SAVE THESE INSTRUCTIONS. This manual contains important safety precautions which should be read and understood before operating the product. Failure to do
so could result in serious injury. This manual should remain with the product.
Specifications, descriptions and illustrations in this manual are as accurate as known at the time of publication, but are subject to change without notice.
This product meets the requirements of the PGMA (Portable Generator Manufacturers' Association) standard ANSI/PGMA G300-2015 (Safety and Performance of
Portable Generators).
REV 20210104
Champion Power Equipment, Inc., Santa Fe Springs, CA USA
Summary of Contents for Champion Global Power Equipment 201001
Page 1
OPERATOR'S MANUAL MODEL #201001 5500W WIRELESS REMOTE START INVERTER GENERATOR REGISTER YOUR PRODUCT ONLINE at championpowerequipment.com or visit championpowerequipment.com SAVE THESE INSTRUCTIONS. This manual contains important safety precautions which should be read and understood before operating the product. Failure to do so could result in serious injury.
Page 2
CARBON MONOXIDE SAFETY: THE BIG PICTURE As the only safe way to use a portable generator, taking your generator outside is absolutely mandatory to keep your family safe from carbon monoxide. But there’s even more you can do. By educating yourself about all carbon monoxide risks, you’ll be better prepared to protect your family from this colorless, oderless threat.
INTRODUCTION 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR INTRODUCTION SAfETY DEfINITIONS Congratulations on your purchase of a Champion Power Equipment The purpose of safety symbols is to attract your attention to possible dangers. The safety symbols, and their explanations, (CPE) product.
IMPORTANT SAfETY INSTRUCTIONS 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR IMPORTANT SAfETY INSTRUCTIONS DANGER Operate equipment with guards in place. WARNING Rotating parts can entangle hands, feet, hair, clothing and/or Cancer and Reproductive Harm – www.P65Warnings.ca.gov accessories. Traumatic amputation or severe laceration can result.
Page 6
IMPORTANT SAfETY INSTRUCTIONS 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR WARNING CAUTION Spark from removed spark plug wire can result in fire or Improper treatment or use of the generator can damage it, electrical shock. shorten its life or void the warranty.
IMPORTANT SAfETY INSTRUCTIONS 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR fuel Safety When transporting or servicing the generator: Always check that the fuel valve is in the OFF position and the DANGER gasoline tank is empty. For LPG compatible models, check that the LPG cylinder is GASOLINE AND GASOLINE VAPORS ARE HIGHLY disconnected and stored securely away from the generator.
IMPORTANT SAfETY INSTRUCTIONS 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Safety and Dataplate Labels These labels warn you of potential hazards that can cause serious injury. Read them carefully. If a label comes off or becomes hard to read, contact Technical Support Team for possible replacement.
IMPORTANT SAfETY INSTRUCTIONS 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Safety Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product.
IMPORTANT SAfETY INSTRUCTIONS 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Operation Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product.
IMPORTANT SAfETY INSTRUCTIONS 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Quick Start Label Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product.
CONTROLS AND fEATURES 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR CONTROLS AND fEATURES Read this operator’s manual before operating your generator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference.
CONTROLS AND fEATURES 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Control Panel 1. Intelligauge with Power Meter – See Intelligauge with RECEPTACLES Power Meter section. 12V DC, 8A (Automotive) 2. Ignition Control Button May be used to supply electrical power for 3.
CONTROLS AND fEATURES 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Intelligauge Five mode digital meter for displaying voltage, frequency (hertz), run time, total run time and power output. MODE DESCRIPTION Output voltage of the generator. Example: 120 volts Voltage (V) Output frequency in hertz.
CONTROLS AND fEATURES 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Wireless Remote Control fCC Statement for Remote Control Device This generator is equipped with a wireless remote key fob 1. This device complies with Part 15 of the FCC Rules. Operation system for starting and stopping.
CONTROLS AND fEATURES 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Parts Included Accessories Dual Port USB Adapter (5v/2.4A) ........Remote Key Fob ............
ASSEMbLY 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR ASSEMbLY Add Engine Oil Your generator requires some assembly. It must be properly WARNING serviced with fuel and oil before operation. DO NOT attempt to crank or start the engine before it has been If you have any questions regarding the assembly of your properly filled with the recommended type and amount of oil.
ASSEMbLY 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR 3. Remove oil fill cap/dipstick to add oil. NOTICE 4. Using a funnel, add up to 20.3 fl. oz. (600 ml) of oil (included). The first 5 hours of run time are the break-in period for the DO NOT OVERFILL.
ASSEMbLY 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR 2. Slowly add gasoline to the tank. Tank is full when gasoline NOTICE reaches red circle on screen. DO NOT OVERFILL. Gasoline can expand after filling. A minimum of ¼ in. (6.4 mm) of space left...
