Blue Seal EVOLUTION Series Service Manual
  1. Manuals
  2. Brands
  3. Blue Seal Manuals
  4. Hob
  5. Evolution Series
  6. Service manual

Blue Seal EVOLUTION Series Service Manual

Gas / electric convection oven ranges
Hide thumbs Also See for EVOLUTION Series:
Table of Contents

Advertisement

Quick Links

Download this manual
Gas / Electric Convection Oven Ranges
Gas/Electric Convection Oven Ranges
Blue Seal Evolution Series Gas / Electric Convection Ranges
Amendment 10
GE54 / GE56 / GE58
GE54 / GE56 / GE58
Service Manual
Service Manual
© Copyright Moffat Ltd. 21 June 2016

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the EVOLUTION Series and is the answer not in the manual?

Questions and answers

Related Manuals for Blue Seal EVOLUTION Series

Summary of Contents for Blue Seal EVOLUTION Series

  • Page 1 Gas / Electric Convection Oven Ranges Gas/Electric Convection Oven Ranges GE54 / GE56 / GE58 GE54 / GE56 / GE58 Service Manual Service Manual Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 2 ALL INSTALLATION AND SERVICE REPAIR WORK MUST BE CARRIED OUT BY QUALIFIED PERSONS WARNING: ONLY. IMPORTANT: MAKING ALTERATIONS MAY VOID WARRANTIES AND APPROVALS. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 3: Table Of Contents

    Contents This manual is designed to take a more in depth look at the Blue Seal Gas / Electric Ranges for the purpose of making the units more understandable to service people. There are settings explained in this manual that should never require to be adjusted, but for completeness and those special cases where these settings are required to change, this manual gives a full explanation as to how, and what effects will result.
  • Page 4 Specifications Dimensions - GE54 Dimensions - GE56 Refer to Page 3 for Cook Top Options Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 5: Specifications

    Specifications Dimensions - GE58 Refer to Page 3 for Cook Top Options Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 6 Cook Top Options GE56-B Cook Top Options GE56-A Cook Top Options GE58-D Cook Top Options GE58-C Cook Top Options GE58-A Cook Top Options GE58-B Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 7 Operating pressure is ex-factory set, through the appliance regulator and is not to be adjusted, apart from when carrying out gas conversion, if required. (Refer to ‘Gas Conversion’ section for details). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016...
  • Page 8 (GE54), 32mm (GE56), 35mm (GE58) from the rear, 655mm from the floor and is reached from beneath the appliance. (Refer to the ‘Dimensions’ section). Connection is ¾" BSP male thread. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 9 Refer to the appropriate wiring standards for the size of cable that is to be supplied to an appliance for the current drawn on that line. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016...
  • Page 10 Blue Seal Gas / Electric Range Convection Ovens are designed to provide years of satisfactory service, and correct installation is essential to achieve the best performance, efficiency and trouble-free operation.

  • Page 11: Installation

    O NOT USE A NAKED FLAME TO CHECK FOR GAS LEAKAGES NOTE: The burner operating pressure is to be measured at the manifold test point with 2 burners operating at ‘Full’ setting. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 12 Connect power supply to the appliance. Check electrical supply is within the input rating specification, refer to ‘Specifications’ section). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 13 If for some reason it is not possible to get the appliance to operate correctly, shut ‘Off’ the gas supply and contact the supplier of this appliance. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016...
  • Page 14 OFF Position LOW Flame Position Position Rear Burner Position Front Burner Position Position (Indicators are located above the Gas Control Knobs). HIGH Position Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 15: Operation

    Fault Diagnosis section and / or Service section to assist in correction of the fault. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 16: Maintenance

    Customers Name (print): Title: Customers signature: Date: It is recommended that this form is photocopied and kept on file for continued use. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 17 Check supply pressure. incorrect colour (yellow / wavy). Incorrect injector size. Check injector for correct size. Obstruction in burner. Inspect burner for obstruction. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 18 (Refer Fault Diagnosis 5.2.1). (Refer Service Section 6.2.4 / 6.3.4). Gas magnet faulty. Replace gas magnet. (Refer Fault Diagnosis 5.2.1). (Refer Service Section 6.3.7). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 19 Incorrect gas pressure. Check supply / adjust pressure. (Refer Specifications Section). Faulty gas control valve. Replace griddle burner gas control valve. (Refer Service Section(6.4.1). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 20 Check supply / adjust pressure. knob released. (Refer Specifications Section). Low fire adjustment incorrect. Adjust griddle low fire setting. (Refer Service Section 6.6.4). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 21 (Refer Fault Diagnosis 5.2.3). (Refer Service Section 6.5.7). (From Lot#0817000). Top element faulty. Replace top element. (Refer Fault Diagnosis 5.2.3). (Refer Service Section 6.5.1). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 22 If thermocouple milli-voltage is above 10mV, and the pilot still will not hold, the gas magnet is faulty - replace the gas magnet. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 23: Fault Finding

