Related Manuals for Feider Machines FGH3500
Summary of Contents for Feider Machines FGH3500
- Page 1 ORIGINAL INSTRUCTIONS > EN LOW POWER DUAL FUEL GENERATOR MODEL: FGH3500 BUILDER SAS ZI -32, rue Aristide Bergès, 31270 Cugnaux, France Made in P.R.C. 2022 Warning: Please read the manual carefully before using the unit!
-
Page 2: Table Of Contents
ORIGINAL INSTRUCTIONS > EN CONTENTS 1. SAFETY INSTRUCTIONS........................... 3 2. COMPONENT IDENTIFICATION........................7 3. ASSEMBLY................................8 4. OPERATION................................ 13 5. MAINTENANCE AND STORAGE........................17 6. SPECIFICATIONS.............................. 21 7. TROUBLESHOOTING............................22 8. DECLARATION OF CONFORMITY........................ 23 9. WARRANTY.................................24 10. PRODUCT FAILURE............................25 11. WARRANTY EXCLUSIONS........................... 26... -
Page 3: Safety Instructions
ORIGINAL INSTRUCTIONS > EN 1. SAFETY INSTRUCTIONS The operator must know the principles of functioning and the structure of the generator and the motor. He must know how to stop the motor in case of urgency and how to manipulate the controls. - Page 4 ORIGINAL INSTRUCTIONS > EN Do not use in wet condition. Keep in flammable away. Warning: when you start the generator with the cord, watch out for sudden changes in the rotation of the motor!!! Risk of wounding!!! ...
- Page 5 ORIGINAL INSTRUCTIONS > EN Always stop the motor of the generator when filling it with fuel. Never fill the fuel tank while smoking or near a naked flame. Make sure you don’t spill fuel on the motor and the exhaust grille of the generator during filling with fuel.
- Page 6 ORIGINAL INSTRUCTIONS > EN FUEL SAFETY DANGER! GASOLINE, GASOLINE VAPORS AND LIQUID PETROLEUM GAS (LPG: with Propane) ARE HIGHLY FLAMMABLE AND EXPLOSIVE. Fire or explosion can cause severe burns or death. Unintentional startup can result in entanglement, traumatic amputation or laceration. Gasoline and Gasoline Vapors (Gas): GAS IS HIGHLY FLAMMABLE AND EXPLOSIVE.
-
Page 7: Component Identification
ORIGINAL INSTRUCTIONS > EN Ground connection It is forbidden to run the generator in an enclosed room because exhaust emissions can lead humans or animals to coma to death. This symbol indicates the surface is very hot and not touching Keep away from the machine Exhaust emissions are harmful to health of body No naked fire near the machine! -
Page 8: Assembly
ORIGINAL INSTRUCTIONS > EN ( 7 ) Battery- Used to start the engine electrically ( 8 ) Power Panel- See " Power Panel " section ( 9 ) Fuel Selector Switch- Used to select fuel source 3. ASSEMBLY Your generator requires some assembly. This unit is shipped from our factory without oil. It must be properly serviced with fuel and oil before operation. - Page 9 ORIGINAL INSTRUCTIONS > EN Handle Place the handle over the mounting channel on the frame Secure the handle to the frame using the two flange bolts(M8x45) Place a flange lock nut on the end of each bolt and fasten seurely. DO NOT over tighten the flange lock nuts Connect the Battery 1.
- Page 10 ORIGINAL INSTRUCTIONS > EN NOTE: Recommended oil type is 10W-30 automotive oil. 1. Place the generator on a flat, level surface. 2. Remove oil fill cap/dipstick to add oil. 3. Add 0.6L of oil and replace oil fill cap/dipstick. DO NOT OVERFILL. 4.
- Page 11 ORIGINAL INSTRUCTIONS > EN NOTE Weather will affect engine oil and engine performance. Change the type of engine oil used based on weather conditions to suit the engine needs. NOTE Synthetic oil may be used after the 5-hour initial break-in period. Using synthetic oil does not increase the recommended oil change interval.
- Page 12 ORIGINAL INSTRUCTIONS > EN It is advisable to always shut off the fuel supply, run the engine to fuel starvation and drain the tank when the equipment is not in use for more than 30 days. with Propane Connecting Liquid Petroleum Gas (LPG: ) Cylinder 1.
