Putting Into Use For The First Time - Hyundai 12ESH Operation Manual

platform, make sure that the lift or platform has adequate bearing capacity, their structures are suitable for the stacker,
and that you've acquired permission from user of equipment. Make inspections before operations. When the stacker
enters lift, let cargo enter first. Choose a proper parking position to avoid collision with walls. If any personnel should use
the lift at the same time, he or she shall not enter until the stacker has been parked well. When reaching the determined
height, the personnel should leave the lift first.
14）Conditions for the cargo under transportation: driver of stacker must inspect the cargo carefully to avoid danger.
Before transporting, arrange the cargo carefully and fasten it. If the cargo is endangered with overturning or falling
during transportation, proper protective devices (such as guardrail) shall be installed.
3.4 Precautions after work
1） Parking: park the truck in the appointed place; do not park on a ramp.
Do the following items before leaving the truck:
Lower the forks naturally to the lowest position;
a)
b) Make the steering wheels to the neutral position;
Turn off the key switch.
c)
2）T ruck cleaning:
When cleaning the electrical system of the truck, use compressed air; never use
water to clean the electrical system.
3）Charging:
Open flame is not allowed in the charging area, otherwise it will lead to explosion
or fire.
Keep good records of the charging conditions. For charging methods, please refer to the storage battery
operation part.

4. Putting into Use for the First Time

4.1 Putting into use for the first time:
4.1.1 To achieve power disconnect in emergencies, the battery plug (not included in the delivery) shall be connected with
the emergency stop plug of the electric truck.
4.1.2 The stacker shall only be driven by battery power. Rectified AC power will damage the truck and its electronic
components. Length of battery cable shall not exceed 6m.
4.13 Never lift the load capacity when the stacker is driven by an external battery.
4.14 When you have received the stacker or the stacker has been transported, conduct the following inspections
before putting it into use:
Attention
Warning
Warning
The electric truck shall not operate when there is no emergency stop plug.
8