    Set thermostat to 180°C. Close oven door and allow oven thermostat to regain temperature. If the temperature overshoots by 50°C and continues, switch ‘Off’ oven and replace thermostat. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 24 Ensure gas and electrical supplies are switched ‘Off’ before commencing servicing.  Always Check / Test for gas leaks on completion of Service Repairs on the Gas System. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 25: Service Procedures

    Griddle Burner Aeration ..........................44 6.6.4 Griddle Low Fire Adjustment ........................45 6.6.5 Oven Thermostat Calibration ........................45 6.6.6 Door Microswitch Adjustment ........................45 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 26: Access

    Disconnect indicator light connections on rear of hob. control panel. Remove the control panel. Drip Tray Screw Two Screws Figure 6.1.1 Figure 6.1.2 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 27: Replacement - Open Burners (Up To Ser No. 718549)

    Cap Screws Figure 6.2.1f Figure 6.2.1c Re-assemble in reverse order. NOTE: Ensure burner bowls are seated correctly on cap screw heads when re-assembling. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 28: Open Burner Main Injector

    2 Pilot Burner Shield Screws Ensure when re-assembling, that burner bowls are seated correctly on locating pins. Figure 6.2.3a Remove burner guard. (refer 6.2.1). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 29: Open Burner Thermocouple

    ¼ turn only. Do not over-tighten. NOTE: When screwing thermocouple back into gas control, once threaded up tighten up another ¼ turn only. Do not over-tighten. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 30: Replacement - Open Burners (From Ser No. 718550)

    Replace and re-assemble in reverse order. Burner Body Figure 6.3.1b Remove control panel (refer 6.1.1 access). Disconnect Gas Connections Figure 6.3.1c Disconnect gas valves from gas connections. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 31: Open Burner Venturi

    Re-assemble in reverse order. NOTE: When screwing thermocouple back into gas control, once threaded up tighten up another ¼ turn only. Do not over-tighten. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 32: Open Burner Gas Control

    Pilot Tube turn only. Do not over-tighten. Remove Pilot Supply Screw Tube Figure 6.3.6c Clean or replace as necessary, re-assemble in reverse order. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 33: Gas Control Magnet (Cooktop Burners Only)

    When re-fitting pilot tube and thermocouple to Burner Mounting Rail, loosely fit 2 pilot burner shield securing screws to prevent damage to thermocouple. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 34: Replacement-Griddle Burner

    Clean or replace as necessary and re-assemble in reverse order. Gas Control Valve Magnet Rear Nut Figure 6.4.2b Replace and re-assemble in reverse order. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 35: Griddle - Pilot Burner

    ¼ turn only. Do not over-tighten. Pilot Supply Tube Figure 6.4.6 Clean or replace as necessary, and re-assemble in re- verse order. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 36: Griddle - Pilot Burner Spark Electrode

    Remove control panel (refer 6.1.1). Remove H.T. lead from rear of piezo ignitor and pilot electrode. Figure 6.4.9 Replace and re-assemble in reverse order. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 37: Replacement - Oven

    25.6 ohms. Figure 6.5.3 Replace motor and re-assemble in reverse order. NOTE: Always replace the motor mounting bushes when replacing the motor. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 38: Fan Motor Capacitor

    From back push neon through front of control panel rotating clockwise. Push new neon in from front of control panel, and reconnect wires. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 39: Door Microswitch

    Before re-fitting control panel, make sure that the microswitch is clicking ‘On’ and ‘Off’ when the oven door is opened and closed. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 40: Oven Door

    Lift out door in a rising, half circular motion similar to the orientation of the door when closing (refer to figures 6.5.10c, d and e). Figure 6.5.10e Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 41: Oven Door Hinges & Springs (Units Up To Lot No.0838999)

    If access to tensioning nut is restricted, by screw Figure 6.5.11c shown above, slacken off screw shown to allow better access.   Remove spring from eyelet bolt and door hinge. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 42 If Door Pivot Pin will not sit flush in door frame, run a Ø12mm drill through hole. Only enlarge enough to make pivot pin a tight fit. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 43: Oven Door Hinges & Springs(Units From Lot No.0839001)

