Table of Contents
Advertisement
Heritage IV
(Model 8024)
Woodstove
OWNER'S MANUAL
Installation And
Operating Instructions
SAVE THIS OWNER'S MANUAL
FOR FUTURE REFERENCE
PLEASE READ THIS ENTIRE OWNER'S MANUAL BEFORE YOU INSTALL AND USE YOUR
NEW HERITAGE 8024 WOOD STOVE.
If this room heater is not properly installed, a house fire may result.
To reduce the risk of fire, follow the installation instructions.
Failure to follow these instructions can result in property damage, bodily injury, or even death.
Conforms to UL Std. 1482
Certified to ULC Std. S627
CONTACT LOCAL AUTHORITIES WITH JURISDICTION (BUILDING DEPARTMENT or FIRE
OFFICIALS), ABOUT PERMITS REQUIRED, RESTRICTIONS AND INSTALLATION
INSPECTION IN YOUR AREA.
California Prop 65
WARNING: This product can expose you to
chemicals including glass wool fiber and carbon
monoxide which are known to the State of California to
cause cancer, birth defects or other reproductive harm.
For more information go to www.P65Warnings.ca.gov
Heritage IV (Model 8024)
Manual: 6400-XXXXX
R: 08/16/21
Advertisement
Table of Contents
Troubleshooting
Subscribe to Our Youtube Channel
Related Manuals for HearthStone Heritage IV
Summary of Contents for HearthStone Heritage IV
- Page 1 WARNING: This product can expose you to chemicals including glass wool fiber and carbon monoxide which are known to the State of California to cause cancer, birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov Heritage IV (Model 8024) Manual: 6400-XXXXX R: 08/16/21...
- Page 2 FFICIENCY Rating: You have purchased a Hearthstone Heritage 8024 tested to EPA Method 28R 40 CFR Part 60 where applicable. This stove is certified to comply with the U.S. Environmental Protection Agency 2020 particulate emissions standard using crib wood. It is certified at 0.54 gr/hr.
-
Page 3: Table Of Contents
ASKETS ................................. 30 LASS ..................31 ROUBLESHOOTING ........................... 32 ROUBLESHOOTING UIDE & O ....................34 EPLACEMENT ARTS PTIONAL CCESSORIES ....................35 AFETY ABEL ..................36 IMITED ARRANTY Hearthstone Quality Home Heating Products, Inc ® Page 3 of 39 Heritage 8024... -
Page 4: Introduction
Do not install your stove in a poorly insulated area. This is inefficient and would likely result in higher fuel usage. Hearthstone Quality Home Heating Products, Inc ® Page 4 of 39 Heritage 8024... -
Page 5: Periodic Checklist
(Refer to • Keep a fire extinguisher handy. We recommend page 30.) the type rated "A B C." • Dispose of ashes properly (See page 23). Hearthstone Quality Home Heating Products, Inc ® Page 5 of 39 Heritage 8024... -
Page 6: Emergency Procedures
Inspect the stove, stovepipe, and chimney thoroughly for any sign of damage before firing the stove again. You must correct any damage before using your stove again. Hearthstone Quality Home Heating Products, Inc ® Page 6 of 39 Heritage 8024... -
Page 7: Specifications
10 to 25 lbs. per cubic foot depending on type of wood, moisture content, packing density and other factors. Figure 1 – Heritage 8024 Dimensions Hearthstone Quality Home Heating Products, Inc ® Page 7 of 39 Heritage 8024... -
Page 8: Installation
Consider the location of your stove for 1-617-770-3000 optimum heating efficiency. In general, it is better to www.nfpa.org Illustration 1 – Handle Installation Illustration 2 – Tag Location Hearthstone Quality Home Heating Products, Inc ® Page 8 of 39 Heritage 8024... -
Page 9: Hearth Requirements & F
Minimum hearth pad dimensions can be reduced by installing the Side Door Lock Kit (Kit 90-70210). (Minimum hearth pad width with the lock kit is 37in/94cm USA, 40 ½ in/103cm CAN). Hearthstone Quality Home Heating Products, Inc ® Page 9 of 39... -
Page 10: Combustible Surfacer
If you use a rear heat shield to obtain reduced clearances, you must use the optional rear heat shield manufactured by Hearthstone available through your local dealer. Close clearance connector pipe must be tested to UL standards and listed. Check listings of your pipe for actual clearances. Shown are measurements typical only and specific to Simpson Dura Vent DVL brand. - Page 11 Shield** 10”/26cm 18”/46cm 6”/15cm 18”/46cm 12”/31cm 20”/51cm 8”/21cm 20”/51cm *For double wall pipe clearance to ceiling, refer to pipe manufacturer ** Rear Heatshield, kit #90-68210 specifications. Hearthstone Quality Home Heating Products, Inc ® Page 11 of 39 Heritage 8024...
