Operation; Fire And Explosion; Chemicals; Transport, Lifting And Storage - Whisper Power M-SQ27 User Manual

INFORMATION
2.1.5

Operation

External moving parts like fans and V-belts are covered by
the canopy and therefore the M-SQ27 is very safe when the
canopy is closed.
Nevertheless take note of the signs on the
generating set which show symbols in a
triangle indicating danger.
When service has to be carried out while the
engine is running, be aware of moving parts
like V-belts.
•
The generating set should be operated by
authorised personnel only.
•
Be aware of hot parts and especially parts of the
exhaust system and cooling system.
•
If the generating set is unsafe, fit danger notices
and disconnect the battery positive (+) lead so that
it cannot be started until the condition is corrected.
•
Do not attempt to operate the generating set with
a known unsafe condition. Disconnect the battery
positive (+) lead prior to attempting any repairs or
cleaning inside the enclosure.
•
Always consult the manual before carrying out
maintenance.
•
Do not change the settings without consulting the
manufacturer. Keep a record of setting changes in
this manual.
2.1.6

Fire and explosion

Fuels can be flammable. Proper handling limits
the risk of fire and explosion.
•
Avoid refilling the fuel tank while the engine is
running. When oil or fuel is leaking do not use the
generating set.
•
Do not run the engine close to explosives or
gasses.
•
Hydrogen gas generated by charging batteries is
explosive. Take measures for proper ventilation.
Do not smoke or allow sparks, flames, or other
sources of ignition around batteries.
•
Keep a fire extinguisher on hand.
•
Poor electrical connections or using wiring which
is not suited for the rated currents can cause
overheating and possibly fire.
2.1.7

Chemicals

•
Fuels, oils, coolants, and battery electrolyte can be
hazardous to personnel if not treated properly. Do
not swallow or have skin contact with these liquids.
Do not wear clothing that has been contaminated
by fuel or lubricating oil.
•
Gaskets may be manufactured from asbestos.
Particles of this material should not be inhaled as
this may result in fatal diseases.
•
On no account allow any unprotected skin to come
into contact with the injector spray as the fuel may
enter the blood stream with fatal results.
•
Engines may be fitted with seals or O-rings
manufactured from "viton" or similar material.
When exposed to abnormal high temperatures in
excess of 400°C an extremely corrosive acid is
produced which cannot be removed from the skin.
If signs of decomposition are evident, or if in doubt,
always wear disposable heavy duty gloves.
2.2

Transport, lifting and storage

When lifting the generating set avoid any risk
of personal injuries, do not stand under the
generating set.
•
Use soft slings to avoid damage
•
On the engine are lifting eyes, which can be used
to take the generator out of the capsule. The lifting
eyes can also be used to lift the entire generator
set, including the capsule
•
After transporting the generating set check for
damage before installation.
•
Long term storage can have detrimental effects on
engine and alternator. The engine should be put
through an engine preservation procedure. (See
the maintenance chapter)
•
The alternator windings tend to condense. To
minimise condensation, store the generating set in
a dry and warm storage area.