    Remove the oven door outer panelling. Measure and note measurement from tensioning nut to end of threaded spline. Measure this Distance Figure 6.5.12c Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 44 Ensure that Door Pivot Shoulder Screws are fitted into door frames until shoulder of the pin is flush or below side of door frame. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 45 Place protective material here. Figure 6.5.12j Refit oven door and remove locking rods and protective cardboard. Ensure that the door operates correctly. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 46: Adjustment / Calibration

    Adjust the aeration slide as required. Main Burner Aeration Screw Aeration Slide Figure 6.6.3 The most efficient flame is clear blue / green in colour. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 47: Griddle Low Fire Adjustment

    Refit thermostat to rear of switch. Turn ‘On’ power and re-check thermostat calibration. Two Screws Repeat procedure if necessary. Figure 6.6.5 Re-assemble in reverse order. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 48: Accessories

    To Target Top. Cooktop Griddle To Chargrill. 228893 SIMMER PLATE 227016. Cooktop Griddle To Cooktop Griddle. To Griddle. To Griddle Toaster. To Cooktop Electric-Griddle. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 49: Exploded Parts Diagrams

    GE56 Main Assembly ............................ 60 8.3.2 GE58 Main Assembly ............................ 61 8.3.3 Door Assembly ............................62 8.3.4 Racks ................................63 8.3.5 Electrical Assembly ............................64 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 50: Convection Range Gas Cooktop

    OPEN BURNER 300mm MODULE (F) KIT (Does not include Knobs or Pot Stands). 230674 OPEN BURNER 300mm MODULE (F) KIT - UK Only (Does not include Knobs or Pot Stands). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 51: Cooktop Open Burners (Pf Models) - Up To Ser No 718549

    OPEN BURNER 300mm MODULE (PF) KIT (Does not include Knobs or Pot Stands). 230676 OPEN BURNER 300mm MODULE (PF) KIT - UK Only (Does not include Knobs or Pot Stands). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 52: Cooktop Open Burners (F Models) - From To Ser. No. 718550

    OPEN BURNER 300mm MODULE (PF) KIT (Does not include Knobs or Pot Stands). 236239 OPEN BURNER 300mm MODULE (PF) KIT - UK Only (Does not include Knobs or Pot Stands). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 53: Cooktop Open Burners (Pf Models) - From To Ser. No. 718550

    Exploded Parts Diagrams 8.1.4 Cooktop Open Burners (PF Models) - from Ser. No. 718550 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 54 OPEN BURNER 300mm MODULE (PF) KIT - UK Only (Does not include Knobs or Pot Stands). Recommended Parts Level *RPL Number of Units In-Service 5-10 10-50 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 55: Cooktop Griddle Burners

    PILOT BURNER INJECTOR 0.23mm (LPG / PROPANE / BUTANE) 018067 PILOT BURNER INJECTOR 0.60mm (TOWN GAS) 018744 PIEZO IGNITION ELECTRODE 228713 GRIDDLE MODULE KIT Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 56: Gas Manifold Assembly (All)

    HOB - RANGE SUPPLY PIPE 227330 UNION BRASS CONICAL ½ x ¾ BSPT 228610 MANIFOLD 750mm 227278 MANIFOLD 900mm 227279 MANIFOLD 1200mm Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 57: Ge54 Oven Assembly

    CONTROL PANEL 230282 SPILL TRAY 750mm WA 229890 SILL WA 750mm 228401 SIDE PANEL RH 228078 SIDE PANEL LH 227960 BLUESEAL BADGE Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 58: Door Assembly

    DOOR HINGE KIT (INCLUDES 2 x ITEMS 21 & 22) - - - - - - PART OF 21 ABOVE 232822 COMPLETE DOOR ASSEMBLY 750mm Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 59: Racks

    NUT SNU 0530 SPIRE ST (From Lot No. 0817xxx) 227893 OVEN SIDE RACK RH 228106 OVEN RACK 228052 OVEN SOLE PLATE 227892 OVEN SIDE RACK LH Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 60: Electrical Assembly

    Exploded Part Diagrams 8.2.4 GE54 Electrical Assembly FAN ROTATION ANTI-CLOCKWISE WHEN LOOKING INSIDE OVEN Up to Lot No. 0816xxx From Lot No. 0817xxx Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 61 KNOB 6mm HI-4-3-2-1-LO (From Lot No. 0817xxx) 13989 ENERGY REGULATOR 240V 50HZ (From Lot No. 0817xxx) 232211 CONTROL PANEL DRIP GUARD KIT (not illustrated) Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 62: Ge56 / Ge58 Oven Assembly

