Table of Contents
Advertisement
9-3. Servicing Compressor Air Cleaner
2
Optional
Keep nozzle
2 in (51 mm)
from element.
.
Complete Parts List available at www.MillerWelds.com
3
4
Blow
Inspect
!
Stop engine.
1
NOTICE − Do not run air compressor
without air cleaner or with dirty element.
Compressor damage caused by using a
damaged element is not covered by the
warranty.
.
The air cleaner primary element can
be cleaned but the dirt holding capac-
ity of the filter is reduced with each
cleaning. The chance of dirt reaching
the clean side of the filter while clean-
ing and the possibility of filter damage
makes cleaning a risk. Consider the
risk of unwarrantable equipment
damage when determining whether
to clean or replace the primary ele-
ment.
NOTICE − If you decide to clean the pri-
mary element, we strongly recommend
installing an optional safety element to
provide additional engine protection.
Never clean a safety element. Replace
the safety element after servicing the pri-
mary element three times.
1
Compressor Air Cleaner
Service air cleaner element if red band
appears in window. A green band means
air cleaner is okay. Press button to reset
indicator.
5
Clean or replace primary element if dirty
(see note above before cleaning). Re-
place primary element if damaged. Re-
place primary element yearly or after six
cleanings.
2
Housing
3
Safety Element (Optional)
4
Primary Element
5
Cover
6
6
Dust Ejector
To clean air filter
Wipe off cover and housing. Remove
cover and dump out dust. Remove ele-
ment(s). Wipe dust from inside cover and
housing with damp cloth. Reinstall safety
element (if present). Reinstall cover.
!
Do not clean housing with air
hose.
Clean primary element with compressed
air only.
Air pressure must not exceed 100 psi
(690 kPa). Use 1/8 in (3 mm) nozzle and
keep nozzle at least 2 in (51 mm) from
inside of element. Replace primary ele-
ment if it has holes or damaged gaskets.
Reinstall primary element and cover
(dust ejector down).
aircleaner1 5/15*−907 634-2 / ST-153 929-B / ST-153 585 / Ref. S-0698-B
OM-267603 Page 61
Advertisement
Table of Contents
