Yamaha FJR13AY 2009 Service Manual page 572

Fault code No. 32
Diagnostic code No.
Order Item/components and probable
cause
1 Connections
• O sensor coupler
2
• Relay unit coupler
• Wire harness ECU coupler
• Sub-wire harness coupler
2 Open or short circuit in wire harness
and/or sub-wire harness.
3 Defective O sensor
2
4 Excessive volume of fuel injected by
injector.
5 The fuel pressure is too high.
Symptom The amount of air-fuel ratio feedback compensation is
maintained continuously in the vicinity of the lower limit
(rich air-fuel ratio).
d:01 Throttle position sensor
Check or maintenance job
• Check the coupler for any pins
• Check the locking condition of
• If there is a malfunction, repair it
• Repair or replace if there is an
• Between O
• Between O
• Between O
Replace if defective. (Unable to
output a rich signal)
• Check the injector.
• Check the fuel pressure.
• Compare the fuel pressures at
• Check the pressure regulator.
• Replace if defective.
• Check the throttle position sen-
• Execute the diagnostic mode.
• Replace if defective.
• Check the fuel system (clog-
• Repair or replace if there is a
8-89
FUEL INJECTION SYSTEM
that may be pulled out.
the coupler.
and connect the coupler se-
curely.
open or short circuit.
sensor coupler and
2
ECU coupler.
(black/blue–black/blue)
(gray/white–gray/white)
sensor coupler and
2
relay unit coupler.
(red/blue–red/blue)
sensor coupler and
2
sub-wire harness coupler.
(black–black)
Refer to "CHECKING THE
FUEL PRESSURE" on page
7-8.
idle and with throttle open.
About the same → Normal
Too high → Refer to the follow-
ing table.
Refer to "CHECKING THE
FUEL PRESSURE" on page
7-8.
sor.
(Code No.d:01)
ging, etc.).
malfunction.
Reinstatement
method
Starting the en-
gine, warming it
up until the
coolant temper-
ature is 60 °C
(140 °F) or
more, and then
running it be-
tween 2000–
3000 r/min un-
til the engine
trouble warn-
ing light turns
off.