Table of Contents
Advertisement
Quick Links
Hampton GCI60
PLEASE READ THIS ENTIRE MANUAL BEFORE INSTALLATION AND USE OF THIS
PELLET-BURNING ROOM HEATER. FAILURE TO FOLLOW THESE INSTRUCTIONS
COULD RESULT IN PROPERTY DAMAGE, BODILY INJURY OR EVEN DEATH.
Contact your building or fire officials about restrictions and installation inspection
I m p r o p e r i n s t a l l a t i o n , a d j u s t m e n t ,
alteration, service or maintenance can
cause injury, property damage, or loss of
life. Refer to this manual. For assistance or
additional information consult an authorized
installer or service agency.
Tested by:
FPI FIREPLACE PRODUCTS INTERNATIONAL, LTD. 6988 Venture St., Delta, BC, Canada V4G 1H4
920-618
requirements in your area.
WARNING:
IMPORTANT: SAVE THESE INSTRUCTIONS
Greenfire® GCi60-2
OWNER'S MANUAL
Pellet Insert
Do not store or use gasoline or other flammable
vapours and liquids in the vicinity of this or
any other appliance.
Installation and service must be performed
by an authorized installer or service agency.
Cast Iron
French Manual: https://bit.ly/3t7lFbE
Manuel en Français : https://bit.ly/3t7lFbE
FOR YOUR SAFETY:
10.03.22
Advertisement
Table of Contents
Related Manuals for HAMPTON BAY Greenfire GCi60-2
Summary of Contents for HAMPTON BAY Greenfire GCi60-2
- Page 1 Greenfire® GCi60-2 OWNER'S MANUAL Cast Iron Pellet Insert French Manual: https://bit.ly/3t7lFbE Manuel en Français : https://bit.ly/3t7lFbE Hampton GCI60 PLEASE READ THIS ENTIRE MANUAL BEFORE INSTALLATION AND USE OF THIS PELLET-BURNING ROOM HEATER. FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN PROPERTY DAMAGE, BODILY INJURY OR EVEN DEATH. Contact your building or fire officials about restrictions and installation inspection requirements in your area.
- Page 2 TO THE NEW OWNER Congratulations! You are the owner of a state-of-the-art Pellet Stove. Thank you for purchasing an FPI FIREPLACE PRODUCT. The pride of workmanship that goes into each of our products will give you years of trouble-free enjoyment. Should you have any questions about your product that are not covered in this manual, please contact the HAMPTON DEALER in your area.
-
Page 3: Table Of Contents
Table of Contents Introduction..................2 Rating Label Location..............4 Fuel Quality................4 Safety Warnings & Recommendations............5 Operating Instructions................6 Dimensions & Specifications............7 Control Board Functions.............8 Automatic Safety Features of Your Pellet Stove......8 Operating Your Pellet Stove............9 Turning Your Pellet Stove Off............10 Slider/Damper Set-Up...............10 Routine Cleaning and Maintenance............11 Optional Service Rail Kit............14 Warranty...................16 Hampton GCI60... -
Page 4: Introduction
Introduction * This manual is designed for the home owner in conjunction with the technical manual. * ating abeL ocation The rating label is located on the top of the hopper. uaLity Fuel quality is important, please read the following: Your Hampton pellet stove has been designed to burn ¼”... -
Page 5: Safety Warnings & Recommendations
Safety Warnings & Recommendations Please read this entire Owner’s Manual before installing or operating your Hampton Pellet Stove. Failure to follow these instructions may result in property damage, bodily injury or even death. Any unauthorized modification of the appliance or use of replacement parts not recommended by the manufacturer is prohibited. - Page 6 Safety Warnings & Recommendations ELECTRICAL: The use of a surge protected power bar is highly recommended. The unit must be grounded. The grounded electrical cord should be connected to a standard 110-120 volts (4.2 Amps), 60 hertz electrical outlet and also must be accessible. If this power cord should become damaged, a replacement power cord must be purchased from the manufacturer or a qualified Hampton dealer.
