Front Brake - APRILIA RSV MILLE R TUONO - 2003 Manual

FRONT BRAKE

CHECK
◆
Position the vehicle on the stand, see p.
82 (POSITIONING THE VEHICLE ON
THE STAND).
◆
Turn the handlebar completely rightwards.
◆
Make sure that the fluid level exceeds
the "MIN" mark.
MIN= minimum level
MAX= maximum level
If the fluid does not reach at least the "MIN"
mark:
When the disc pads wear out, the level
of the fluid decreases progressively to
compensate for their wear.
◆
Check the brake pad wear, see p. 118
(CHECKING THE BRAKE PAD WEAR)
and the disc wear.
If the pads and/or the disc do not need
replacing, provide for topping up.
58
use and maintenance RSV mille TUONO
TOPPING UP
Carefully read p. 56 (BRAKES).
The brake fluid may flow out of the tank.
Do not operate the front brake lever if
the screws (1) are loose or, most
important, if the brake fluid reservoir
cover has been removed.
◆
Unscrew the two screws (1) of the brake
reservoir (2) by means of a short, cross-
headed screwdriver.
Avoid any prolonged exposure of the
brake fluid to the air.
The brake fluid is hygroscopic and
when in contact with the air it absorbs
its humidity.
Leave the brake fluid tank open ONLY
for the time necessary for topping up.
- RSV mille R TUONO
◆
Raise and remove the cover (3) together
with the screws (1) and the gasket (4).
In order not to spill the brake fluid while
topping up, do not shake the vehicle.
Do not put additives or other subtances
into the fluid.
If you use a funnel or other similar
items, make sure that they are perfectly
clean.
◆
Fill the tank (2) with brake fluid, see p.
1 4 4 ( L U B R I C A N T C H A R T ) , u n t i l
reaching the correct level between the
"MIN" and "MAX" marks.
Do not exceed the "MAX" level while
topping up.
It is advisable to top up until reaching
the "MAX" level only with new pads.
Do not reach the "MAX" level with worn
out pads, since this will cause a fluid
outflow when the pads are changed.
Check the braking efficiency.
In case of excessive stroke of the brake
lever or reduced efficiency of the
braking system, contact your local
a p r i l i a D e a l e r , s i n c e i t m a y b e
necessary to bleed the system.