SAVE THESE INSTRUCTIONS. This manual contains important safety precautions which should be read and understood before operating the product. Failure to do
so could result in serious injury. This manual should remain with the product.
Specifications, descriptions and illustrations in this manual are as accurate as known at the time of publication, but are subject to change without notice.
Summary of Contents for Champion Global Power Equipment 500987-UK
Page 1
OPERATOR'S MANUAL MODEL #500987-UK 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR REGISTER YOUR PRODUCT ONLINE at championpowerequipment.co.uk Original Instructions +44(0)-1942-715-407 or visit www.championpowerequipment.co.uk SAVE THESE INSTRUCTIONS. This manual contains important safety precautions which should be read and understood before operating the product. Failure to do so could result in serious injury.
INTRODUCTION 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR INTRODUCTION SAfETY DEfINITIONS Congratulations on your purchase of a Champion Power Equipment The purpose of safety symbols is to attract your attention to possible dangers. The safety symbols, and their explanations, (CPE) product.
IMPORTANT SAfETY INSTRUCTIONS 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR IMPORTANT SAfETY INSTRUCTIONS DANGER Operate equipment with guards in place. DANGER Rotating parts can entangle hands, feet, hair, clothing and/or Generator exhaust contains carbon monoxide, a colorless, accessories.
Page 4
IMPORTANT SAfETY INSTRUCTIONS 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR WARNING CAUTION Spark from removed spark plug wire can result in fire or Improper treatment or use of the generator can damage it, electrical shock. shorten its life or void the warranty.
IMPORTANT SAfETY INSTRUCTIONS 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR fuel Safety DO NOT move or tip the generator during operation. When transporting or servicing the generator: DANGER Always check that the fuel valve is in the OFF position and the petrol tank is empty.
IMPORTANT SAfETY INSTRUCTIONS 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Lithium-ion battery Safety – Store the battery in a dry, well ventilated area between -4°F (-20°C) and 104°F (40°C). Electrolyte inside the battery is harmful to skin and eyes. If the –...
Page 7
IMPORTANT SAfETY INSTRUCTIONS 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Safety and Dataplate Labels These labels warn you of potential hazards that can cause serious injury. Read them carefully. If a label comes off or becomes hard to read, contact Technical Support Team for possible replacement.
IMPORTANT SAfETY INSTRUCTIONS 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Safety Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product.
Page 9
IMPORTANT SAfETY INSTRUCTIONS 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR SYMBOL MEANING Read Operator’s Manual. To reduce the risk of injury, user must read and understand operator’s manual before using this product. This product uses lithium-ion (Li-ion) batteries. Local, state, or federal laws may prohibit disposal of batteries in ordinary trash.
IMPORTANT SAfETY INSTRUCTIONS 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Operation Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product.
IMPORTANT SAfETY INSTRUCTIONS 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Quick Start Label Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product.
CONTROLS AND fEATURES 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR CONTROLS AND fEATURES Read this operator’s manual before operating your generator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference.
CONTROLS AND fEATURES 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Control Panel 1. Intelligauge with Power Meter – See Intelligauge with RECEPTACLES Power Meter section. (2×) 240V AC, 13A 2. Ignition Switch – Used to START the generator.
Page 14
CONTROLS AND fEATURES 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Intelligauge with Power Meter The meter is divided into two seperate displays. The LCD displays each mode for several seconds and then automatically cycles through. The Power Meter LED displays output in percent (%) with 100% at the top.
CONTROLS AND fEATURES 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Wireless Remote Control This generator is equipped with a wireless remote control system for starting and stopping. The system consists of (5) main components: 1. Receiver Control Module (RCM) 2.
CONTROLS AND fEATURES 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Parts Included Accessories Oil Funnel ............
Page 17
IMPORTANT ASSEMbLY 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR ASSEMbLY Connect the battery 1. Remove the non recoil side maintenance cover by removing Your generator requires some assembly. It must be properly the two screws with a phillips head screw driver serviced with fuel and oil before operation.
Page 18
ASSEMbLY 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR 2. Turn the oil access cover fastener to the unlocked position NOTICE and remove the cover. Once oil has been added, a visual check should show oil about 1-2 threads from running out of the fill hole.
Page 19
ASSEMbLY 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Add fuel Empty Full DANGER Petrol vapors are highly flammable and extremely explosive. DO NOT light or smoke cigarettes. Fire or explosion can cause severe burns or death. Only fill or drain fuel outdoors in a well-ventilated area. DO NOT pump petrol directly into the generator.
