Table of Contents
Advertisement
OPTIONAL FEATURES
Result Output:
Remote Control:
Industrial Interface:
Calibration:
Multi-stream:
Manual stream:
4-20mA Outputs:
Hazardous Area:
CONSUMABLES
Acid & Base:
Instrument Air:
Service:
ANALYSIS PARAMETERS
Oxidation Method:
TOC Measurement:
Measurement Terms:
Measured Components:
*
COD & BOD by correlation algorithm incorporating TOC measured results
Cycle Time:
TIC, TC, VOC, after correlation COD, BOD
Input for remote start / standby
Input for remote stream and range selection (up to 2 online streams)
Input for remote manual grab sample analysis
Network Control Unit for remote access over Internet or Intranet connection
using HTTP over TCP/IP protocol
Modbus, Profibus, Ethernet
(when any of the Modbus, Profibus or Ethernet option is selected, the digital
output signals are sent through the relevant device with its specific
communication protocol)
Automatic Calibration is available.
Calibration is not necessary between every 6 month service intervals.
Up to 2 sample input channels, which can be used for online streams
Manual grab sample channel, which can be used for automatic calibration.
Sample input channels may be configured as manual grab sample channels.
As individual signal up to maximum of 4 or as multiplex signal up to maximum
of 35. Maximum impedance: 500 ohms.
Certification options are available to European Standards (ATEX for Zone 2)
and to North American Standards (Class I Division 1 and Class I Division 2).
Other options are available on request.
Typical Replacement Frequency & Consumption
13-17 weeks/19 Liters (based on standard range and 6 minute analysis cycle)
1.5 bar, - 20°C dew point (free of water, oil and dust)
Average consumption is less than 5.4 m
Filter pack is recommended and available to meet the air quality specification.
BioTector Air Compressor is available for air supply.
6 Monthly Intervals
Patented Two-Stage Advanced Oxidation Process using Hydroxyl Radicals
NDIR measurement of CO
TOC (Total Organic Carbon) including Non-Purgeable Organic Carbon
(NPOC) and Purgeable Organic Carbon (POC)
BioTector TIC&TOC mode measures NPOC
BioTector VOC mode measures TOC as NPOC+POC.
TOC (NPOC)
TOC (NPOC + POC)
TIC
TC
VOC (POC)
COD*
BOD*
from 5 minutes, depending on range and application
3
/hour.
after oxidation
2
Page 35
Advertisement
Table of Contents