-
Page 12: Chimney Connectors
24-gauge thickness. Fasteners used to secure chimney section shall not penetrate chimney flue liner. Hearthstone Quality Home Heating Products, Inc ® Page 12 of 39 Heritage 8024... -
Page 13: Outside Air Supply
Hearthstone Quality Home Heating Products, Inc ® Page 13 of 39 Heritage 8024... -
Page 14: Venting Components & C
Where venting requires tighten yet. passage through a wall or partition of combustible construction, the installation must conform to NFPA Code 211 or CAN/CSA - B365. Hearthstone Quality Home Heating Products, Inc ® Page 14 of 39 Heritage 8024... - Page 15 Do not connect this stove to a chimney regulate the draft. The Heritage 8024 requires a draft serving another appliance; you will compromise the between 0.06" and 0.1" WC. For drafts above 0.1" Hearthstone Quality Home Heating Products, Inc ® Page 15 of 39 Heritage 8024...
- Page 16 An oversized filled with vermiculite or suitable material (these keep the liner warmer for better performance) Hearthstone Quality Home Heating Products, Inc ® Page 16 of 39 Heritage 8024...
- Page 17 • At least 3 feet (0.9 m) higher than the highest part of the roof opening through which it passes. Figure 8 – Chimney Height Requirements Hearthstone Quality Home Heating Products, Inc ® Page 17 of 39 Heritage 8024...
- Page 18 Figure 9 – Typical Chimney Configuration Hearthstone Quality Home Heating Products, Inc ® Page 18 of 39 Heritage 8024...
-
Page 19: Installing I N A Mobile Home
Figure 11 – Mobile Home Installation start the room on fire. Hearthstone Quality Home Heating Products, Inc ® Page 19 of 39 Heritage 8024... -
Page 20: Operation
This could overheat and damage the stove. the front lower left of the stove, just under the ash lip. The primary air control allows you to regulate the Hearthstone Quality Home Heating Products, Inc ® Page 20 of 39 Heritage 8024... - Page 21 Figure 16 – Catalyst Probe Hearthstone Quality Home Heating Products, Inc ® Page 21 of 39 Heritage 8024...
- Page 22 (green wood) contains a great deal of Ash, White 3,689 23.6 moisture. As you might expect, green wood burns Birch, Yellow 3,689 23.6 poorly. You must season green wood before using it Hearthstone Quality Home Heating Products, Inc ® Page 22 of 39 Heritage 8024...
-
Page 23: Buildinga Fire
These odors will dissipate over time. You can alleviate these odors by opening a few windows or Hearthstone Quality Home Heating Products, Inc ® Page 23 of 39 Heritage 8024... -
Page 24: Normal Operation
8) Use the primary air control to regulate the desired rate of burn. Pull the handle towards you for a Hearthstone Quality Home Heating Products, Inc ® Page 24 of 39 Heritage 8024... - Page 25 Retain ashes in the closed container until all stove using fuel and following operating procedures coals thoroughly cool. as outlined in this manual should not over-fire. Hearthstone Quality Home Heating Products, Inc ® Page 25 of 39 Heritage 8024...