-
Page 13: Operation
ORIGINAL INSTRUCTIONS > EN WARNING: Failure to properly ground the generator can result in electric shock. A ground terminal connected to the frame of the generator has been provided on the power panel. For remote grounding, connect of a length of heavy gauge (12 AWG minimum) copper wire between the generator ground terminal and a copper rod driven into the ground. - Page 14 ORIGINAL INSTRUCTIONS > EN Once a fuel source has been selected, the user must turn the fuel valve to the vertical position to open the fuel valve. (1) To turn a fuel valve to the off position the valve must be in the horizontal position. (2) NOTE The fuel selector switch cover is specifically designed not to slide to either side while a specific fuel has been selected and the valve is in the “ON”...
- Page 15 ORIGINAL INSTRUCTIONS > EN NOTE: Keep choke lever in “Choke” position for only 1 pull of the recoil starter. After first pull, move choke lever to the “Run” position for up to the next 3 pulls of the recoil starter. Too much choke leads to sparkplug fouling/engine flooding due to the lack of incoming air.
- Page 16 ORIGINAL INSTRUCTIONS > EN NOTE: When the battery switch is in the “ON” position, the switch will light up if the battery is sending out a charge. If the switch does not light up while in the “ON”position, check that the battery connection is still good.
-
Page 17: Maintenance And Storage
ORIGINAL INSTRUCTIONS > EN with indication of a problem with the generator but only a problem with the flow of gas from the LPG( Propane ) container. If generator performance seems to be deteriorating at the same time that ice formation is observed on tank valve, hose or regulator then some actions may be taken to eliminate this symptom. - Page 18 ORIGINAL INSTRUCTIONS > EN NOTE: Once oil has been added, a visual check should show oil about 1-2 threads from running out of the fill hole. If using the dipstick to check oil level, DO NOT screw in the dipstick while checking. Spark Plugs 1.
- Page 19 ORIGINAL INSTRUCTIONS > EN 6. Position the spark arrester in the muffler and attach with the three screws CAUTION: Failure to clean the spark arrester will result in degraded engine performance Cleaning CAUTION: DO NOT spray engine with water. Water can contaminate the fuel system Use a damp cloth to clean exterior surfaces of the engine.
- Page 20 ORIGINAL INSTRUCTIONS > EN Every 250 hours Clean combustion chamber* Every 3 years with Propane Replace fuel line and LPG( ) hose *To be performed by knowledgeable, experienced owners or Hyundai certified dealers. Generator Maintenance Make certain that the generator is kept clean and stored properly. Only operate the unit on a flat, level surface in a clean, dry operating environment.
-
Page 21: Specifications
ORIGINAL INSTRUCTIONS > EN screw (M5x10) and nut (M5) 3. Repeat steps 1-2 for the red / positive battery lead 4. Store the battery in a cool, dry place. Charge the Battery For a generator equipped with batteries for electric starting, proper battery maintenance and storage should be followed, An automatic battery charger (not included with automatic trickle charging capability should be used to charge the battery, Maximum charging rate should not exceed 1.5 amps. -
Page 22: Troubleshooting
ORIGINAL INSTRUCTIONS > EN & hose of Capacity: 1,5 kg/h with Outlet pressure: 37 Mbar LPG( With French instruction NF approval Propane Hose NF gas hose in rubber acc.to NF XPD36- 112 Length=0.75M With REACH certificate phthalate concentration+/-5% Spark Plugs OEM spark plug: NHSP F6RTC Replacement spark plug: NGK BPR6ES or equivalent Make certain the spark plug gap is 0.7 - 0.8 mm or (0.028 - 0.031 in.). -
Page 23: Declaration Of Conformity
ZI, 32 RUE ARISTIDE BERGES – 312070 CUGNAUX – FRANCE Declares that the machinery designated below: LOW POWER DUAL FUEL GENERATOR Model: FGH3500 Serial number: 20221229055-20221229104 Complies with the provisions of the Directive “machinery” 2006/42/CE and national laws transposing it:... -
Page 24: Warranty
9 . WARRANTY WARRANTY The manufacturer guarantees the product against defects in material and workmanship for a period of 2 years from the date of the original purchase. The warranty only applies if the product is for household use. The warranty does not cover breakdowns due to normal wear and tear. The manufacturer agrees to replace parts identifed as defective by the designated distributor. -
Page 25: Product Failure
1 0 . PRODUCT FAILURE WHAT TO DO IF MY MACHINE BREAKS DOWN? If you bought your product in a store: a) Empty the fuel tank if your product has one. b) Make sure that your machine is complete with all accessories supplied, and clean! If this is not the case, the repairer will refuse the machine. -
Page 26: Warranty Exclusions
11. WARRANTY EXCLUSIONS THE WARRANTY DOES NOT COVER: • Start-up and setting up of the product. • Damage resulting from normal wear and tear of the product. • Damage resulting from improper use of the product. • Damage resulting from assembly or start-up not in accordance with the user manual. •...