Dodge R1500 1999 Service Manual page 42

1999 MANUAL A/C-HEATER SYSTEMS
Trouble Shooting - Cars & Trucks
CHRYSLER
Avenger, Breeze, Caravan, Cirrus, Concorde, Dakota, Durango,
Intrepid, LHS, Neon, Ram Pickup, Ram Van/Wagon, Sebring Convertible,
Sebring Coupe, Stratus, Town & Country, Voyager, 300M
A/C SYSTEM DIAGNOSIS
RAPID COMPRESSOR CLUTCH CYCLING
Some possible causes of rapid compressor clutch cycling,
clutch cycles 10 or more times per minute, include:
* Low refrigerant system charge.
* Faulty low pressure cycling clutch switch.
* Faulty PCM.
COMPRESSOR WILL NOT ENGAGE
Some possible causes of compressor not engaging with high and
low side system pressures equal include:
* No refrigerant in system.
* Faulty fuse.
* Faulty compressor clutch coil.
* Faulty compressor clutch relay.
* Faulty electronic cycling clutch switch.
* Improperly installed or faulty low pressure cycling clutch
switch.
* Faulty low pressure cut-off switch.
* Faulty high pressure cut-off switch.
* Faulty PCM.
* Faulty A/C-heater control panel.
TEMPERATURE IS TOO HIGH WITH A/C ON
Some possible causes of high temperature output at center
panel when A/C system pressure is normal include:
* Excessive oil charge in refrigerant.
* Temperature control cable improperly installed or faulty.
* Blend-air door inoperative, obstructed or sealing
improperly.
* Blend door actuator not calibrated.
LOW SIDE PRESSURE IS LOW-TO-NORMAL & HIGH SIDE PRESSURE IS
LOW
Some possible causes of low side system pressure being lower-
to-normal and high side system pressure being too low include:
* Low refrigerant system charge.
* Refrigerant flow through accumulator is restricted.
* Refrigerant flow through evaporator is restricted.
* Faulty compressor.
LOW SIDE PRESSURE IS HIGH-TO-NORMAL & HIGH SIDE PRESSURE IS
A/C-HEATER SYSTEM TROUBLE SHOOTING
1999 Dodge Pickup R1500