Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Feider Machines FG1600i-A
Summary of Contents for Feider Machines FG1600i-A
- Page 1 PETROL INVERTER GENERATOR (LOW GENERATING SET) ORIGINAL INSTRUCTION MANUAL MODEL: FG1600i-A Warning: read the following instructions before using the machine BUILDER SAS ZI – 32, rue Aristide Bergès, 31270 Cugnaux, France Made in P.R.C. 202 1...
- Page 2 1. SAFETY INSTRUCTION Warning: 1. Attention! Exhaust gases are toxic. Do not operate the generator in a room without ventilation system! 2. Children should be protected by keeping them at a safe distance from the generator set! 3. Refilling of the generating sets are not allowed during the operation! 4.
- Page 3 Perform periodic maintenance and resolve problems that appear immediately. Do not run the generator before correcting any fault detected. The generator uses a system of air-cooling, and it is necessary to clean its components regularly, including the grilles, the cover of the fan and the fan itself so as to ensure cooling. ...
- Page 4 The user shall conform to regulations of electrical safety applicable to the place where the generating sets are used. The user must respect the requirements and precautions in the case of resupply by generating sets of an installation, depending on existing protective measures in this installation and applicable regulations.
- Page 5 Connect the generator to earth. Use a sufficiently thick conductor for the earth wire. Do not operate the generator in parallel with another generator. If using electrical extensions, make sure that they are sufficiently thick to transport the current and that they are used correctly.
- Page 6 Do not dispose of old appliances with domestic rubbish . Guaranteed sound power level Ground connection Fill in engine oil It is forbidden to run the generator in an enclosed room because exhaust emissions can lead humans or animals to coma to death. This symbol indicates the surface is very hot and not touching Keep away from the machine...
-
Page 7: Quick Start
Quick Start WARNING Only use outdoors . The generator emits carbon monoxide, a toxic colorless and odorless gas that can cause death or serious injury. Ensure that the generator is placed horizontally. Never work in the rain, snow or other humid environment. ... -
Page 8: Start The Generator
Forewords Thank you for Choosing our generator. This manual includes the operation and maintenance of Model FG1600I-A series inverter generator. All contents of this manual are consistent with the latest products (when this manual is printed). Our company reserves the right to make changes without notice and without any liability. -
Page 9: Safety Label Location
As long as following the instructions in this manual, the generators are safe and reliable. Be sure to read and understand the instructions before use, otherwise the wrong operation will result in personal injury or equipment damage. Generator specification： Model FG1600i-A Rated voltage（V） Rated frequency（HZ） Rated current（A）... -
Page 10: Parts Identification
Parts Identification The configurations of control panel might be different. Fuel Cap Handle Control Panel Fuel tank Exhaust port Feet... -
Page 11: Control Panel
Engine Oil filler Air filter Oil Switch Choke Cable Control Panel Overload light AC SOCKET Output indicate Fuel alert indicate DC protect Starting swithing DC output ECO switch Earth stud Check before Operation BE CAUTIOUS Be sure to check whether the generator is placed horizontally, and the engine is off. ... - Page 12 SEA viscosity grade as follows： Loosen the screw on the side maintenance cover to remove the cover. Remove the oil dipstick, wipe the dipstick with a clean cloth, insert it into the oil port without tightening the dipstick to check the oil level. If the oil level is below the bottom of the dipstick, add the recommended oil.
-
Page 13: Check The Fuel Level
Check the Fuel Level Use automotive gasoline (preferably unleaded or low-lead gasoline to reduce combustion chamber carbon and reduce environmental pollution). When the fuel level is too low, please add fuel to the required level. Never use a mixture of oil and gasoline or dirty gasoline. Prevent dirt, water into the fuel tank. -
Page 14: Air Filter
Air filter sponge Air filter cover BE CAUTIOUS Never run the engine without a filter, or dirt will enter the engine through the carburetor and cause rapid wear of the engine. Start the Engine Recoil Start Disconnect the load from the socket before starting the generator. 1. - Page 15 Turn the power switch to “ON” position. 3. Turn the throttle arm to “OFF” position. BE CAUTIOUS Please turn the throttle arm to the “OFF” position or move the throttle arm to the 1/3 ~1/2 position according to the temperature of the engine. ...
- Page 16 BE CAUTIOUS Never allow the starting handle to rebound. Slowly put it back. When pulling the cable, hold the generator tightly to prevent the generator from overturning. Starting handle 5. After the generator is started, preheat the generator, then slowly turn the throttle arm to the “OPEN” position. Working at high altitudes In high altitude areas, the air-fuel mix in a standard carburetor is relatively thick, so the engine operating performance will reduce, while the fuel consumption increases.
-
Page 17: Operating The Generator
Operating the Generator WARNING In order to prevent electric shock caused by improper use, the generator should be grounded. Connect a thick cable between the ground terminal of the generator and the external ground source. If the unit is used as a backup power source for a building, the connection of the generator to its power system shall be carried out by a professional electrician and must comply with the applicable laws and regulations. - Page 18 Use of AC Power Connect the ground bolt. Ground symbol Start the engine in accordance with the “Start the Engine” requirements. Make sure the connected device is turned off, then connect the device to the generator. When the power indicator (green) is on, turn on the connected device. BE CAUTIOUS ...