OPERATION 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR – The generator system ground connects lower frame cross- NOTICE member below the alternator. The system ground is connected to the AC neutral wire. The generator engine works well with 10% or less ethanol blend petrol.
OPERATION 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR WARNING During operation the muffler and exhaust fumes will become hot. If adequate cooling and breathing space are not supplied, or if the generator is blocked or enclosed, temperatures can become extremely heated and may lead to fire.
OPERATION 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR 6. Push and hold the wireless set button approximately three 2. Turn the EZ Start Dial to the “ON” position. seconds until the blue LED on wireless set button turns off.
Page 23
OPERATION 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR 3. Turn the EZ Start Dial to the “ON” position. 6. Do not over-choke. As soon as engine starts, push the choke button one time to set the choke to the “RUN” position. Choke button will no longer be illuminated when in “RUN”...
OPERATION 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR 4. Push the choke button one time to set the choke to the NOTICE “CHOKE” position. Choke button will illuminate when in If the engine starts but does not run make certain that the “CHOKE”...
OPERATION 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR NOTICE For electric and manual starts only (not wireless remote start): Keep choke in “CHOKE” position for only 1 start attempt. After first start attempt, move the choke to the “RUN”...
OPERATION 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Eco (Economy) Mode 1. Select the electrical devices you plan on running at the same time. The Eco Mode button can be activated to turn on economy control 2. Total the running watts of these items. This is the amount of in order to minimize fuel consumption and noise while operating power you need to keep your items running.
Parallel Operation WARNING The Champion model 500987-UK is parallel ready and can be This 12V DC socket is unregulated and it is not recommended operated in parallel with another Champion unit to increase the running any piece of equipment off it otherwise you could total available electrical power.
OPERATION 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR 1. Turn off and unplug all electrical connected loads. Never start 1. Begin by raising the folding handle, found on opposite side of or stop the generator with electrical devices plugged in or wheels.
MAINTENANCE 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR 1. Use a damp cloth to clean exterior surfaces of the generator. WARNING 2. Use a soft bristle brush to remove dirt and oil. Operation using the alternative main jet at elevations lower 3.
MAINTENANCE 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR NOTICE Once oil has been added, a visual check should show oil about 1-2 threads from running out of the fill hole. If using the dipstick to check oil level, DO NOT screw in the dipstick while checking.As a general rule on a flat level surface oil is full...
MAINTENANCE 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR battery must be connected to a standard automotive style battery charger for re-charging before it can be used. Disconnect the Battery 1. Pull two halves of battery connector apart. 5. Replace the spark arrestor and spark arrestor screen if it they damaged.
MAINTENANCE 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Remote Key fob battery The air-fuel mixture is not adjustable. Tampering with the governor can damage your generator and your electrical devices and Batteries have a shelf life and after time used or unused will will void your warranty.
STORAGE 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR STORAGE 10. SLOWLY pull the recoil to rotate the engine to distribute and lubricate the cylinder. WARNING 11. Re-install the spark plug and spark plug wire. 12. Re-install the maintenance cover.
STORAGE 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Removing from Storage NOTICE If the generator has been improperly stored for a period longer than 30 days with ethanol blended petrol in the fuel tank and/ or carburetor, all fuel must be drained and the carburetor must be thoroughly cleaned of ethanol build up.
SPECIfICATIONS 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR SPECIfICATIONS Oil Specifications DO NOT OVERFILL. Generator Specifications Type ..........*See following chart Generator Model ........
TROUbLESHOOTING 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR TROUbLESHOOTING Problem Cause Solution No fuel. Add fuel. Faulty spark plug. Clean and adjust spark plug or replace. Fill crankcase to the proper level. Low oil level. Place generator on a flat, level surface.
Page 39
TROUbLESHOOTING 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR Problem Cause Solution Engine governor defective. Contact the help line. Dirty fuel valve. Clean the fuel valve. Carburetor is dirty and running lean. Contact the help line. Engine hunts or falters.
WARRANTY* 500987-UK - 3500W RATED WIRELESS REMOTE START INVERTER GENERATOR WARRANTY* warranty and is not required to be performed at a facility or by a person authorized by CPE. CHAMPION POWER EQUIPMENT 3 YEAR LIMITED WARRANTY Other Exclusions This warranty excludes: Warranty Qualifications –...