    SPILL TRAY 900mm WA BSEAL (1 Piece New Style). 229733 SILL WA 900 BS DD 228078 SIDE PANEL LH 228401 SIDE PANEL RH 227960 BLUE SEAL BADGE Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 63: Ge58 Main Assembly

    SPILL TRAY WA 1200mm RH, BSEAL (1 Piece New Style). 229892 SILL WA BSEAL 228078 SIDE PANEL LH 228401 SIDE PANEL RH 227960 BLUESEAL BADGE Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 64: Door Assembly

    DOOR SPRING KIT (INCLUDES 2 SPRINGS) 232402 DOOR HINGE KIT (INCLUDES 2 x ITEM 20 & 21) 227968 PART OF 20 ABOVE 232819 COMPLETE DOOR ASSEMBLY 900mm Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 65: Racks

    228054 OVEN SOLE PLATE EXTENSION 227896 OVEN RACK 227892 OVEN SIDE RACK LH 232355 OVEN BAFFLE UPGRADE KIT (From Lot No 0817xxx) Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 66: Electrical Assembly

    Exploded Part Diagrams 8.3.5 GE56 / GE58 Electrical Assembly Up to Lot No. 0816xxx From Lot No. 0817xxx Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 67 KNOB 6mm HI-4-3-2-1-LO (From Lot No. 0817xxx) 13989 ENERGY REGULATOR 240V 50HZ (From Lot No. 0817xxx) 232211 CONTROL PANEL DRIP GUARD KIT (not illustrated) Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 68: Circuit Schematics

    Circuit Schematics 9.1 Convection Ovens (GE54 / GE56 / GE58) 9.1.1 To Lot Number 0816999 9.1.2 From Lot Number 0817000 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 69: Wiring Diagram

    Wiring Diagram 10.1 Convection Ovens (GE54 / GE56 / GE58) 10.1.1 From Lot Number 0817000 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 70 Wiring Diagram 10.1.2 To Lot Number 0816999 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 71: Service Contacts

    Tel Sales 1800 551 8795 +1 336 661 9546 NATIONAL COVERAGE FOR SERVICE OR MAINTENANCE DIAL FREE CALL 866 673 7937 (USA ONLY). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 72: Appendix A. Gas Type Conversion

    NOTE: The 'Low Fire Screw' should be sealed with coloured paint on completion of low fire adjustment. Low Fire Screw Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 73 NOTE: The 'Low Fire Screw' should be sealed with coloured paint on completion of low fire adjustment. Low Fire Screw Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 74 NOTE: The 'Low Fire Screw' should be sealed with coloured paint on completion of low fire adjustment. Low Fire Screw Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 75 Carry out a ‘Commissioning’ check of the appliance as shown in Installation Section of this manual. Ensure any adjustments done to components that have adjustments / settings paint sealed, these are to be re-sealed. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016...
  • Page 76 Operating pressure is ex-factory set through the appliance regulator and is not to be adjusted, apart from when carrying out gas conversion, if required. (Refer to the ‘Gas Conversion’ section for details). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016...
  • Page 77 Operating pressure is ex-factory set through the appliance regulator and is not to be adjusted, apart from when carrying out gas conversion, if required. (Refer to the ‘Gas Conversion’ section for details). Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016...
  • Page 78 (**) TOWN GAS Only - Adjust burner operating pressure using adjustable gas regulator supplied.  Refer to ‘Gas Conversion and Specifications’ section of this manual for further details. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 79: Appendix B. Hob Type Conversion

    (See Fig 5) and carefully remove the burner module from the cook top. Fig 4 Burner Cap Front Burner Securing Screws Burner Bowl Fig 1 Fig 5 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 80 Secure the burner module in position in the burner box with 2 screws at the front (See Fig 10) and rear (See Fig 13) of the burner. Fig 13 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 81 On completion of the conversion, carry out a complete commissioning of appliance as shown in 'Installation' section of 'Installation and Operation Manual' for this appliance. Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

  • Page 82: Appendix C Removing Hob From Range

    Lift out door in a rising half circular motion similar to the orientation of the door when closing. Fig 2 Cardboard under locking Metal rod through locking hole Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 83 Remove 3 screws at bottom edge of hob back panel (refer fig 4). Fig 4 Step 5: Gas Connection Break gas connection at rear of unit (refer fig 5). Fig 5 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...
  • Page 84 * Check for gas leaks * Fig 6 Dimensions after dis-assembly. * Width dimension varies according to size of range * Fig 7 Blue Seal Evolution Series Gas / Electric Convection Ranges © Copyright Moffat Ltd. 21 June 2016 Amendment 10...

This manual is also suitable for:

Evolution ge54Evolution ge56Evolution ge58

Table of Contents