 90-53210 stove, stovepipe, and chimney are all thoroughly Blower 90-57210 Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... - Page 6 HearthStone’s Thermo-Ceramic Baffle System Soapstone Finish Polished Gray Soapstone To enhance the combustion efficiency and reduce the emissions of the fire in your stove HearthStone Castings Finish Painted Matte; and Porcelain QHHP, Inc. developed advanced Enamel (Brown, Sea-foam, Blue-black THERMO-CERAMIC baffle system. This system...
-
Page 7: Setting Up Your Heritage Wood Stove
Heritage Wood Stove NPACKING Clearances To NFPA 211 Protected Surfaces HearthStone Stoves packages your Heritage stove with the greatest care, so that it ships safely. Under certain You can reduce the clearances to combustible surfaces by circumstances, however, damage can occur during transit using any National Fire Protection Agency (NFPA) and handling. -
Page 8: Outside Air Supply
To open the front door, rotate the latch WASHER clockwise to approximately the 10 o’clock position. BOLT According to Intertek Testing Services, Inc. According to ASHRAE Handbook of Fundamentals 1977 HearthStone Quality Home Heating Products Inc ® Heritage Model 8021... -
Page 9: Clearances T O Combustibles
Minimum alcove width Maximum alcove depth Alcove ceiling above stove top MANTLE MANTLE 25" TOP TRIM 1 1/2" TRIM THICKNESS 21" 8" 16" US 18" CAN 3-1/2" SIDE VIEW FRONT VIEW Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... - Page 10 HearthStone Quality Home Heating Products Inc ® Heritage Model 8021...
-
Page 11: Venting Components And Configuration
To protect against the possibility of a house fire, you must You can simplify connecting stovepipe by using properly install and constantly maintain the venting additional accessories such as telescoping pipes, slip- HearthStone Quality Home Heating Products Inc ® Heritage Model 8021... -
Page 12: Connecting Your Wood Stove
Do not install your stove until the chimney is safe for use. Whenever possible, choose an interior chimney. An interior chimney heats up more quickly and retains its HearthStone Quality Home Heating Products Inc ® Heritage Model 8021... - Page 13 Tee Support Bracket Tee clean-out Access door Chimney through outer wall with enclosed chase. One story house installation with attic. Chimney is supported by Tee Support Bracket. Chimney is supported by Ceiling. Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®...
- Page 14 This stove requires a minimum chimney height of 13 feet (4 m). The maximum allowable chimney height is 30 feet structure (9m). 2'-0" 2'-0" MINIMUM MINIMUM 3'-0" 3'-0" MINIMUM MINIMUM 10'-0" Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®...
-
Page 15: Installing I N A Mobile Home
DO NOT INSTALL IN A SLEEPING ROOM ▌ CAUTION: MAINTAIN THE STRUCTURAL INTEGRITY OF THE MOBILE HOME WALLS, FLOOR, CEILING, AND ROOF WHILE YOUR STOVE IS INSTALLED AND IN USE Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... -
Page 16: Operating Your Heritage Wood Stove
Once your Heritage has been set in place, connected, and conversely, less air creates a slower burn. To fully open the assembled, you are ready to light a fire. HearthStone primary air intake, move the handle as far as it will go to Stoves tests each wood stove before we ship, so you should the left;... -
Page 17: Choosing Firewood
Do not load wood that is encrusted with ice into a for a mouse to get through, but not for the cat that's chasing burning stove as the thermal shock can cause damage. it." Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... -
Page 18: Building A Break In Fire
Your window may get dirty. A good hot fire will burn or pushing it to the right for a low rate of clean it. We recommend a visual inspection (and cleaning if burn. Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... -
Page 19: Burn Rate
Over-firing means the stove is operating at temperatures slope, which kicks the ashes further into the pan. above the recommended temperatures outlined above in the BURN RATE section. Over-firing should be carefully Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... -
Page 20: Maintenance
35 - 45 minutes daily to burn out creosote deposits from within the stove and the venting system. DOOR: 67" (170 cm) Length, 3/8" (9.5 mm) Diameter, Adhesive Black Tube Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... -
Page 21: Glass
2. Place the door face down on a flat, smooth surface, other than the floor, with the handle hanging over the edge. HearthStone Quality Home Heating Products Inc ® Heritage Model 8021... -
Page 22: Stone
BAROMETRIC PRESSURE: Chimney drafts are once the weather changes. typically sluggish on balmy, wet or muggy days. This is a Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... -
Page 23: Troubleshooting Guide
Do not over-fire the stove. Monitor stove temperatures. Use ENAMEL CASTING seasoned wood only. Excessive Draft Check the DRAFT. A damper may be required. Operate the stove at a LOW BURN range. HearthStone Quality Home Heating Products Inc ® Heritage Model 8021... -
Page 24: Replacement Parts & Optional Accessories
90-68210 HER REAR HEAT SHIELD 1141-240 STONE: POL,4-5/32"x6-11/16",DT/,HER 90-57210 HER BLOWER ASS'Y 1141-242 STONE: POL,2-7/8"x6-11/16",DB/HER 1421-56 STONE: POL,6-11/16"x9-1/2",S/,HER/HAR 1421-58 STONE: POL,8-1/32"x15-5/8",TS/,HER/HA 1141-261 STONE:POL,8-3/32"x8-1/32" TOP CEN. 1141-241 STONE: POL,8-3/8"X10-1/4" SIDE DOOR Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... -
Page 25: Safety Label
FREQUENTLY. UNDER CERTAIN CONDITIONS OF USE, CREOSOTE BUILDUP MAY OCCUR RAPIDLY. U.S. ENVIRONMENTAL PROTECTION AGENCY Certified to comply with July 1, 1990 particulate emissions standards Date of Manufacture 2002 2003 2004 Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®... -
Page 26: Hearthstone Woodstove Limited Warranties
“Original Purchaser”) the new woodstove manufactured by HearthStone and purchased by the Original Purchaser (the “Woodstove”) against any of the occurrences listed in this document that result from defects in material or workmanship. All obligations of HearthStone under this document commence on the date the Original Purchaser purchases the Woodstove (the “Purchase Date”). - Page 27 12. A defect in any part of the Woodstove if the Original Purchaser fails to comply with HearthStone’s or a Dealer’s request to ship the part or the Woodstove to HearthStone or a Dealer, as the case may be.
- Page 28 Woodstove is located. In the event the Original Purchaser refuses to allow a Dealer to make a service call, HearthStone or a Dealer, as the case may be, will request that the Original Owner return the defective part, or the entire Woodstove (if needed), with shipping prepaid, to HearthStone or a Dealer.
- Page 29 Notes: Heritage Model 8021 HearthStone Quality Home Heating Products Inc ®...
Need help?
Do you have a question about the Heritage 8021 and is the answer not in the manual?
Questions and answers