-
Page 26: Maintenance
-You can get an indication of whether the catalysts are working by comparing the amount of smoke leaving the chimney when the smoke is going through the combustor and catalyst light-off has been Hearthstone Quality Home Heating Products, Inc ® Page 26 of 39 Heritage 8024... -
Page 27: Removing Or Replacing The Removing / Replacing The Rear Baffle
-No metal tools such as gun cleaners should be used. -No detergents or chemicals. Figure 19 – Removing the Middle Air Tube Figure 20 – Installing Gasket on Catalyst Hearthstone Quality Home Heating Products, Inc ® Page 27 of 39 Heritage 8024... - Page 28 (B) 17. Remove the rear baffle. 18. Installation is the reverse of removal. Figure 21 - Acceptable Catalyst Distortion Hearthstone Quality Home Heating Products, Inc ® Page 28 of 39 Heritage 8024...
-
Page 29: Glass Replacementp
Tighten the screws no more than 1/8 of a turn after they seat. The glass will break at this point if not positioned correctly. Hearthstone Quality Home Heating Products, Inc ® Page 29 of 39 Heritage 8024... -
Page 30: Creosote Formation & R
(your dealer only 5mm x 287mm x 457mm Ceramic IR, or may be a certified sweep!). Neoceram IR glass. Contact your Hearthstone dealer. We recommend that before each heating season you have the entire system professionally inspected, cleaned and repaired, if necessary. -
Page 31: Troubleshooting
Opening a window briefly in the room briefly will help quickly get draft established. while lighting the stove may help. Other draft guidelines are as follows: Hearthstone Quality Home Heating Products, Inc ® Page 31 of 39 Heritage 8024... -
Page 32: Troubleshooting Guide
Do not over-fire the stove. Monitor stove temperatures. Use OF FINISH seasoned wood only. Excessive Draft Check the DRAFT. A damper may be required. Operate the stove at a LOW BURN range. Hearthstone Quality Home Heating Products, Inc ® Page 32 of 39 Heritage 8024... - Page 33 Reduce air control settings for a lower burn THE CATALYST periods of time. rate to ensure catalyst temperatures do not exceed the operating range. Hearthstone Quality Home Heating Products, Inc ® Page 33 of 39 Heritage 8024...
-
Page 34: Replacement Parts & O
SIDE DOOR LOCK KIT 90-76240 BAFFLE KIT 90-58313 CATALYST REPLACEMENT KIT Refer to the Illustrated Parts list for further detail about stove components, available online at www.hearthstonestoves.com. Hearthstone Quality Home Heating Products, Inc ® Page 34 of 39 Heritage 8024... -
Page 35: Safety Label
AFETY ABEL Hearthstone Quality Home Heating Products, Inc ® Page 35 of 39 Heritage 8024... -
Page 36: Limited Warranty
This warranty is not transferrable. All obligations of Hearthstone under this document commence on the date of the Original Invoice (the “Purchase Date”). The term “Limited Lifetime” is defined as 10 years from the beginning of warranty coverage. - Page 37 Hearthstone or an authorized Dealer, as the case may be. Notwithstanding any other provision of this document, in no event will Hearthstone pay for any Dealer fees or other fees for pick up or delivery of the appliance returned for repair; the Original Purchaser shall be responsible for any such fees.
- Page 38 10. Consequential damage caused by leaking of condensate during startup 11. A defect in any part of the appliance if the Original Purchaser fails to comply with Hearthstone’s or a Dealer’s request to ship the part or the appliance to Hearthstone or a Dealer, as the case may be.
- Page 39 Dealer on behalf of Hearthstone, as the case may be, will instruct the Original Purchaser to either return the defective part, or the entire appliance (if requested), to the Dealer or Hearthstone or allow a Dealer to make a service call at the place where the appliance is located. Hearthstone may require that a digital picture be provided to support the claim.
Need help?
Do you have a question about the Heritage IV and is the answer not in the manual?
Questions and answers