OPERATION 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Neutral Bonded to Frame* WARNING – Neutral circuit IS electrically connected to the frame/ground of During operation the muffler and exhaust fumes will become the generator. hot. If adequate cooling and breathing space are not supplied, –...
OPERATION 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Wireless Set button 4. Push and release the STOP $ button on the remote key fob. The green LEDs on the remote key fob and the Ignition The wireless set button is a feature that lets the user synchronize Control Button will blink once simultaneously to indicate the remote key fob to the generator.
OPERATION 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR 3. Press and release the “START” button on the remote control. NOTICE DO NOT hold the button down, only press the button once. The engine will attempt to start six times.
Page 23
OPERATION 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR 3. Press the ignition control button to start the engine. If engine 4. Press the “CHOKE” button. does not start, wait at least ten seconds before attempting to start the engine again.
OPERATION 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Manual Choke Start 5. Pull the recoil cord until resistance is felt, then pull rapidly. If the battery is dead or not able to produce enough current to power the push button choke, the choke itself can be operated manually to help start the engine.
OPERATION 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR WARNING Always remember to plug your appliances directly into the generator and do not plug the generator power cord into any electrical outlet or connect to the circuit breaker panel in your home.
Eco Mode should be off. Parallel Operation 12V DC Automotive Style Outlet The Champion model 201001 is parallel ready and can be The 12V DC outlet(s) can be used with supplied accessories and operated in parallel with another Champion unit to increase the other commercially available 12V DC automotive style plugs.
OPERATION 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Moving the Generator To completely shut down the generator, make sure the fuel dial is in the “OFF” position when the generator will not be used for an extended period of time.
MAINTENANCE 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Operation at High Altitude NOTICE The density of air at high altitudes is lower than at sea level. For Emission control devices and systems, read and Engine power is reduced as the air mass and air-fuel ratio understand your responsibilities for service as stated in the decrease.
MAINTENANCE 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR 4. Use pliers to slide the spring clamp down the oil drain hose and pull the hose off the plug bracket. 4. Inspect the electrode on the plug. It must be clean and not worn to produce the spark required for ignition.
MAINTENANCE 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR 2. Locate the air filter plastic cover and remove by rotating the 6. Position the spark arrestor and cover plate on the muffler and fastener counterclockwise and pull the cover off.
MAINTENANCE 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Adjusting the Governor Remote Key fob battery WARNING NOTICE Tampering with the factory set governor will void your – Always purchase the correct size and grade of battery warranty.
STORAGE 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR 1. If not using the generator for 2-4 weeks, begin by making EVERY 8 HOURS OR PRIOR TO EACH USE sure all appliances are disconnected from the generator. Check oil level 2.
STORAGE 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Removing from Storage 8. After fuel has run out and the engine has stopped, allow the engine to cool. NOTICE 9. Remove maintenance cover. 10. Remove the spark plug and pour about a tablespoon of oil into If the generator has been improperly stored for a period the cylinder.
TROUbLESHOOTING 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR TROUbLESHOOTING Problem Cause Solution No fuel. Add fuel. Faulty spark plug. Clean and adjust spark plug or replace. Fill crankcase to the proper level. Low oil level. Place generator on a flat, level surface.
Page 36
TROUbLESHOOTING 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR Problem Cause Solution Poor cord connection. Check all connections. Circuit breaker is open. Reset circuit breaker. Check all circuit breakers. Faulty brush assembly. Replace brush assembly (Service Center). Engine is running but no AC output.
WARRANTY 201001 - 5500W WIRELESS REMOTE START INVERTER GENERATOR WARRANTY* Other Exclusions This warranty excludes: CHAMPION POWER EQUIPMENT – Cosmetic defects such as paint, decals, etc. 3 YEAR LIMITED WARRANTY – Wear items such as filter elements, o-rings, etc. Warranty Qualifications –...
Page 38
CHAMPION POWER EQUIPMENT, INC. (CPE) AND THE UNITED STATES ENVIRONMENT PROTECTION AGENCY (U.S. EPA) EMISSION CONTROL SYSTEM WARRANTY Your Champion Power Equipment (CPE) engine complies with U.S. EPA emission regulations. YOUR WARRANTY RIGHTS AND OBLIGATIONS: The US EPA AND CPE are pleased to explain the Federal Emission Control Systems Warranty on your 2021 small off-road engine (SORE) and engine powered equipment.
Page 39
EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System (ECS) Warranty Coverage. 1. APPLICABILITY: This warranty shall apply to 1997 and later model year small off-road engines (SORE). The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter.
Page 40
EMISSION-RELATED PARTS INCLUDE THE FOLLOWING: (using those portions of the list applicable to the engine) Systems covered by this Parts Description warranty Fuel Metering System Fuel regulator, Carburetor and internal parts Air Induction System Air cleaner, Intake manifold Ignition System Spark plug and parts, Magneto ignition system Exhaust System Exhaust manifold, catalytic converter...