- Page 19 When overloaded or short-circuited (red) Power output (green) Power indicator, Overload indicator and Oil alarm indicator： Under normal operating conditions, the power output indicator (green) is on. If the generator is overloading or the connected device is internally faulty, the power indicator (green) will go off and the overload indicator (red) will light up and there is no power output.
- Page 20 When using the generator with a pure inductive load, the pure inductive load cannot exceed the rated power of the generator. The power can only run 40% to 75% of rated power on pure inductive load. Model FG1600i-A Rated Power (W) 1000 Frequency（Hz）...
- Page 21 1. Connect the charging cable to the generator DC socket and connect it to the battery terminal Charging Cable WARNING Connect the charging cable to the battery first, and then connect it to the generator. Disassembly must start from the generator side, which prevents sparks start beside the battery. When connecting the charging cable to the car battery, disconnect the battery ground wire first.
- Page 22 DC protector When using AC power, you can have use DC output. The DC circuit overload may cause DC protection. And the switch should be reset. DC protector Rated Power Output Conditions of the Generator The oil alarm system is designed to prevent damage to the engine due to insufficient oil. The oil alarm system automatically shuts down the engine before the oil in the crankcase drops to the safety line (although the start switch remains in the "on"...
- Page 23 2. Turn the switch to “STOP” position. Switch 3. Turn the oil switch to “OFF” position. When not using the generator for a long time, please turn off the generator. Turn off...
-
Page 24: Maintenance
Maintenance Maintenance and adjustment schedules are developed to keep the generator in the best working condition. WARNING Turn off the engine before any maintenances. If the engine must be operated during maintenance, be sure to operate it in a ventilated area because the exhaust contains toxic carbon monoxide. NOTICE ... - Page 25 a. Loosen the oil drain screw, drain the oil. b. Install back the oil drain screw. c. Fill the recommended oil, check the oil level. d. After filling a new oil, shake the generator about a few times to ensure that the float of the oil alarm system works properly.
- Page 26 Maintenance of Air Filter The dirty air filter will block the air into the carburetor. To prevent the carburetor from malfunctioning, check the air filter following the maintenance schedule. If you use the generator in a particularly dirty place, you need to keep the maintenance regularly. WARNING Do not use gasoline or low-ignition solvents to clean the generators because they are flammable and explosive under certain conditions.
- Page 27 Spark plug removal tool Ignition coil...
- Page 28 4) If the insulator has been ruptured, it must be scrapped. If you want to use the spark plug again, use a brush to clean the spark plug. 5) Measure the spark plug clearance with a feeler gauge, and the spark plug clearance should be 0.6-0.7mm (0.024-0.028 in) 6) Install the spark plug carefully.
- Page 29 Transportation/Storage To prevent fuel leakage during transport or temporary storage, turn off the oil switch and place the generator in a location where no fuel leaks. WARNING When transporting the generator： Do not fill too much fuel into fuel tank. (There should be no fuel in the filler). ...
-
Page 30: Troubleshooting
2) Exhaust oil. Remove the spark plug, pour a tablespoon of clean oil into the cylinder, pull the start handle a few times to scatter the oil, and then install the spark plug back. Pull the handle slowly until it feels pressure. At this moment, the piston is rising to the top of its compression stroke and the exhaust valve is closed. - Page 31 4. Pull the start handle, spark should jump from the gap. NOTICE Ensure that the engine is cooled down when you check the spark plug, or the high temperature of the engine and spark plug will cause burns. Connected device does not work Is the output indicator ON or OFF? Return the generator to an authorized Is overload indicator ON?
-
Page 32: Specification
Specification Size and Weight FG1600i-A Model L x W x H (mm) 310*310*380 Net weight (kg) 15.5kg Engine Model XG154F Type 4-Stroke, 1-Cylinder, OHV Displacement 89cm Compression Ratio Engine Speed 3600rpm Cooling System Forced Air-Cooled Ignition System Oil Capacity 0.4 L Fuel Tank Capacity 4.5 L... -
Page 33: Ce Declaration Of Conformity
: +33 (0)5.34.502.503 States that the designated below machine: Product: Petrol Inverter generator Model: FG1600i-A Serial number: 20211201376-20211201650 I s in confirmity with the essential requirements and other relavantprovisions of the applicable European Directives,basedon the application of European harmonizedstanderds.Anyunauthorized modification of the apparatus voids thisdeclaration. -
Page 34: Warranty
WARRANTY WARRANTY The manufacturer guarantees the product against defects in material and workmanship for a period of 2 years from the date of the original purchase. The warranty only applies if the product is for household use. The warranty does not cover breakdowns due to normal wear and tear. The manufacturer agrees to replace parts identified as defective by the designated distributor. -
Page 35: Product Failure
PRODUCT FAILURE WHAT TO DO IF MY MACHINE BREAKS DOWN? If you bought your product in a store: a) Empty the fuel tank. b) Make sure that your machine is complete with all accessories supplied, and clean! If this is not the case, the repairer will refuse the machine. -
Page 36: Warranty Exclusions
WARRANTY EXCLUSIONS THE WARRANTY DOES NOT COVER: • Start-up and setting up of the product. • Damage resulting from normal wear and tear of the product. • Damage resulting from improper use of the product. • Damage resulting from assembly or start-up not in accordance with the user manual. •...