Table of Contents
Advertisement
Quick Links
9000 Starting Watts/7000 Running Watts
Wireless Remote, Electric Start
PORTABLE GENERATOR
SAVE THESE INSTRUCTIONS
Important Safety Instructions
are included in this manual.
OWNER'S MANUAL & OPERATING INSTRUCTIONS
MODEL NUMBER
41532
MADE IN CHINA
REV 41532-20130219
10006 Santa Fe Springs Road
Santa Fe Springs CA 90670
USA / 1-877-338-0999
www.championpowerequipment.com
Advertisement
Table of Contents
Related Manuals for Champion 41532
Summary of Contents for Champion 41532
- Page 1 9000 Starting Watts/7000 Running Watts Wireless Remote, Electric Start PORTABLE GENERATOR MODEL NUMBER 41532 10006 Santa Fe Springs Road SAVE THESE INSTRUCTIONS Santa Fe Springs CA 90670 Important Safety Instructions USA / 1-877-338-0999 MADE IN CHINA are included in this manual. REV 41532-20130219 www.championpowerequipment.com...
- Page 2 FCC Statement for Remote Control Device 1. This device complies with Part 15 of the FCC Rules. accordance with the instructions, may cause harmful Operation is subject to the following two conditions: interference to radio communications. However, there (1) This device may not cause harmful interference. is no guarantee that interference will not occur in a (2) This device must accept any interference particular installation.
-
Page 3: Table Of Contents
41532 9000 Starting Watts/7000 Running Watts Wireless Remote, Electric Start PORTABLE GENERATOR TABLE OF CONTENTS Introduction ...... -
Page 4: Introduction
ENGLISH INTRODUCTION Introduction Accessories Congratulations on your purchase of a Champion Champion Power Equipment manufactures and sells Power Equipment generator. CPE designs and builds accessories designed to help you get the most from generators to strict specifications. With proper use and your purchase. -
Page 5: Manual Conventions
Please call our help line at 1-877-338-0999 situation which, if not avoided, could result in death or serious injury. CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury. REV 41532-20130219... -
Page 6: Safety Rules
This product contains a button battery. If loss of power would cause you or anyone in your swallowed, it could cause severe injury or death in household to experience a medical emergency. just 2 hours. Seek medical attention immediately. REV 41532-20130219... - Page 7 – Equipment vibrates excessively Operation of this equipment may create sparks that can start fires around dry vegetation. A spark arrestor may be required. The operator should contact local fire agencies for laws or regulations relating to fire prevention requirements. REV 41532-20130219...
-
Page 8: Controls And Features
Battery – Used to start the engine. Provides 12V Air Cleaner – Protects the engine by filtering dust DC to the electric starter and receiver control and debris from the intake air. module. Power Panel – See “Power Panel” section. REV 41532-20130219... -
Page 9: Power Panel
120 Volt AC, 20 Amp Duplex (2) (NEMA 5-20R) – May be used to supply electrical power for the operation of 120 Volt AC, 20 Amp, single phase 60 Hz electrical loads. Ground Terminal – Consult an electrician for local grounding regulations. REV 41532-20130219... -
Page 10: Wireless Remote Control
(6) times. The RCM controls the Auto Choke during each attempt to start. If the generator does not start, call Champion Customer Care team for assistance at 1-877-338-0999. To stop the generator by Remote Control, press the “STOP”... -
Page 11: Parts Included
41532 ENGLISH CONTROLS AND FEATURES Parts Included Your 41532 Gasoline Powered Generator ships with the following parts: Wheel Kit – 10 in. Wheel ...... -
Page 12: Assembly
2. Slide the M10x120 wheel bolt through the washer, sleeve and wheel. 3. Slide the bolt through the mount point on the frame. 4. Fasten securely with the M10 nut. 5. Repeat steps 2-4 to attach the second wheel. REV 41532-20130219... -
Page 13: Add Engine Oil
2. Remove oil fill cap/dipstick to add oil. 3. Add 1.16 qt (1.1 L) of oil (included) and replace oil fill cap/dipstick. DO NOT OVERFILL. 4. Check engine oil level daily and add as needed. REV 41532-20130219... -
Page 14: Add Fuel
WARNING Pouring fuel too fast through the fuel screen may result in blow back of fuel at the operator while filling. REV 41532-20130219... -
Page 15: Operation
During operation the muffler and exhaust fumes produced will become hot. If adequate cooling and breathing space are not supplied, or if the generator is blocked or contained, temperatures can become extremely heated and may lead to fire. REV 41532-20130219... -