-
Page 7: Dimensions & Specifications
16 ⁄ Specifications imenSionS 43 ⁄ 11 ¾ 26 ⁄ 24 ¾ 16 ⁄ 33 ⁄ 22 ⁄ 12 ¾ 40 ⁄ 43 ⁄ 11 ¾ 50.000 33 ⁄ 38.000 22 ⁄ 12 ¾ 40 ⁄ Oversize Filler Panel Dimensions Regular Cast Faceplate Dimensions peciFicationS Input rating when using: Wood Pellets/Corn - 55,000BTU (16.1KW•hr) &... -
Page 8: Operating Instructions
Operating Instructions ontRoL oaRd unctionS Note: The Control Panel is located underneath the units Cast Hopper Lid which is attached to a safety switch that will immediatley stop the auger. The switch will stop operation of the stove and display a #4 flash code if the lid is not closed within two minutes. -
Page 9: Operating Your Pellet Stove
Operating Instructions peRating eLLet tove THE UNIT WILL NOT OPERATE WITH THE DOOR OR ASH BOX OPEN. Open the hopper lid only to re- fuel or to adjust the controls. the unit will shut down if the hopper lid is left open for longer than two minutes. -
Page 10: Turning Your Pellet Stove Off
Operating Instructions uRning eLLet tove • MANUAL and HI / LOW mode: To turn the unit OFF, simply press the ON / OFF button. This will stop the feed of pellets. The blowers will continue to operate and cool the stove down. When cool enough, the stove will turn off. • AUTO / OFF mode: To turn the unit OFF, turn the Thermostat down or Timer off. -
Page 11: Routine Cleaning And Maintenance
Routine Cleaning and Maintenance The following list of components should be inspected and maintained routinely to ensure that the appliance is operating at its optimum and giving you excellent heat value. The appliance, flue gas connector and the chimney flue require regular cleaning. Check them for blockage prior to re-lighting after a prolonged shut down period. Check the Burn Pot Liner DAILY TOOLS REQUIRED TO CLEAN UNIT: Torx T-20 Screwdriver, ¼”, 5 /16”... - Page 12 Routine Cleaning and Maintenance Heat eXcHangeR tubeS (Weekly) Front castings removed for The exchanger tube scraper rod handle is located above clarity the firebox door. Move the handle all the way in and out a few times (ONLY WHEN THE UNIT IS COLD) in order to clean away any fly ash that may have collected on the heat exchanger tubes.
- Page 13 Routine Cleaning and Maintenance EXHAUST PASSAGES (Biannually) 1. Swing open the cast door, and unlatch the firebox door. (Both removed for clarity) 2. Remove the burn pot assembly and clean all the parts. 3. Lubricate all screws with FIREBOX LINER penetrating oil.
-
Page 14: Optional Service Rail Kit
Routine Cleaning and Maintenance Optional Service Rail Kit (Part number GCI60-900) 1. Remove Cast Ash Drawer Front. 2. Slide open the Cast Top. 3. Lift off Cast Sides. 4. Clip Side Rails to unit. 5. Attach Front Rail using the quick release pins as shown in Fig. - Page 15 NOTES ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ Hampton GCi60-2 Cast Pellet Insert Owner’s Manual...
-
Page 16: Warranty
WARRANTY Limited Lifetime Warranty FPI Fireplace Products International Ltd. (for Canadian customers) and Fireplace Products U.S., Inc. (for U.S. customers) (collectively referred to herein as “FPI”) extends this Limited Lifetime Warranty to the original purchaser of this appliance provided the product remains in the original place of installation. The items covered by this limited warranty and the period of such coverage is set forth in the table below. - Page 17 WARRANTY Replacement units are limited to one per warranty term. Airtube and baffle replacements are limited to one replacement per term. Unit must be installed according to all manufacturers’ instructions as per the manual. All Local and National required codes must be met. The installer is responsible to ensure the unit is operating as designed at the time of installation.
- Page 18 WARRANTY Limitations of Liability: The original purchaser’s exclusive remedy under this warranty, and FPI’s sole obligation under this warranty, express or implied, in contract or in tort, shall be limited to replacement, repair, or refund, as outlined above. IN NO EVENT WILL FPI BE LIABLE UNDER THIS WARRANTY FOR ANY INCIDENTAL OR CONSEQUENTIAL COMMERCIAL DAMAGES OR DAMAGES TO PROPERTY.
- Page 19 WARRANTY Product Registration and Customer Support: Thank you for choosing a Regency Fireplace. Regency strives to be a world leader in the design, manufacture, and marketing of hearth products. To provide the best support for your product, we request that you complete a product registration form found on our Web Site under Customer Care within ninety (90) days of purchase.
- Page 20 WARRANTY Hampton GCi60-2 Cast Pellet Insert Owner's Manual...
- Page 21 NOTES ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ Hampton GCi60-2 Cast Pellet Insert Owner’s Manual...
- Page 22 NOTES ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ Hampton GCI60 Cast Pellet Insert Owner's Manual...
- Page 23 Hampton GCi60-2 Cast Pellet Insert Owner’s Manual...
- Page 24 Installer: Please complete the following information Dealer Name & Address: ______________________________________________ ___________________________________________________________________ Installer: ___________________________________________________________ Phone #: ___________________________________________________________ Date Installed: ______________________________________________________ Serial #: ____________________________________________________________ Hampton GCI60 Printed in Canada Regency, Hampton and Greenfire are registered and / or proprietary trademarks of FPI Fireplace Products International Ltd. ©...