Cornelius beverage dispenser illustrated parts list (11 pages)
Summary of Contents for Cornelius Ice Cooled Dispensers
Page 1
® ICE COOLED DISPENSERS Operators Manual Release Date: October 8, 2003 Publication Number: 166239002 Revision Date: July 12, 2010 Revision: B Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs.
Product and is subject to all of the restrictions and limitations contained in the Commercial War- ranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than...
Displaces Oxygen. Strict Attention must be observed in the prevention of CO and soft drink system. If a CO gas will experience tremors which are followed rapidly - 1 - Ice Cooled Dispensers Operators Manual gas leak is suspected, particularly in a Publication Number: 166239002...
Ice Cooled Dispensers Operators Manual HIPPING TORAGE CAUTION — Before shipping, storing, or relocating the Unit, syrup systems must be sanitized and all sanitizing solution must be purged from the syrup systems. All liquids, after sanitizing, must be purged from the unit. A freezing ambient environment will cause residual sanitizing solution or water remaining inside the Unit to freeze resulting in damage to the internal components.
SYSTEM OVERVIEW This manual applies to all models of drop-in and free-standing ice cooled dispensers. ECOMMENDED AINTENANCE Details of each task are listed immediately below the chart. Refer to the details by task number. Task Clean all exterior surfaces Clean dispensing valves, Post-Mix Clean dispensing valves, Pre-Mix Clean &...
Ice Cooled Dispensers Operators Manual Cleaning Dispensing Valves, Post-Mix 1. Remove the valve cover(s) and wash in plain water. 2. Remove the nozzle and the syrup diffuser and wash the parts in plain water. IMPORTANT: When washing the dispensing valve, care must be taken not to get water on the electrical solenoid.
Page 10
For each 10 ft. of horizontal tubing between tank and dispenser For each 2 ft. of elevation For each tank per flavor over 3 tanks Basic pressure shown is based on ambient temperature of 72_F. Use a Cornelius Pre-Mix slide rule for exact calculations. Publication Number: 166239002 Post-Mix...
Ice Cooled Dispensers Operators Manual TROUBLESHOOTING Trouble WATER-TO-SYRUP A. Dispensing valve syrup flow reg- “RATIO” TOO LOW OR TOO HIGH B. CO ADJUSTMENT OF DIS- A. Dispensing valve syrup flow reg- PENSING VALVE SYRUP FLOW REGULATOR DOES NOT INCREASE B. Syrup tank quick disconnects not TO DESIRED WATER- TO-SYRUP ‘‘RATIO’’...
Page 14
Ice Cooled Dispensers Operators Manual Trouble NO PRODUCT DIS- A. Broken or disconnected wiring. PENSED FROM ONE B. Inoperative dispensing valve DISPENSING VALVE. C. Inoperative dispensing valve ONLY CARBONATED A. Quick disconnects not secure on WATER DISPENSED. B. Out of syrup.
Need help?
Do you have a question about the Ice Cooled Dispensers and is the answer not in the manual?
Questions and answers