Page 16: Wireless Remote And Electric Start
“ON” position, check that the battery connection is still good. NOTE The supplied 12V 15AH battery does re-charge while the engine is running, but it is also recommended that the battery be fully charged at least once per month. REV 41532-20130219... -
Page 17: Connecting Electrical Loads
If the generator will be connected to a building electrical system, consult your local utility company or a qualified electrician. Connections must isolate generator power from utility power and must comply with all applicable laws and codes. REV 41532-20130219... -
Page 18: Do Not Overload Generator
To alleviate high altitude issues other than the natural calculated in step 2. Surge wattage is the extra power loss, Champion Power Equipment can provide a burst of power needed to start some electric driven high altitude carburetor main jet. The alternative main equipment. -
Page 19: Maintenance And Storage
5. Add 1.16 qt (1.1 L) of oil and replace oil fi ll excess oil. cap/dipstick. DO NOT OVERFILL. 6. Dispose of used oil at an approved waste 6. Place the fi lter in the assembly. management facility. 7. Reattach the air fi lter cover and snap in place. REV 41532-20130219... -
Page 20: Spark Arrester
Contact our helpline at 1-877-338-0999 to locate the 3. Remove the spark arrester screen. nearest Champion Power Equipment certified service 4. Carefully remove the carbon deposits from the spark arrester screen with a wire brush. dealer for your generator or engine maintenance needs. -
Page 21: Storage
– Remove batteries from equipment which is not to be used for an extended period of time. – Remove batteries if consumed or if product is to be left unused for a long time. REV 41532-20130219... -
Page 22: Specifications
....5.9 gal. (22.4 L) Your Champion Power Equipment product is designed – Gross Weight ... . -
Page 23: Wiring Diagram
41532 ENGLISH SPECIFICATIONS Wiring Diagram REV 41532-20130219... -
Page 24: Parts Diagram
41532 ENGLISH SPECIFICATIONS Parts Diagram REV 41532-20130219... -
Page 25: Parts List
Washer Ø10 5.1280.003 Fuse (10a) 153.191100.02 Rotor Assembly 5.1830.001 Remote Control Module 152.192300.00 Air Guide 120 5.1040.004 Switch 152.190005.00 Rubber,Fore-Cover 5.1460.003 Indicator Light 152.190005.01 Rubber,Fore-Cover 122 152.210002.11 Control Box 47.602 Engine 123 5.1820.000 Charger 152.200702.02 Cover,Handle 152.200701.02 Handle REV 41532-20130219... -
Page 26: Engine Parts Diagram
41532 ENGLISH SPECIFICATIONS Engine Parts Diagram REV 41532-20130219... -
Page 27: Engine Parts List
Stud.Bolt (M8×34) 120 1.823.0408 Screw M4×8 2.15.002 (F6RTC) Spark Plug (F6RTC) 81.132001.00 Cover, Stepper Motor 2.08.014 Flange Bolt 10×80 122 46.091000.03 Air Cleaner Assembly 46.020002.00 Gasket, Cylinder Head Cover 123 46.061000.00 Recoil Assembly 47.021000.00 Cylinder Head Cover (CPE) REV 41532-20130219... -
Page 28: Troubleshooting
Review load and adjust. See “Power Management” Faulty cords or device Check for damaged, bare or frayed wires. Replace defective device For further technical support: Technical Service Mon – Fri 8:30 AM – 5:00 PM (PST/PDT) Toll Free: 1-877-338-0999 tech@championpowerequipment.com REV 41532-20130219... -
Page 29: Warranty
Warranty Qualifications Other Exclusions Champion Power Equipment (CPE) will register this This warranty excludes: warranty upon receipt of your Warranty Registration Card – Cosmetic defects such as paint, decals, etc. - Page 30 The United States Environment Protection Agency (U.S. EPA.) and the California Air Resources Board (CARB) Emission Control System Warranty Your Champion Power Equipment (CPE) engine complies with both the U.S. EPA and state of California Air Resources Board (CARB) emission regulations.
- Page 31 EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System (ECS) Warranty Coverage. 1. APPLICABILITY: This warranty shall apply to 1995 and later model year California small off-road engines (for other states, 1997 and later model year engines). The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter.
- Page 32 You must take your CPE engine or the product on which it is installed, along with your warranty registration card or other proof of original purchase date, at your expense, to any Champion Power Equipment dealer who is authorized by Champion Power Equipment, Inc. to sell and service that CPE product during his normal business hours.